Professional Documents
Culture Documents
Project Goal
Project Scope
Technical Requirements
2
Which two pieces of information does the network designer need to determine if the
Cisco IOS of
a router requires an upgrade? (Choose two.)
3
Which three pieces of information need to be considered when selecting the proper
Cisco IOS
version for an upgrade? (Choose three.)
processor ID
interface type
amount of DRAM
bootstrap version
CCNA Discovery 4.1 - CCNA Discovery Answers
http://ccna-discovery-4.blogspot.com/
4
What are two practices a network technician should follow when installing a new
interface card in
a router? (Choose two.)
Be sure the interface card faceplate does not touch the chassis rear panel.
Do not tighten the captive screws until the router has been powered on and recognizes
the card.
Store the blank faceplate inside the card slot to be used if the card is removed.
Push the interface card into place until the edge connector is seated securely
5
The new serial interface card for the router arrives and the network technician reads
that it is hotswappable.
What does this mean?
The card cannot be installed while the router is powered on because static discharge
could damage the card.
The card cannot be installed until the router is powered off and completely cooled
down.
The card can be installed while the router is powered on if the router supports this
technology.
The card is a replacement and must be installed in the same slot as the card it is
replacing.
6
Refer to the exhibit. A network administrator issues the command shown to gain
knowledge about
a poorly documented network. Which two pieces of information can the network
administrator
discover from the command output? (Choose two.)
The entire network contains a total of five Cisco devices with CDP enabled.
None of the directly connected network devices have been configured with an IP
address.
Five Cisco devices with CDP enabled are directly connected to device C3750-
24_MDF
7
Refer to the exhibit. Which of the three Cisco IOS images shown will load into RAM?
The router selects an image depending on the value of the configuration register.
The router selects the third Cisco IOS image because it is the most recent IOS image.
The router selects the second Cisco IOS image because it is the smallest IOS image.
The router selects an image depending on the boot system command in the
configuration.
The router selects the third Cisco IOS image because it contains the advipservicesk9
image.
8
An administrator wants to download a new Cisco IOS software version to the local
router. Which
command performs this task?
9
Refer to the exhibit. The top of the output shows the Cisco Feature Navigator
regarding a Cisco
CCNA Discovery 4.1 - CCNA Discovery Answers
http://ccna-discovery-4.blogspot.com/
IOS image that the administrator wants to install on a router. Below it is the output
from the show
version command for that router. Which statement is true regarding the capacity of the
router to
run this Cisco IOS image?
10
Which two items are objectives of a WLAN design site survey? (Choose two.)
11
Refer to the exhibit. Which two actions improve the weaknesses of the topology
shown, assuming
that each access layer segment is in its own subnet? (Choose two.)
Implement a reduntant link from all access layer switches to Admin, Dist, and Server
Farm.
Implement reduntant links from the existing firewall to all access layer switches.
12
CCNA Discovery 4.1 - CCNA Discovery Answers
http://ccna-discovery-4.blogspot.com/
A company is beginning to analyze their new Cisco IOS upgrade requirements. What
is one of the
router components that a network administrator must consider when selecting a new
Cisco IOS version?
processor type
compatibility of the bootstrap version with the new Cisco IOS software
13
An employee at a company notices that the wireless signal strength indicator on his
laptop
fluctuates from good to low. The network administrator decides to do a site survey of
that area.
Which three factors need to be included in the survey? (Choose three.)
location of the AP
14
The new network design for AnyCompany must include support of voice and video
traffic. Before
upgrading, the network designer checks whether the existing devices can support the
new
requirements. Which three items does the designer need to check? (Choose three.)
15
A new Cisco IOS version has been copied into flash from a TFTP server. When a
reload is issued
to upgrade the Cisco IOS, the router freezes part of the way through the loading
process. What
could be the problem?
The new Cisco IOS should have been loaded into NVRAM.
The new bootstrap version is not compatible with the original version on the router.
16
Refer to the exhibit. A network designer has no documentation and is attempting to
create a
logical diagram of the network using the output from show commands. What can be
determined
from the output shown?
The Cisco router IOS supports enterprise-level voice and video technologies.
17
A production router is reloaded and finishes with a Router> prompt. What three facts
can be
determined? (Choose three.)
The router did not locate the Cisco IOS in flash, so it defaulted to ROM.
18
During a site survey, the network designer noticed that people were accessing the
company
wireless network from the parking lot. What should be done to stop the wireless
signal from
radiating out into the parking lot?
19
A network design project includes a review of the existing network. What is the
purpose of this
phase of the project?
lower the cost of the project by removing redundant links and devices
determine if the number of applications used within the company can be reduced
To determine what existing network devices require upgrades to meet the new
20
Refer to the exhibit. Based upon the Cisco IOS file naming convention, what is
represented by
the value ipvoicek9 listed in the IOS filename?
CCNA Discovery 4.1 - CCNA Discovery Answers
http://ccna-discovery-4.blogspot.com/
version
file format
feature set
hardware platform
21
Refer to the exhibit. What two items can be determined from the output? (Choose
two.)
22
During a wireless site survey, a consultant is determining the hours of peak
usage and the estimated number of users in each location. The consultant is currently
in what
step of the site survey process?
23
Refer to the exhibit. The network administrator is attempting to install a new version
of the IOS on
R2. Based on the exhibited output, what are two possible reasons that the transfer
failed?(Choose two.)
The administrator did not verify that the TFTP server is running.
24
In which section of the Network Design Requirements document would a network
consulting team detail names and IP addresses of important networking components
and servers,
provide network diagrams and topologies, and define strengths and weaknesses of the
network?
network requirements
project scope