You are on page 1of 4
JQ) Safoty Data Sheet SECTION 1 PRODUCT NAME AND COMPANY IDENTIFICATION Product Name: WB-2000 Water-Based Primer Recommended U 9: Acrylic Latex Primer Restriction on Use: None ‘Manufecturor: Polygiass US.A. Inc 11411 West Newpott Center Drive Deerfield Beach, Frida 32442 866-222-9782 SDS Date of Preparation: 09/05/13 Emergency Contact: (800) 424-6300 CHEMTREC (USA) ‘SECTION 2: HAZARDS IDENTIFICATION Hazard Classification: Physical Health Not Hazardous, Eye itant Category 2A Label Elements: WARNING: Causes serious eye initaton ‘Wash hands thoroughly after handling Wear eye protection. IFIN EYES: Rinse cautously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing If eye intation persists: Get medical edvice/attenton. ‘SECTION 3 COMPOSITION/INFORMATION ON INGREDIENTS INGREDIENTS. case. wt Styrenein-Butyl Acrylate Copolymer Proprietary 30-60 ‘The exact percentage (concentration) of composition has been withheld as a trade secret. SECTION 4 FIRST AID MEASURERS Eyes: mmediately fush eyes with water while iting the upper and lower lids. f contact lenses are present, remove them if easy to 0 after tho first § minutes of fushing, then continue fushing fer 15 minutes. Get medical aientonifiitation persists, ‘Skin: Remove contaminated clothing, Wash skin thoroughly with soap and water. Iirtation develops, get medical attention, Launde: clathing before reuse Inhalation: If symptoms develop, remove vicim to fresh air. if symptoms develop, get medical attention. ‘WE-3000 Water-Based Primer Pagetofe Polyglass U.S.A. inc. +1111 West Newport Center rive, Deereki Beach, FL Toll Free (868) 410-1875 sew.pauaass.com ae JQ Safety Data Sheet Ingestion: conscious, rinse mouth with water. Never give anything by mouth to a parson whois unconscious or convulsing. If large amount if swallowed or gastrointestinal effects develop, get madical attention. Most important symptoms/effects, acute and delayed: Causes eye Iritation. Prolonged contact may cause skin inttation. Inhalation of vapors or mists may cause respiratory ritation. Ingestion may cause nausea, vomiting and diarrhea, Indication of immediate medical attention and special treatment, if necessary: Immediate medical attention is net nermlly required, SECTION 6 FIRE FIGHTING MEASURES Extinguishing Media: Use any media appropriate forthe surrounding fire. Cool fre exposed containers with water. ‘Special Protective Equipment and Precautions for Fire-fighters: Firefighters should wear full emergency equipment and NIOSH poroved positive pressure self-contained breathing apparatus. Do not allow run-of from firefighting to enter drains or water courses, ‘Specific Hazards Arising from the Chemical: This products an aquecus mbture that will rot bum until all water has evaporated. Residue will bum ater the fre hes evaporated, Combustion products may include oxides of carbon and nitrogen and hydrocarbons. SECTION 6 ACCIDENTAL RELEASE MEASURES Personal Precautions, Protective Equipment, and Emergency Procedures: Weer appropriate protective clothing to avoid eye ‘and skin contact, ‘Methods and Materials for Containment and Cleaning Up: Dike the spiled material. Attempt to reclaim the free product, if this is Possible. Shovel into an appropriate container for use or disposal. Collect residue with inert material and place into a closable Container for dieposel. Wash epll area, Prevent runoff to storm sewers and ditches leading to natural waterways. Report spi as required by local and federal regulations. SECTION 7 HANDLING and STORAGE Precautions for Safe Handling: Avoid contact withthe eyes, skin and clothing. Avoid breathing vapors and mists. Weer protective clothing and equipment as described in Section 8, Use with adequate ventilation. Wash thoroughly with soap and ‘water ater handling. Keep containers closed wren notin use, Empty containers retain product residues cen be hazardous. Fallow all SDS precautions when handing emety containers. Conaitions for Safe Storage, Including any Incompatibllties: Store in @ cool, dry, wellventlated area, Protect from physical damage. Keep container closed when notin use. Keep out of the sun. ‘SECTION 8 EXPOSURE CONTROLS and PERSONAL PROTECTION Exposure Guidelines: INGREDIENTS: EXPOSURE LIMITS. ‘Styrenein-Buly! Acryiate None Established Copolymer ‘Appropriate Engineering Controls: Use with adoquate general or local exhaust venation to minimize exposures levels, Respiratory Protection: None normally required, If aerosols are generated during use a NIOSH approved particulate respirator ‘appropriate forthe form and concentration ofthe contaminants should be used. Selection end use of respiratory equipment must be in accordance with OSHA 1810.134 and good industrial hygiene practice. Gloves: Nir latex or other impervious gloves are recommended to prevant prolonged skin contact. Eye Protection: Chemical safety goggles should be worn if splashing is possible, ‘WE-3000 Water-Based Primer PageZoft Polisiass U.S.A Inc. 1111 West Newport Contr Dive, Deer Beach, FL» Tol Free (898) 410-1975 snpwpovsiass.com ae A Safety Data Sheet Other Protective Equipment: Impervious cothing as needed to avold skin contact. For operations where contact can occur, an eye wash faclity should be avaiable ‘SECTION 9 PHYSICAL and CHEMICAL PROPERTI Appearance And Odor: White quid with a sight latex odor. Bolling Point (@ 760 mmHg): 212°F (100°C) Freezing Point: Not determined ‘Odor Threshold: Not determined Viscosity: Not determined Rolative density (W20=1): 1.02 Vapor Pressure: Not determined VOC: 2 aft ‘Vapor Density (AIR=1): Not determined Evaporation Rate: Noi deiermined able ‘Solubility In Wator: Miscible pH: 7.0:8.0, Partition Coefficient n-OctanolWater: Not determined Flash Point: None. ‘Autoignition Temperature: Not applicable Decomposition Temperature: Noi determined Flammable Limits: (vol % in air) LEL-WA VEL -N/A SECTION 10 STABILITY and REACTIVITY Reactivity: Not normally reactive Chemical Stability: Stable under normal storage and handling conditions Possibility of Hazardous Reactions: None known Conditions to avold: Do not freeze, Incompatible materials: Avoid oxidizing agents, bases and acids Hazardous decomposition products: Thermal decomposition may yield oxides of carbon and nitrogen and hydrocarbons SECTION 41 TOXICOLOGICAL INFORMATION Eye: Contact may couse iritaton with redness and tearing ‘Skin: Prolonged skin contact may cause ination and drying of the skin, Inhalation: Inhalation of vapors or mists may cause mucous membrane and upper respiratory tract tation Ingestion: Ingestion may cause gastrointestnel ination, nausea, vomiting and diarrhea. Sensitization: Ths product's not expected to cause sensitization Chronic Effects: None known Garcinogenicity: None of the components present et 0.1% or greater are listed as a carcinogen by NTP, IARC, ACGIH or OSHA Numerical Measures of Toxicity: No data available SECTION 1 {COLOGICAL INFORMATION Ecotoricity: No ecotoxty data Is evallable for this product at this ime, Avoid release to the environment. Persistonca and dogradabllity: No data available Bioaccumulative potential: No data avalable Mobily in soll: No data available Other adverse effects: No data avaliable SECTION 13: DISPOSAL CONSIDERATIONS Waste Disposal Method: Dispose in accordance with all local, state and federal reguistons. ‘WB-3000 Water-Based Primer Page 3 of Poysiess USA. Inc. +1111 West Newpod Center Drive, Deerfold Beach, FL» Tol Free (888) 410-1375 yo golaias.com qnnareay Safety Data Sheet ‘SECTION 14: TRANSPORT INFORMATION Proper Shipping Name: Not Reguiated UN Nurbes: None Hazard Class/Pecking Group: None Labels Reauired: None Environmental hazards: None known ‘Transport in bulk (according to Annex il of MARPOL 73/78 and the IBC Code): Not applicable ‘Special precautions: None known ‘SECTION 16: REGULATORY INFORMATION SARA Hazard Category (311/912): Acute Health EPA SARA 343: This product contains the folowing chemicals regulated under SARA Title Il, section 313: None CERCLA Hazardous Substances (Section 103)RQ: This product is not subject to CERCLA reporting requirements as itis sol. Many states have more stingent release reporting requirements, Repos spills required under federal, state and local regulations, ‘Toxic Substances Control Act: Allof the components ofthis product are listed on the TSCA inventory. California Proposition 68: This product is nat known to contain chemicels known to the State of Calforia to cause cancer or reproductive toxity WHNIS Classification: Ciass D Division 2 Subdivision B (Toxic Material Causing other Toxic Effects) ‘This SDS has been prepared according to the cxtera ofthe Controlled Products Regulation (CPR) and the SDS contains al of the informaton required by the CPR. ‘SECTION 16: OTHER INFORMATION NFPA Rating: Health IMIS Rating Health =2 Instability = 0 Physical Hazard = 0 ‘SDS Date of Preparation: 09/08/13 Revision Summary: New SDS WB-3000 Water-Based Primer Pagesoit Polygass U.S.A Inc. + 1111 West Newport Cee Dive, Deerfeld Beach, FL Tol Free (888) 410-1975 wwu.golyalass.com

You might also like