You are on page 1of 2

Rotator Brake Delay Modification Mk2

for the hy-gain rotators

Some Background
In the standard circuit, the primary of the 'power' transformer is energised by depressing the
Brake switch lever, operating a microswitch. The secondary side energises the brake solenoid
directly, releasing the brake. Additional switches on the secondary feed the clockwise or
counterclockwise mode of rotation for the motor. From this you will realise that it is not
possible to energise the motor without first or simultaneously releasing the brake. Of course
rotation should be stopped by first releasing the selected motor switch and
pausing before applying the brake, as the momentum of the antenna is obviously
considerable. It is very easy to forget the pause.

Several schemes have been published for a delay to prevent the brake from being applied to
the still-rotating antenna but they tend to be elaborate. Mine is simpler than others I have
seen.

So here are the modification details. ( Schematic )


Another microswitch driven by the brake switch lever is interposed on the secondary side
before the motor switches and a relay is also fed from this point. The relay drive circuit
includes a diode to provide DC and a capacitor and resistor to delay the drop-off. Relay pick-
up is immediate, however. Note that the brake is still energised as soon as the switch is
depressed as in the original design. However, a normally-open contact of the relay is in
parallel with the original primary-side microswitch and hence when the brake switch is
released the brake remains energised for the drop-off period, in my case 3 seconds. But the
motor circuits are de-energised by the second microswitch as soon as the brake switch is
released.

The relay and the microswitch contacts should be rated 10 amps AC or more as the brake and
and motor currents are of this order. I chose a common octal-based relay which has a coil
requirement of 12 volts 100 mA DC. The voltage at the capacitor exceeds 40 VDC so it needs
to be good for 50 V . The resistor must be capable of 2 W but I suggest more as that is close
in my case, resistor and capacitor values need trial and error according to the relay; the diode
and resistor were mounted on a scrap of Veroboard with a small bolt securing it to the control
box chassis. The capacitor, relay and microswitch are silicone-glued in place, saving time and
effort!

The motor cannot be energised without the brake nor during the brake delay period.

Incidentally, I would have liked to have put two more switches, with normally-closed contacts,
each in series with a motor switch, to provide a directional "cross-interlock". As the circuit is
and was, it is possible to select both motor directions at once, and I don't suppose that would
do the motor a good turn! But there is not room to do this as other components intrude on
the space required.

73 de KEN WOOD ZS2ACB


By Ken Wood ZS2ACB
Click the image for a full size schematic

Back to the Technical Articles

You might also like