Professional Documents
Culture Documents
5:1994
ISO/IEC ISP 10608-5:1992
Information technology—
International standardized profile
TAnnnn—Connection-mode
transport service over
connectionless-mode network
service
Information technology—
International standardized profile
TAnnnn—Connection-mode
transport service over
connectionless-mode network
service
STANDARDS AUSTRALIA
1 The Crescent,
Homebush NSW 2140 Australia
PREFACE
This Standard was prepared by the Joint Standards Australia/Standards New Zealand Committee
IT/1 on Information Systems—Interconnection. It is identical with and has been reproduced from
ISO/IEC ISP 10608-5:1992, Information technology—International Standardized Profile
TAnnnn—Connection-mode Transport Service over Connectionless-mode Network Service, Part 5:
TA1111/TA1121 profiles including subnetwork-dependent requirements for X.25 packet-switched
data networks using virtual calls.
This Standard is issued as a Joint Standard under the terms of the Active Cooperation Agreement
between Standards Australia and Standards New Zealand.
The objective of this Standard is to provide users of the OSI 7-layer network with a specification
of subnetwork-type dependent requirements for end system operation when the end system is
attached to a X.25 packet-switched data network by a dedicated access line and using switched
virtual calls.
This is a free 7 page sample. Access the full version at http://infostore.saiglobal.com.
ISO AS/NZS
9542 Information processing systems— 3651 Information processing systems—
Telecommunications and infor- Telecommunications and infor-
mation exchange between sys- mation exchange between sys-
tems—End system to Inter- tems—End system to inter-mediate
mediate system routeing exchange system routing exchange protocol
protocol for use in conjunction for use in conjunction with the
with the Protocol for providing the prot ocol for provi ding t he
connect i onless-mode net work connect i onl ess-mode net work
service (ISO 8473) service
ISO/IEC
8208 Informat ion technology—Dat a 3621 Informat ion technol ogy— Data
communicat ions—X.25 P acket communicat i ons—X.25 packet
Level protocol for Data Terminal layer protocol for data terminal
Equipment equipment
This is a free 7 page sample. Access the full version at http://infostore.saiglobal.com.
CONTENTS
Page
1 Scope . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
2 Normative References . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
3 Definitions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
4 Abbreviations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Annexes
A SNDCF IPRL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
1.1 General
This part of ISO/IEC ISP 10608 specifies subne twork-type depe ndent requi rements for end system opera-
tion when the end system is attached to an X.25 packet-switched data network by a dedicated (permane nt)
This is a free 7 page sample. Access the full version at http://infostore.saiglobal.com.
access line and using switched virtual calls. The Directory of Profiles and ISPs in ISO/IEC TR100 00 identi-
fies this TA profile configu ration as TA1111 or TA1121. The complete set of requ irements for TA11n 1
consists of the requi rements specified in ISO/IEC ISP 10608-1 and ISO/IEC ISP 1060 8-5.
ISO/IEC ISP 1060 8-5 covers the taxonomy ele ments ide ntified as “TA” in the Directory of Profiles and ISPs
containe d in ISO/IEC TR 10000 -2. These ele ments constitute Transport profiles, group A: Conne ction-
mode Transport Service over Conn ectionle ss-mode Network Service.
This clause specifies requi rements for the profile ide ntified in ISO/IEC TR 100 00 as TA11n1, Connection-
mode Transport Service provided over the Conne ction less-modeNetwork Service through dedicated (per-
manen t) access to an X.25 packet-switched data network using virtual calls.
Figure 1 (below) illu strates the standards which comprise the TA1111 and TA112 1 profiles.
Transport ISO 807 3 ISO 807 3/Add.2 Transport Layer ISO 807 3 ISO 807 3/Add.2
Layer
ISO 847 3 ISO 954 2 ISO 847 3 ISO 954 2
Network Layer Network Layer
ISO 820 8 ISO 820 8
Data-lin k Layer ISO 777 6 Data-lin k Layer ISO 777 6
X.25 dedicated access via
Physical Layer X.25 dedicated access via PSTN Physical Layer
digital data circuit
1.3 Scenario
Figure 2 ill ustrates the configuration of systems to which TA11n 1 is app licable.
COPYRIGHT
This is a free preview. Purchase the entire publication at the link below: