Professional Documents
Culture Documents
TECHNICAL DATA CABLE GLAND TYPE INGRESS PROTECTION PROCESS CONTROL SYSTEM : A2 : IP66, NEMA 4X : BS EN ISO 9001 : 1211841 : CSA Enclosure Type 4X
INSTALLATION INSTRUCTIONS Installation should only be performed by a competent person using the correct tools. Read all instructions before beginning installation. ACCESSORIES The following accessories are available from CMP Products, as optional extras, to assist with fixing, sealing and earthing :Locknut | Earth Tag | Serrated Washer | Entry Thread (I.P.) Sealing Washer | Shroud*
16
M16 M20 M20 M20 M25 M32 M40 M50 M50 M63 M63 M75 M75 M90
15.0 15.0 15.0 15.0 15.0 15.0 15.0 15.0 15.0 15.0 15.0 15.0 15.0 15.0 15.0 15.0 15.0
8.1 8.7
22.0 24.0 24.0 36.0 41.0 50.0 55.0 60.0 70.0 75.0 79.0 108.0 122.0 138.0 154.0 84.0 27.0
18.0 21.0 21.0 26.0 28.0 29.0 30.0 30.0 30.0 32.0 32.0 48.0 55.0 62.0 44.0 27.0 24.0
20.0 26.3 32.2 38.2 50.0 56.0 62.0 68.0 80.0 91.0 115.0 98.0 44.1
14.0
11.7
20S16A21RA 20SA21RA 20A21RA 25A21RA 32A21RA 50SA21RA 63SA21RA 75SA21RA 75A21RA 90A21RA 63A21RA 50A21RA 40A21RA
16A21RA
PVC02 PVC04 PVC04 PVC05 PVC09 PVC10 PVC13 PVC14 PVC17 PVC20 PVC22 PVC24 PVC26 150/50HST 180/60HST 180/60HST PVC31
0.051 0.054 0.054 0.059 0.112 0.128 0.168 0.224 0.231 0.360 0.344 0.466 0.395 1.575 2.322 3.400
2-1/2 2-1/2 3 3 4 -
3-1/2 3-1/2 -
NOTE: *CMP SOLO LSF Halogen Free Shrouds also available on request.
Registered Office: Glasshouse Street St. Peters Newcastle upon Tyne NE6 1BS Tel: +44 191 265 7411 Fax: +44 191 265 0581 E-Mail: cmp@cmp-products.co.uk Web: www.cmp-products.com Company Number:
CMP PRODUCTS
www.cmp-products.com
1.346
Metric
Standard
Option NPT
www.cmp-products.com
1. It is not necessary to dismantle the gland any further than illustrated below.
2. Fit the gland into the equipment and fully tighten the entry item (1).
5. Pass the cable through the gland to the desired position, then tighten the seal nut by hand until resistance is felt (when the seal contacts the cable). Tighten with a spanner one further turn.
3. Determine the conductor length required to suit the installation and prepare the cable accordingly, removing part of the outer sheath where required to reveal the insulated conductors.
www.cmp-products.com