You are on page 1of 188

Atlas Copco Stationary Air Compressors

ZT 110

Parts list

From following serial number :


APF - 134 079

Copyright 2008, Atlas Copco Airpower n.v., Antwerp, Belgium.


Any unauthorized use or copying of the contents or any part thereof is prohibited.
This applies in particular to trademarks, model denominations, part numbers and
drawings.
Use only authorized parts. Any damage or malfunction caused by the use
of unauthorized parts is not covered by Warranty or Product Liability.

No. 2930 1519 00

Registration code : APC Z110-275

2008-06
www.atlascopco.com
Parts list

Contents Indice
Inhoud Innholdsfortegnelse
Innehll Indice
Inhaltsverzeichnis Indholdsfortegnelse
Table des matires Sisllysluettelo
Indice

Gear casing ........................................................................ 1 - IMD - Piping - Tropical dryer .................................. 20


Compressor elements ......................................................... 2
- IMD - Piping - Tropical dryer -
Gears .................................................................................. 3 High ambient condition ........................................... 21
Compressor drive ............................................................... 4 - IMD - Cooler piping ................................................ 22
Breather .............................................................................. 5 - IMD - Gearcasing and gear drive ............................ 23
Air inlet .............................................................................. 6 - IMD - Electronic Drain System ............................... 24
Air filter .............................................................................. 7 - IMD - Electronic Drain System -
High Ambient Temperature vesion ......................... 25
Air flow
- Low pressure outlet ..................................................... 8 - IMD - Electronic Drain System -
Winterisation version .............................................. 26
- High pressure inlet ....................................................... 9
- IMD - Difference pressure indicator ....................... 27
- High pressure outlet ............................................... 10
- IMD - Low load - Heaters ........................................ 28
IMD - Low load - Piping .......................................... 29
Air outlet
- Pack - With aftercooler ............................................. 11
-

IMD - Regeneration air ............................................ 30


- Pack - Hot air variant - Safety valve ........................ 12
-
- FDT - Bodywork ..................................................... 31
Full Feature
- IMD - Air outlet - Without PDp filter ...................... 13 - FDT - Connection set -
without additional cooler ........................................ 32
- IMD - Air outlet - With PDp filter ............................ 14
- FDT - Connection set -
- IMD - Pressure vessel and rotor ............................. 15 with additional cooler .............................................. 33

- IMD - Mounts on vessel ......................................... 16 - FDT - Heat exchangers and drains .......................... 34

- IMD - Cooler ........................................................... 17 - FDT - Cubicle .......................................................... 35

- IMD - Piping ........................................................... 18 - FDT - Electrical and mechanical components ......... 36

- IMD - Piping - High ambient condition, - FDT - Additional cooler set .................................... 37
Outdoor version ...................................................... 19

2 2930 1519 00
Parts list

Contents Indice
Inhoud Innholdsfortegnelse
Innehll Indice
Inhaltsverzeichnis Indholdsfortegnelse
Table des matires Sisllysluettelo
Indice

Drain system - Safety valves Cubicle(s)


- With Aftercooler ..................................................... 38 - IEC ...........................................................................53
- With Aftercooler - High ambient condition, - IEC - High ambient condition, Outdoor version ..... 54
Outdoor version, Winterisation .............................. 39
- CSA-UL ................................................................... 55
- Hot air variant ......................................................... 40
- CSA-UL - High ambient condition,
- Hot air variant - High ambient condition, Outdoor version ...................................................... 56
Outdoor version, Winterisation .............................. 41
- Without motor ......................................................... 57
Cooler(s)
- Cooling system ....................................................... 42 - Without motor - High ambient condition,
Outdoor version ...................................................... 58
- With aftercooler ...................................................... 43
Bodywork
- Hot air variant ......................................................... 44 - Cubicle box .............................................................. 59
Oil system - Cubicle box - NEMA ............................................... 60
- With Single Oil filter ................................................ 45
- Inlet silencer without Pre-Filter Kit ......................... 61
- With Duplex Oil filter ............................................... 46
- Inlet silencer for separate air inlet
Drive arrangement ( with Pre-Filter Kit ) ................................................ 62
- Arr. E ....................................................................... 47 - Baffles ..................................................................... 63
- Arr. 1 ........................................................................ 48 - Baffles - Arr E .......................................................... 64
Control module - Baffles - Motorhood without motor ........................ 65
- Pack ......................................................................... 49
- Doors and stays ...................................................... 66
- Full-Feature ............................................................. 50
- Container box outside ............................................. 67
- Full-Feature - Pdp Sensor set without DDp filer ..... 51
Electrical system
- SPM monitoring ...................................................... 52 - Cubicle - Winterisation ............................................ 68
- Options .................................................................... 69

Service kits ................................................................... 70

2930 1519 00 3
Parts list

70871

4 2930 1519 00
Parts list

Gear casing
1

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

7.5bar(e) 50Hz 8.6bar(e) 60Hz


8.6bar(e) 50Hz 10.4bar(e) 60Hz
10bar(e) 50Hz 1005 1621 6578 01 1 Gear casing
1005 1621 6578 03 1 Gear casing 1010 1621 3297 00 1 Plug
1010 1621 3297 00 1 Plug 1015 0101 1951 50 2 Pin
1015 0101 1951 50 2 Pin 1020 0686 3716 09 4 Plug
1020 0686 3716 09 4 Plug 1025 0661 1000 31 4 Seal washer
1025 0661 1000 31 4 Seal washer 1030 0686 4230 07 1 Plug
1030 0686 4230 07 1 Plug 1035 9125 6303 00 1 Seal washer
1035 9125 6303 00 1 Seal washer

