Professional Documents
Culture Documents
BBV30303 ELECTRONIC 2
EXPERIMENT REPORT 4
(SIMPLE AUDIO AMPLIFIER)
BIL
NAMA
1. Azman Bin Hanafiah
MATRIK
DB120004
Check By:
Dr. Alias Bin Masek
Pensyarah Elektronik II
Submit: 15 NOVEMBER 2014
1.0.
TITLE
Simple Audio Amplifier
2.0.
AIM
To improve our knowledge about the operation of audio amplifier circuit.
3.0.
4.0.
5.0.
OBJECTIVES
3.1.
3.2.
3.3.
3.4.
EQUIPMENTS
4.1.
Soldering
4.2.
Flux
4.3.
Stand of soldering
4.4.
Multimeter.
4.5.
Sucker
4.6.
Tin
4.7.
ELECTRONIC COMPONENT
NO.
COMPONENT
QUANTITIES
1.
Resistor 1K Ohm
2.
3.
Diode 1N4148
4.
Capacitor 47uF
5.
Capacitor 470uF
6.
Transistor C945
7.
Transistor 2N2222
8.
Transistor C9012
6.0.
PROCEDURE
C945
2N2222
C9012
C945
C945
C945
6.1.
6.2.
Based on circuit in figure 1 given, make the connection on the Vero Board.
6.3.
Defined the emitter, collector and based of the transistors using by multimeter.
6.4.
6.5.
6.6.
6.7.
6.8.
If the audio circuit in a good condition it must have the output. The output is the
same like the sound of radio.
7.0.
RESULT
Overall, audio amplifier circuit that I created Connection is successful and it is supposed
to sound. However, the output sound is not too loud because the speakers are not
suitable. We should use 25 Ohm speaker to get a good result.
8.0.
DISCUSSION OR ANALYSIS
C945
2N2222
C9012
C945
C945
C945
This is the circuit diagram of a simple three transistor audio amplifier that can
deliver around 100mW power to a 25 Ohm speaker.
The diodes D1 and D2 provide a constant bias voltage for the transistors Q1 and
Q2.
You can use any NPN transistor for Q1, Q3 and any PNP transistor for Q2.
Any way the minimum collector current capacity of the transistors must not be
less than 100mA.
The circuit will work well with an 8 ohm speaker too, but the volume will be a little
less.
NO. COMPONENT
1.
Diode
FUNCTION
2.
Transistor
3.
Speaker
4.
Capacitors
5.
9.0.
Battery 9V
CONCLUSION
Based on the experiment we understand about the function of audio amplifier circuit,
where this device will produce of sound. After that, we can understand about the
application of transistor in audio amplifier circuit. Overall the function of transistor Q1
works as a preamplifier and the transistor Q2 and Q3 as a drives the speaker. Other
than that, we can apply our skill in soldering component on the board. Lastly, Im get the
best output from this experiment.
10.0.