You are on page 1of 3

Thyristor : principal and characterstics 1.1 : introduction 1 1.2: history of power electronic development 1.3: thyristor family 1.

4: principal of operational of scr 1.5 : statics anode - cathode characteristic of scr 1.6; the two- transistor modal of scr 1.7 : thyristor construction 1.8: gate characteristic of scr 1.9: turn on method of theoristor 1.10 : dynamic turn on switching charaterstic 1.11 : turn of machanism 1.12 : turn of method 1.13 : thyristor ratings 1.14 : measurement of thyristor parameter 1.15 : comparison b/w gas tube and thyristors 1.16 : comparison b/w transistors and thyristors

Gate triggering circuits 2.1 : introduction 2.2 : firing of thyristor 2.3 : pulse transformers 2.4 : optical isolators optoisolators 2.5 : gate trigger circuits 2.6 : unijunction transistor 2.7 : the programmable unijunction transistor 2.8 : phase control sing pedestal and ramp triggering 2.9: firing system for dc/ dc choppers 2.10 : firing circuit for a three phase inverter bridge

4.1 : introduction 4.2 : phase angle control 4.3 : single phase half life a): with resister load b): with inductive lode c): effective of freewheeling diode 4.4 : single phase full wave cortroling rectidire

a): mid point converters * with resistive load * with inductive load * effective of freewheeling diode b): bridge configuration: * full controlled bridge speed with inductive load 4.6): performance factor of line communicated converter * input displacement angle * input displacement factor * input power factor * dc voltage ratio * input current distortion factor * input harmonic factor * voltage ripple factor * current ripple factor 4.7): performance mazors of two pulse converter: * input displacement factor * input power factor * dc voltage ratio * input current distortion factor * input harmonic factor * voltage ripple factor * active pawer input * reactive power input 4.8): three phase controlled converter 5.1): introduction 5.2): thyristor invereter * classification according to the method of commulation * classification according to the method of connection 5.3): series invertor * basic series inverer * circuit analysis * design aspect * selection of thyristor * modified series inverter * 3 phase series inverter * high frequency series inverter 5.5):parallel invereter * basic parallel inverer * parallel invereter with feedback diode

* selection of scr 5.7): 3 phase bridge inverter * 3 phase 180 deegeree conduction modes * 3 phase 120 deegeree conduction modes * comparision of two conduction mode 5.8): 3 phase bridge inverter with input circuit commutation

You might also like