You are on page 1of 7

Safety Data Sheet

MAGNAFLOC E30
Revision date : 05.07.2010 Version: 1.2 Page: 1/7 (30482626/SDU_GEN_CA/EN)

1. Product and Company Identification


Company BASF Canada Inc. 100 Milverton Drive Mississauga, ON L5R 4H1, CANADA 24 Hour Emergency Response Information CANUTEC (reverse charges): (613) 996-6666 BASF HOTLINE: (800) 454-COPE (2673)

2. Hazards Identification
Emergency overview

Signal word: Colour: Appearance: State of matter: Odour: Health: Physical/Chemical hazards:
Potential health effects

CAUTION: ! white emulsion liquid ammonia-like Contact causes skin irritation., Contact causes eye irritation, Possible reproductive effects., Aspiration hazard. Slip hazard when wet.

Primary routes of entry: Skin, Eyes, Inhalation, Ingestion Chronic exposure: Causes severe eye irritation. May cause respiratory irritation. Avoid inhalation of vapours or mist.

3. Composition/Information on Ingredients
Chemical name Sulfuric acid diammonium salt Distillates (petroleum), hydrotreated light Poly(oxy-1,2-ethanediyl), a-(nonylphenyl)-whydroxyThis product is WHMIS controlled. CAS Number 7783-20-2 64742-47-8 9016-45-9 Content (Weight) 1.0 - 5.0 % 10.0 - 30.0 % 1.0 - 5.0 % Hazardous Y Y Y

Safety Data Sheet


MAGNAFLOC E30
Revision date : 05.07.2010 Version: 1.2 Page: 2/7 (30482626/SDU_GEN_CA/EN)

4. First-aid Measures
Inhalation: Remove to fresh air, if not breathing give artificial respiration. If breathing is difficult, give oxygen and get immediate medical attention. Skin: If clothing is contaminated, remove and launder before reuse. After contact with skin, wash immediately with plenty of water and soap. Get medical attention if irritation occurs. Eyes: Immediately flush the eye(s) with lukewarm, gently flowing water for 15 minutes or until the chemical is removed. Get immediate medical attention if irritation persists. Ingestion: Do not induce vomiting. If vomiting occurs naturally, have casualty lean forward to reduce the risk of aspiration. Seek medical attention immediately.

5. Fire-fighting Measures
Suitable extinguishing media: carbon dioxide, dry powder, foam Unsuitable Extinguishing Media: If water is used, restrict pedestrian and vehicular traffic in areas where slip hazard may exist. Hazardous combustion products: Carbon and nitrogen oxides. Hazards during fire-fighting: Standard procedure for chemical fires. Cool fire-exposed containers with water. The product is slippery when wet. Protective equipment for fire-fighting: Wear self-contained breathing apparatus and chemical-protective clothing.

6. Accidental Release Measures


Personal precautions: Spills are very slippery. Restrict pedestrian and vehicular traffic in area of spill until spill is thoroughly cleaned up. Cleanup: Pick up with inert absorbent material (e.g. sand, earth etc.). Place into approved waste containers. Wear suitable protective equipment. Should not be released into the environment.

Safety Data Sheet


MAGNAFLOC E30
Revision date : 05.07.2010 Version: 1.2 Page: 3/7 (30482626/SDU_GEN_CA/EN)

7. Handling and Storage


Handling

General advice: As with all industrial chemicals, use good industrial practices when handling. Avoid eye, skin, and clothing contact. Do not inhale. Do not taste or swallow. Use only with adequate ventilation. Slip hazard when wet. Clean up spills promptly Product may freeze; however, it should recover upon warming. Should freezing occur, warm slowly. Thawed product should be thoroughly mixed with low shear agitation prior to use. Do not use or store in iron, copper or aluminium containers or equipment.
Storage

General advice: Keep container tightly closed in a dry, cool and well-ventilated place. Store between 10 - 40 C (50 - 104 F). Do not use or store in iron, copper or aluminium containers or equipment. Storage incompatibility: General: Keep away from iron, copper or aluminium containers or equipment > for industrial use only <

8. Exposure Controls and Personal Protection


Exposure Guidelines

Distillates (petroleum), hydrotreated light (64742-47-8) Engineering Controls:

ACGIH

200 mg/m3

Work in well ventilated areas. Do not breathe vapors or mist. Ensure good ventilation and local exhaust.
Personal protective equipment

Respiratory protection: Wear a NIOSH-certified respirator as necessary. Eye protection: Tightly fitting safety goggles (splash goggles) (EN 166) Body protection: Wear chemical resistant gloves and protective clothing. General safety and hygiene measures: Eye wash station and safety shower should be available in immediate work area., Select additional protective equipment based upon potential for exposure.

