380-425 MW COMBINED CYCLE POWER PLANT APSIPL-05EPC-
3-A20 CHEMICAL LABORATORY EQUIPMENT
Page 1 of 3
20.0 CHEMICAL LABORATORY EQUIPMENT
20.1 A suitable chemical laboratory shall be provided in the power plant to enable testing of fuel, water, flue gas, etc. as required for normal operation of the combined cycle power plant. The equipment proposed to be provided are listed below. In addition to these equipment, the laboratory shall also be equipped by the necessary laboratory glassware, reagent chemicals and laboratory furniture. A portion of the chemical laboratory housing equipment such as the spectrophotometer shall be air-conditioned. Any other equipment to make the system complete shall be provided by the Bidder.
20.2 The following equipment shall be provided in the chemical laboratory. The chemical laboratory shall be located atop the MCC room of WT plant building.
(a) Equipment for Water Analysis (i) Conductivity meter (ii) Alfoc test kit for oxygen (iii) pH meter (digital type : 1 no. and line operated : 1 No.) (iv) Turbidity meter (v) Dissolved oxygen meter (vi) Spectrophotometer (vii) Jar test apparatus (laboratory flocculator)
(b) Equipment for Oil Analysis
(i) Apparatus for oxidation stability test (ii) Redwood viscometer No. 1 (iii) Redwood viscometer No. 2 (iv) Apparatus for water in oil by Dean and Stack method (v) Interfacial tension apparatus (vi) Pensky-Martens flash point apparatus (vii) Pentra meter for grease testing
(c) Equipment for Gas Analysis
(i) Three-bulb Orsat (ii) Explosimeter (Combustible gas analyser) (iii) Hydrogen purity test apparatus
PIONEER GAS POWER LIMITED 380-425 MW COMBINED CYCLE POWER PLANT APSIPL-05EPC- 3-A20 CHEMICAL LABORATORY EQUIPMENT
Page 2 of 3
(d) General Equipment
(i) Magnetic stirrer (ii) Balance (chainomatic) with weight box (iii) Atomic absorption spectrophotometer (iv) Triple beam balance (v) Single pan balance (vi) Gas heating assembly (vii) Water bath (viii) Hot plate (ix) Water distilling still (x) Vacuum pump (xi) Heating mantle (xii) Kipps apparatus (xiii) Flame photometer (xiv) Lovibond comparator (xv) Voltage stabiliser (xvi) Oil centrifuge (xvii) Hot plate-cum-magnetic stirrer (xviii) Karl-Fischer titration apparatus (xix) Gas chromatograph with data processor (xx) Refrigerators: 2 Nos. (One for storage of chemicals and the other for storage of samples)
Bidder shall note that the list of equipment mentioned above is indicative. Suitability/ non-suitability of the equipment shall be ascertained by proper justification. The technical parameters, measurement range and accuracy shall be suitable for the minimum anticipated level / concentration of the constituents measured.
(e) Environmental Laboratory Equipment
(i) Stack monitoring kit for iso-kinetic sampling consisting of control module, flow totaliser module (dry gas meter), impinger & condenser module, pitot tube. (2 sets)
(ii) Continuous ambient air quality monitor for SOx (UV Fluorescent principle) NOx equivalent to Rupprecht & Patashnick 1400 TSP monitor USA series (1 No.)
PIONEER GAS POWER LIMITED 380-425 MW COMBINED CYCLE POWER PLANT APSIPL-05EPC- 3-A20 CHEMICAL LABORATORY EQUIPMENT
Page 3 of 3
(iii) Ambient Air Monitoring Weather Monitoring Station including wind speed anemometer, direction sensor, rain fall sensor, rain gauge, relative humidity sensor and temperature sensors