Professional Documents
Culture Documents
Network Scenario
VLAN Plan
Vlan 25 Management
Vlan 26 Internet service
Vlan 27 VOIP service
Vlan 28 IPTV service
QOS Plan
Service type 802.1p Priority GEM port T-CONT
Management 6 11 4
VOIP 5 12 4
IPTV 4 13 4
Internet 0 14 4
DBA type Type 3 (DBA profile: assured bandwidth + maximum bandwidth. Users are allowed to
preempt the bandwidth on condition that the users assured bandwidth is guaranteed. However, the
total bandwidth cannot exceed the maximum bandwidth.)
Rate limit on OLT downstream Rate limit can be configured for Internet service using traffic table
but its recommended to do it on BRAS/BNG.
OLT configuration
Before adding ONT we need to enable ont-auto-find feature to ensure that OLT properly discovered
ONT.
To enable ont-auto-find on port 0 of GPON board 0 run:
NGCOM-OLT(config)#interface gpon 0/0
NGCOM-OLT(config-if-gpon-0/0)#port 0 ont-auto-find enable
To see discovered ONTs run:
NGCOM-OLT(config-if-gpon-0/0)#display ont autofind 0
As you see OLT discovered ONT with serial number 4857544326A5EB34, on port 0 of GPON board
0
To add this ONT using ont line profile ftth and service profile ftth assinging ont id 7 run:
NGCOM-OLT(config)#interface gpon 0/0
NGCOM-OLT(config-if-gpon-0/0)#ont add 0 7 sn-auth 4857544326A5EB34 omci ont-lineprofile-
name ftth ont-srvprofile-name ftth desc NGCOM_ONT
To check if ONT properly registered run :
NGCOM-OLT(config-if-gpon-0/0)#display ont info 0 7
under gpon interface mode
or
NGCOM-OLT(config)#display ont info 0 0 0 7
under config mode
0 0 0 7 means frame id / gpon board slot id / port id on gpon board / ont id
ONT Configuration
Click apply then go to System tools >> Configuration file and click Save.
To verify connection go to Status >> WAN information
To configure WI-FI go to WLAN page. For security reasons it isnt recommended to enable WPS
Click apply then go to Network application page to configure IGMP mode , in my case its snooping
After this go to System tools >> Configuration file and click Save