You are on page 1of 1

Release 9

38

3GPP TS 25.306 V9.5.0 (2010-12)

Table 5.1a: FDD HS-DSCH physical layer categories


HS-DSCH category Maximum number of HSDSCH codes received Minimum inter-TTI interval Maximum number of bits of an HS-DSCH transport block received within an HSDSCH TTI NOTE 1 7298 7298 7298 7298 7298 7298 14411 14411 20251 27952 3630 3630 35280 42192 23370 27952 35280 15 1 23370 42192 15 1 27952 Category 19 Category 20 Category 21 Category 22 Category 23 Category 24 15 15 15 15 15 15 1 1 1 1 1 1 35280 42192 23370 27952 35280 42192 345600 518400 518400 345600 345600 518400 518400 345600 259200 Total number of soft channel bits Supported modulations without MIMO operation or dual cell operation Supported modulations with MIMO operation and without dual cell operation Supported modulations with dual cell operation Supported modulations with simultaneous dual cell and MIMO operation

Category 1 Category 2 Category 3 Category 4 Category 5 Category 6 Category 7 Category 8 Category 9 Category 10 Category 11 Category 12 Category 13 Category 14 Category 15 Category 16 Category 17 NOTE 2

5 5 5 5 5 5 10 10 15 15 5 5 15 15 15 15

3 3 2 2 1 1 1 1 1 1 2 1 1 1 1 1

19200 28800 28800 38400 57600 67200 115200 134400 172800 172800 14400 28800 259200 259200 345600 345600 259200

QPSK, 16QAM

Not applicable (MIMO not supported)

QPSK QPSK, 16QAM, 64QAM QPSK, 16QAM QPSK, 16QAM, 64QAM QPSK, 16QAM, 64QAM QPSK, 16QAM QPSK, 16QAM Not applicable (dual cell operation not supported) Not applicable (simultaneo us dual cell and MIMO operation not supported)

Category 18 NOTE 3

QPSK, 16QAM, 64QAM QPSK, 16QAM QPSK, 16QAM, 64QAM

Category 25 Category 26 Category 27 Category 28

15 15 15 15

1 1 1 1

23370 27952 35280 42192

691200 691200 1036800 1036800

QPSK, 16QAM QPSK, 16QAM, 64QAM

For any category, in addition to the requirements in Table 5.1a, an HS-SCCH less capable UE shall allocate 24960 raw channel bits for HS-SCCH less operation in order to buffer the last 13 subframes and 13599 soft channel bits to receive 3 parallel HARQ processes. UE Categories 1 to 4 and Category 11 do not support HS-DSCH reception in CELL_FACH, CELL_PCH or URA_PCH states. UEs of Category 13 are only required to support code rates up to 0.823 when 64QAM is used, which is represented by a limitation in the maximum value of Ki. in the transport block calculation in [9]. For other modulation formats, this restriction does not apply.

You might also like