Professional Documents
Culture Documents
2. Make a cut so around 1.5mm to 2mm of the PTFE tube are looking out of the
throat
3. Tighten the nuts against each other so there is a few of the PTFE still looking
out.
1
M. Other
3. August 2016
4. Now press the nut against the sandpaper ant rub it until the nut is completely
scraping on the sandpaper, this means you have a flat end on one end of your
PTFE Tube now.
5. Turn the PTFE tube and repeat step 3 and 4. Make sure you get it sticking out
around 0.5mm when you are finished. (You can even mesure the placeing of
the nuts if you want.)
6. Take the PTFE tube out and make some nice chamfers on the in and outside
with your knife.
2
M. Other
3. August 2016