Professional Documents
Culture Documents
DOT
HMIS TSCA
H 1
R 0
PE
DSL CAS#
Mixture.
Code
Molecular weight Revision Number
FGA-0075
Not applicable 1
Not available.
Check for and remove any contact lenses. In case of contact, immediately flush eyes with plenty of water for at least 15 minutes. Get medical attention if irritation occurs. Wash with soap and water. Get medical attention if irritation develops or persists. If inhaled, remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get medical attention if symptoms appear. Do NOT induce vomiting unless directed to do so by medical personnel. Never give anything by mouth to an unconscious person. Loosen tight clothing such as a collar, tie, belt or waistband. Get medical attention if symptoms appear.
CAS #
107-41-5
TLV/PEL
Not available. Not available.
LC50/LD50
Not available. ORAL (LD50): Acute: 3700 mg/kg [Rat]. DERMAL (LD50): Acute: 3200 mg/kg [Rabbit].
FGA-0075
Page Number: 2
Clean air act (CAA) 112 accidental release prevention: Not Listed. Clean air act (CAA) 112 regulated flammable substances: Not Listed. Clean air act (CAA) 112 regulated toxic substances: Not Listed.
Auto-ignition temperature Not available. Fire degradation products Not available. Flash points Flammable limits Fire extinguishing procedures Flammability Risks of explosion
CLOSED CUP: Higher than 93.3C (200F). Not available. SMALL FIRE: Use DRY chemical powder. LARGE FIRE: Use water spray, fog or foam. Do not use water jet. Because of the large amount of water contained in the product, the product might be combustible only after partial or complete evaporation. Non-explosive in presence of open flames and sparks, of shocks.
The product is stable. Warning - This product is not freeze thaw stable. Do not allow to freeze oxides of silicone Oxides of carbon Not available.
Oxides of carbon Not available. The product itself and its products of degradation are not toxic.
Non-corrosive in presence of glass, of stainless steel(316). May react with strong oxidizing agents.
Corrosivity Reactivity
Page Number: 3
CARCINOGENIC EFFECTS: No carcinogenic substances as defined by IARC, NTP and/or OSHA. DEVELOPMENTAL TOXICITY: Not toxic.
Acute effects on humans Slightly hazardous in case of eye contact (irritant), of ingestion. Repeated skin exposure can produce local skin destruction or dermatitis. Over-exposure by inhalation may cause respiratory irritation. Aquatic Toxicity (LC50)
Not available.
Waste must be disposed of in accordance with federal, state and local environmental control regulations.
Keep container tightly closed. Keep container in a cool, well-ventilated area. Do not ingest. Do not breathe gas/fumes/vapor/spray. If ingested, seek medical advice immediately and show the container or the label. Absorb with an inert material and put the spilled material in an appropriate waste disposal. Absorb with an inert material and put the spilled material in an appropriate waste disposal. Finish cleaning by spreading water on the contaminated surface and allow to evacuate through the sanitary system. Be careful that the product is not present at a concentration level above TLV. Check TLV on the MSDS and with local authorities. Splash goggles. Full suit. Boots. Gloves. Suggested protective clothing might not be sufficient; consult a specialist BEFORE handling this product.
Maritime transportation
Not available.
FGA-0075
Page Number: 4
Illinois chemical safety act: Hexylene Glycol. Rhode Island RTK hazardous substances: Hexylene Glycol. Pennsylvania RTK: Hexylene Glycol. Florida: Hexylene Glycol. Massachusetts RTK: Hexylene Glycol. Massachusetts spill list: Hexylene Glycol. New Jersey: Hexylene Glycol. CERCLA: Hazardous substances.: Not Listed. SARA 313 toxic chemical notification and release reporting: Not Listed. Not available.
International Lists
Not Listed.