You are on page 1of 4

501-05-1

Interior Trim and Ornamentation

501-05-1

REMOVAL AND INSTALLATION


Headliner
Special Tool(s)
Torx Bit, Safety Belt Bolt
501-010 (T77L-2100-A)

Removal and Installation


1.

If equipped with a supplemental restraint


system (SRS), depower the SRS system. For
additional information, refer to Supplemental
Restraint System (SRS) Depowering and
Repowering in Section 501-20B.

2.

Remove the overhead console. For additional


information, refer to Section 501-12.

3.

If equipped with a roof opening panel, remove


the roof opening panel gimp.

5.

6.

Remove the two sun visor brackets.


1

Remove the two screws.

Remove the two sun visor brackets.

Remove the A-pillar assist handles.

4.

Remove the caps and bolts.

Remove the two sun visors.


1

Remove the six screws.

Remove the two sun visors.

If equipped, disconnect the electrical


connectors.

Copyright 2004, Ford Motor Company


Last updated: 06/23/2004

2005 Explorer Sport Trac, 9/2004

501-05-2

Interior Trim and Ornamentation

501-05-2

REMOVAL AND INSTALLATION (Continued)


7.

Remove the A-pillar assist handles.

11. Position the lower C-pillar trim panel aside.


8.

Remove the windshield side garnish mouldings.

12. Open the cover and remove the rear seat safety
belt guide nut.
9.

Open the cover and remove the front seat safety


belt guide nut.

10. Remove the upper B-pillar trim panel.


1

Remove the B-pillar bolt cover.

Remove the bolt.

Remove the upper B-pillar trim panel.

2005 Explorer Sport Trac, 9/2004

501-05-3

Interior Trim and Ornamentation

501-05-3

REMOVAL AND INSTALLATION (Continued)


13. Remove the upper C-pillar trim panel.

17. If equipped, remove the six assist handle bolt


covers.
14. Remove the interior lamp lens.

18. If equipped, remove the three assist handles.


15. Remove the screws and the interior lamp.

Remove the six bolts.

Remove the three assist handles.

16. Remove the roof trim panel.


19. NOTE: The headliner is removed through the
passenger side rear door.
Remove the passenger seat. For additional
information, refer to Section 501-10.
20. Remove the headliner.
2005 Explorer Sport Trac, 9/2004

501-05-4

Interior Trim and Ornamentation

501-05-4

REMOVAL AND INSTALLATION (Continued)


21. To install, reverse the removal procedure.

Transfer components as necessary.

2005 Explorer Sport Trac, 9/2004

You might also like