Professional Documents
Culture Documents
CNC: Mazak M2
CNC Parameters
OP2 - BIT 0=1 (ISO) (leave other bits alone)
OP3 - 109
OP4 - 70
OP15 - 0
OP16 - 0
OP20 - 0 (No leader)
OP21 - 0 (No space before programs)
OP22 - 0 (No trailer)
OP23 - 16 (4800 input baud)
OP24 - 16 (4800 output baud)
PC DNC Settings
Baud: 4800
Code: 7 data bits / ASCII Even
Stop Bits: 2
EOB: CR/LF
Handshaking: XON/XOFF
ADVANCED
Leader: %CRLF
Trailer: %
Skip lines which contain: %
Additional Notes
Note: The transfer of Mazatrol programs with CMT IO requires
PC-DNC plus 3.3.1 or later.
When transferring to / from this CNC, it is recommended that
you use a hardware handshake cable. Diagram:
PC 9-pin to CNC 25-pin:
PC(2) to CNC(2)
PC(3) to CNC(3)
PC(7) to CNC(5)
PC(8) to CNC(4)
PC(5) to CNC(7)
Jumper 6,8,20 on CNC side only
Attach cable shield to pin 1 on CNC side only
PC 25-pin to CNC 25-pin:
PC(2) to CNC(3)
PC(3) to CNC(2)
PC(4) to CNC(5)
PC(5) to CNC(4)
PC(7) to CNC(7)
Jumper 6,8,20 on CNC side only
Attach cable shield to pin 1 on CNC side only
RS232 Support
RS232 Support
versions of this control may not have the CMT CONTENTS.
Steps for setting CNC to drip-feed mode:
EIA.1 Set mode selector to TAPE
EIA.2 Cycle Start
Steps for setting parameters in the CNC:
1 Press LEFT PAGE key
2 Press PARAM softkey
3 Press any white key (MDI, etc)
4 Cursor to parameter
5 Key in new value
6 Press INPUT
7 POWER DOWN CNC