Professional Documents
Culture Documents
Group Efacec was formed in 1948 and it is now the largest Portuguese Group in the field of electricity, employing around 4800 people and with a volume of orders that already exceeds $1,400 MUSD, being present in more than 65 countries worldwide.
The Group has been serving US customers since 1998 and as of 2007, established its US Operations headquarters in
Atlanta, GA. In November 2009, a totally brand new power transformers plant started operations as a result of an investment over $140 MUSD; this plant is equipped with the most modern equipment in the world and manufacturing CORE and SHELL technology transformers up to 1,500 MVA and 525 kV.
Transformer Technologies
Main Characteristics:
Interleaved windings, composed of rectangular coils: The coils have a narrow width and a large surface.
All coils are interleaved between pressboard washers with the surface in contact with the coil, covered with small pressboard spacers, assuring coil cooling.
Advantages:
High reliability and inherent design flexibility Excellent dielectric strength to impulse voltages due to a
large series capacitance of the windings and low capacitance to ground
Windings with high air core reactance allow reduced value Excellent cooling capability allows a lower hot spot
temperature due to the vertical arrangement of the coils
Low noise level The Dissociated Phases design flexibility allows separate
transport of the phases and common cover
Main Characteristics:
Concentric windings: The cylindrical coils are formed with a narrow thickness and a large surface area. All of the coils are
insulated by pressboard barriers with pressboard spacers allowing cooling by the free flowing insulating mineral oil.
Magnetic circuit: The circular cross section is formed by vertically positioned sheets. Tightening structure of core and windings: The design is optimized to support the short circuit stress and to allow, not
only the active part untanking, but also the lifting of the complete transformer.
Automatic Hot-Oil Spray drying Automatic Vapor-Phase drying All Manufacturing areas served
with total environmental control (temperature, humidity and particles) transformer filling
Test Facility
Testing Equipment Capabilities: State of the art, brand new test lab with the following capability:
Rated for 60 hz testing All ANSI standard tests except for Short
Circuit
Maximum BIL of 2400 kV Ability to test transformers up to 765 kV Digital impulse measurement equipment Complete DGA analysis capabilities Double testing bank (for simultaneous
testing)
Mobile Substations
Product Range CORE or SHELL up to 60 MVA 245 kV (BIL 1050kV)
Main Characteristics:
Efacec Mobile Substation design, assembling and commissioning are the result of Efacecs substantial experience in the
fields of manufacturing power equipment and/or integrating complete electrical systems.
Research and development is carried out at all levels, to continuously improve reliability. The high level of qualification and experience of Efacec engineering assures high quality of Efacec Mobile Substations
meeting ANSI/IEEE standards and all DOT requirements.
Efacec Mobile Substations are always customer engineered, resulting in a flexible and reliable design.
Efacec USA Headquarters 2755 Northwoods Parkway Norcross, GA 30071 Ph: 770-446-8854
Efacec Power Transformers 2789 Highway 21 South Rincon, GA 31326 Ph: 912-754-5300
Fax: 770-446-8920
Fax: 912-754-6882
www.efacecusa.com
TRF US B1 1103