You are on page 1of 2

1. When pulsating d.c is applied to a capacitor, the capacitor will be charged to the peak value of the voltage.

The peak value of a sine-shaped voltage is Vs=(rumus) How can the operating principle and the measured results be explained with the circuit above based on the above given assumption?

D1 is connected in the forward direction when a positive half wave is applied, and D2 is in this case connected in the reverse direction. Consequently C1 is charged, and with the following negative half wave D2 is connected in the forward direction and D1 is connected in the reverse direction, i.e C2 is charged but at the same time C1 is not discharged as D1 blocks. Thus the peak voltage Us is applied to both capacitors and, therefore, the total output voltage at the output is: (rumus) 2. Why does the voltage reach only 2 Vs = 13.6 V when no load is applied to the rectifier? Because the diffusion voltage of the silicon diode(Ud=0,6V; refer to experiment B2-74.2) must be exeeded before a rectifying current is able to flow.

3. Why is the frequency of the ripple voltages of the partial voltage U2 and U3 50Hz and that of the total voltage 100 Hz? The single dodeswith their smoothing capacitors act as half-wave rectifier ( 50Hz; refer to experiment B2-2.7.2) after each other for the positive and the negative half wave. Both partial voltages are added (100 Hz) = two-way rectifier.

4. What is the relationship between the resulting ripple voltage and thhe d.c voltage comapared to the value of the smoothing capacitors ( for constant values of load reesistance)? For larger capacitors the value of the d.c voltage will be higher and ripple wiil be reduced.

5. What is the maximum value for the d.c voltage? (rumus) (rumus)= internal resistance of the voltage sources U1 (rumus)= internal resistance of the rectifier ( taking the diffusi voltage into account)

6. What happens to the d.c voltage and the ripple voltage when redu the value of the load resistor? U4 dops U4 increases

1 . Ketika dc berdenyut diterapkan pada kapasitor , kapasitor akan dibebankan pada nilai puncak tegangan . Nilai puncak dari tegangan berbentuk sinus adalah Vs = ( Rumus ) Bagaimana prinsip operasi dan hasil diukur dijelaskan dengan rangkaian di atas didasarkan pada asumsi yang diberikan di atas ? D1 terhubung dalam arah maju ketika gelombang setengah positif diterapkan , dan D2 dalam hal ini terhubung dalam arah sebaliknya . Akibatnya C1 dibebankan , dan dengan setengah gelombang negatif berikut D2 terhubung dalam arah maju dan D1 terhubung dalam arah sebaliknya , yaitu C2 dikenakan biaya tapi pada saat yang sama C1 tidak bisa keluar sebagai D1 blok . Dengan demikian Vs tegangan puncak diterapkan untuk kedua kapasitor dan , karena itu, total tegangan output pada output adalah : ( Rumus ) 2 . Mengapa tegangan hanya mencapai 2 Vs = 13,6 V ketika tidak ada beban yang diterapkan untuk penyearah ? Karena tegangan difusi dioda silikon ( Ud = 0,6 V; lihat bereksperimen B2 - 74.2 ) harus exeeded sebelum arus meluruskan mampu mengalir . 3 . Mengapa frekuensi tegangan riak tegangan U2 parsial dan U3 50Hz dan bahwa dari total tegangan 100 Hz ? Dioda tunggal dengan kapasitor smoothing mereka bertindak sebagai setengah gelombang penyearah ( 50Hz , lihat bereksperimen B2 - 2.7.2 ) setelah satu sama lain untuk positif dan setengah gelombang negatif. Kedua tegangan parsial ditambahkan ( 100 Hz ) = dua arah penyearah . 4 . Apa hubungan antara tegangan yang dihasilkan riak dan thhe tegangan dc dibandingkan dengan nilai dari kapasitor perataan ( untuk nilai-nilai konstan resistensi beban ) ? Untuk kapasitor yang lebih besar nilai tegangan dc akan lebih tinggi dan riak wiil dikurangi . 5 . Berapa nilai maksimum untuk tegangan d.c ? ( Rumus ) ( Rumus ) = resistansi internal sumber tegangan U1 ( Rumus ) = resistansi internal dari rectifier ( mengambil tegangan diffusi ke rekening ) 6 . Apa yang terjadi dengan tegangan dc dan tegangan riak ketika redu nilai dari resistor beban ? U4 tetes U4 meningkat

You might also like