You are on page 1of 7

SPECTRUM

AM TRANSMITTER
&
AM RECEIVER TRAINER
Manual for
( Sr. No:............................)
Operating instructions
FOR DEMO MODE
TECHNICAL SPECIFICATIONS
1. Build in Modulation Frequency source Based on XR-2206. Both frequency and amplitude varriable.
2. Build in Carrier Frequency source Based on XR-2206. Both frequency and amplitude varriable.
3. MC1496 IC Based balanced modulator circuit for demo mode.
4. LF356 based amplifier for modulated output in demo mode.
5. Build in Mic pre amplifer. Can be used for both modulation and Transmitter
6. AM Modulator circuit using Two transistor low power RF transmitter.
3. Build in power supply and attenna internally connected.
1. First switch ON the AM transmitter trainer
2. Connect the carrier frequency source to carrier input terminal as per patch connections.
3. Connect Modulating frequency source to modulating input terminal as per patch connection.
4 . Observe the output modulating waveform in CRO.
5. Adjust the amplitude control of frequency source to required level.
6. Adjust the amplitude control of modulating frequency. This will vary the modualting index, ie depth of
modulation can be varried.
7. Adjust the frequency of modulating signal and observe the waveforms in cro.
8. Now connect this modulator output to amplifier and the see the amplified output.
9. Mic input can also be connected at the mod input terminal and its voice signal modulation can be
observed.
FOR AM TRANSMITTER TRAINER
Operating instructions
1. First switch ON the AM Receiver trainer
2. Connect the audio out terminal to input terminal of audio amplifier.
3 .Keep the AM TRANSMITTER TRAINER switched ON and keep it 5 metre away from the
AM RECIVER TRAINER .
4. Connect the modulation frequency source output to the tramsmitter input terminal.
5. Keep the amplitude of mod signal maximum. And extend the antenna fully out.
7. Adjust the frequency Tune control of receiver trainer very finelly
8. We can hear this audio tone of modulating signal.Vary the frequency control of modulating signal
and observe the audio tone.
9. Now connect the Mic to its socket and connect the mic pre amplifier out to the transmitter input
in the transmitter trainer and speak in the mic
10. We can hear audio voice in the receiver trainer.
FOR AM RECEIVER TRAINER
1. Receiver circuit based on sony fm/am receiver ic.
2. Build in audio amplifier.
3. Build in power supply and attenna internally connected.
FOR DEMO MODE
FOR Transmitter MODE from mod source
FOR Transmitter MODE from mod source

You might also like