i made a lpt port for programming ( as shown in the diagram)
i am attaching the images of lpt port cable i made. the resistances on the lpt port as measured on the digital meter are MOSI = 487 OHM MISO = 500 OHM SCK = 473 OHM RESET = 483 OHM but i used a (330 ohm resistances ) i connected the vag com obdii pin 16 to +12 V and pin 4 to GND (as shown in images) i connected the lpt port ground to pcb ground as shown in images. Now when i open pony prog 2000 I select the "Avr ISP I/O" Probe TEST is OK Calibration is OK Selected the chip to ATmega 162 but when i try to ERASE or try to open Configuration & Security Bits (LOCKS & FUSES) it gives me "DEVICE MISSING OR UNKNOWN DEVICE (-24) error. I tried to open the LPT BIOS Settings it shows STANDARD MODE
I have also tried to use 1k ohm resistances.
but the result is same. Please help me, what should i do next. It is very difficult to find a USB AVR programmer