9. Physical and Chemical Properties


Colour: Form: State of matter: Odour: pH value: white emulsion liquid ammonia-like 5

Safety Data Sheet


MAGNAFLOC E30
Revision date : 05.07.2010 Version: 1.2 Evaporation rate: Flammability: Lower explosion limit: Upper explosion limit: Flash point: Self-ignition temperature: Melting point: Boiling point: Vapour pressure: Density: Vapour density: Partitioning coefficient noctanol/water (log Pow): Viscosity, dynamic: % Volatiles: Solubility in water: Solubility in other solvents: Not tested Not tested Not applicable Not applicable > 93 C Not applicable -18 C > 100 C Not tested 1.0 g/cm3 Not tested Not applicable Not tested not determined dispersible Not tested Page: 4/7 (30482626/SDU_GEN_CA/EN)

10. Stability and Reactivity


Stability: Stable. Conditions to avoid: Avoid humidity. Avoid temperature extremes. Avoid electro-static discharge. Avoid sources of ignition. Substances to avoid: Strong oxidizing agents., (may degrade polymer) Possibility of Hazardous Reactions: No hazardous reactions known. Hazardous decomposition products: No decomposition expected under normal storage conditions.

11. Toxicological Information


Acute oral toxicity:

Not determined.
Acute inhalation toxicity:

Not determined.
Acute dermal toxicity:

Not determined.
Skin irritation:

Note: May produce severe skin irritation under occlusive conditions. Prolonged or repeated skin contact can remove skin oils, possibly leading to dry skin, irritation and/or dermatitis. (Rabbits) Moderate irritant.
Eye irritation:

(Rabbits) Severe Irritant.


Respiratory irritation:

Minute amounts if aspirated into the lungs during ingestion may cause pulmonary injury
Skin Sensitization:

not determined

Safety Data Sheet


MAGNAFLOC E30
Revision date : 05.07.2010 Version: 1.2
Chronic toxicity:

Page: 5/7 (30482626/SDU_GEN_CA/EN)

Contains component(s) at greater than 1% which is a suspected endocrine disruptor.


Subacute Toxicity:

not determined
Subchronic Toxicty:

not determined Genetic toxicity: No test data available Carcinogenicity: None of the components in this product at concentrations greater than 0.1% are listed by IARC; NTP, OSHA or ACGIH as a carcinogen. Reproductive toxicity: Contains component(s) at greater than 1% which is known to cause reproductive effects. Developmental toxicity/teratogenicity: Contains component(s) at greater than 1% which is known to cause teratogenic effects.

12. Ecological Information


Toxicity to fish: Not tested Toxicity to aquatic invertebrates: Not tested Toxicity to aquatic plants: Not tested Toxicity to microorganisms: Not tested Biodegradation: Not tested Other ecotoxicological advice: Limited ecological data are available. May be harmful to the aquatic environment.

13. Disposal Considerations


Waste disposal of substance: Dispose of in accordance with national, state and local regulations.

Safety Data Sheet


MAGNAFLOC E30
Revision date : 05.07.2010 Version: 1.2 Page: 6/7 (30482626/SDU_GEN_CA/EN)

14. Transport Information


TDG (Canada) Road transport

Special shipping information: Special shipping information: Special shipping information:

Not classified as a dangerous good under transport regulations. Not classified as a dangerous good under transport regulations. Not classified as a dangerous good under transport regulations.

International Air Transport Association (IATA) International Maritime Dangerous Goods Code (IMDG)

15. Regulatory Information


Canada: Domestic Substances List (DSL): US: Toxic Substances Control Act (TSCA): All components either exempt or listed on the DSL All component(s) comprising this product are either exempt or listed on the TSCA inventory

Canada Regulations

Workplace Hazardous Materials Information System (WHMIS Classification): This product is WHMIS controlled. D-2A Materials Causing Other Toxic Effects - Very toxic material D-2B Materials Causing Other Toxic Effects - Toxic material Significant New Activity Conditions (SNAC): This product does not contain any components subject to a SNAC Notice.
International Regulations

Chemical Weapons Convention: This product does not contain any component(s) listed under the Chemical Weapons Convention Schedule of Chemicals.

16. Other Information


Product Safety Contact: Prepared by: Phone number of preparer: Date / Revised: Ginette Rambi (905) 812-7280 Generation date

This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations and the MSDS contains all the information required by the Controlled Products Regulations.

MAGNAFLOC E30 is a registered trademark of BASF Canada or BASF SE Due to the merger of CIBA and BASF Group all Material Safety Data Sheets have been reassessed on the basis of consolidated information. This may have resulted in changes of the Material Safety Data Sheets. In case you have questions concerning such changes please contact us at the address mentioned in Section I.

Safety Data Sheet


MAGNAFLOC E30
Revision date : 05.07.2010 Version: 1.2
END OF DATA SHEET

Page: 7/7 (30482626/SDU_GEN_CA/EN)

You might also like