2930 1519 00 5
Parts list

70874

6 2930 1519 00
Parts list

Compressor elements
2

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Teflon elements 1080 0663 2103 19 1 O-ring


7.5bar(e) 1085 0147 1963 06 4 Bolt
8.6bar(e) 1090 0147 1963 05 2 Bolt
10bar(e) 1091 0301 2344 00 6 Washer
10.4bar(e) 1095 0686 3716 01 2 Plug
1 006 1616 5803 81 1 Service stage 1100 0661 1000 25 2 Seal washer
1616 5824 00 1 Diaphragm 1125 1621 3548 00 1 Pipe
1010 0663 2107 89 1 O-ring 1130 0580 3623 06 1 Pipe coupling
1015 0663 2103 22 1 O-ring 1135 0580 0400 03 1 Straight coupling
1020 0147 1963 04 4 Bolt 1140 0661 1000 25 1 Seal washer
1025 0147 1963 02 2 Bolt 1205 1621 3072 00 1 Hose assembly
1026 0300 0274 11 6 Washer 1210 0147 1323 03 4 Bolt
1030 0686 3716 01 2 Plug 1215 0663 2107 81 2 O-ring
1035 0661 1000 25 2 Seal washer 1220 1621 6616 00 1 Hose assembly
1040 0686 3716 07 1 Plug 1245 0147 1323 03 4 Bolt
1045 0661 1000 30 1 Seal washer 1250 0663 2107 81 2 O-ring
1 071 1616 5851 81 1 Service stage 1260 0686 3716 02 1 Plug
1616 5874 00 1 Diaphragm 1270 0653 1124 00 1 Flat gasket
1075 0663 2107 89 1 O-ring Teflon-free (Epoxy) elements
1080 0663 2103 19 1 O-ring 7.5bar(e)
1085 0147 1963 06 4 Bolt 8.6bar(e)
1090 0147 1963 05 2 Bolt 10bar(e)
1091 0301 2344 00 6 Washer 10.4bar(e)
1095 0686 3716 01 2 Plug 1 006 1616 5803 82 1 Service stage
1100 0661 1000 25 2 Seal washer 1616 5824 00 1 Diaphragm
1125 1621 3548 00 1 Pipe 1010 0663 2107 89 1 O-ring
1130 0580 3623 06 1 Pipe coupling 1015 0663 2103 22 1 O-ring
1135 0580 0400 03 1 Straight coupling 1020 0147 1963 04 4 Bolt
1140 0661 1000 25 1 Seal washer 1025 0147 1963 02 2 Bolt
1205 1621 3072 00 1 Hose assembly 1026 0300 0274 11 6 Washer
1210 0147 1323 03 4 Bolt 1030 0686 3716 01 2 Plug
1215 0663 2107 81 2 O-ring 1035 0661 1000 25 2 Seal washer
1220 1621 6616 00 1 Hose assembly 1040 0686 3716 07 1 Plug
1245 0147 1323 03 4 Bolt 1045 0661 1000 30 1 Seal washer
1250 0663 2107 81 2 O-ring 1 071 1616 5851 82 1 Service stage
Teflon elements 1616 5874 00 1 Diaphragm
10bar(e) High ambient 1075 0663 2107 89 1 O-ring
condition 1080 0663 2103 19 1 O-ring
10.4bar(e) High ambient 1085 0147 1963 06 4 Bolt
condition 1090 0147 1963 05 2 Bolt
10bar(e) Outdoor version 1091 0301 2344 00 6 Washer
10.4bar(e) Outdoor version 1095 0686 3716 01 2 Plug
1 006 1616 7186 87 1 Service stage 1100 0661 1000 25 2 Seal washer
1616 5824 00 1 Diaphragm 1125 1621 3548 00 1 Pipe
1010 0663 2107 89 1 O-ring 1130 0580 3623 06 1 Pipe coupling
1015 0663 2103 22 1 O-ring 1135 0580 0400 03 1 Straight coupling
1020 0147 1963 04 4 Bolt 1140 0661 1000 25 1 Seal washer
1025 0147 1963 02 2 Bolt 1205 1621 3072 00 1 Hose assembly
1026 0300 0274 11 6 Washer 1210 0147 1323 03 4 Bolt
1030 0686 3716 01 2 Plug 1215 0663 2107 81 2 O-ring
1035 0661 1000 25 2 Seal washer 1220 1621 6616 00 1 Hose assembly
1040 0686 3716 07 1 Plug 1245 0147 1323 03 4 Bolt
1045 0661 1000 30 1 Seal washer 1250 0663 2107 81 2 O-ring
1 071 1616 5851 87 1 Service stage
1616 5874 00 1 Diaphragm
1075 0663 2107 89 1 O-ring

2930 1519 00 7
Parts list

3 Gears

70875

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

7.5bar(e) 50Hz 1055 1616 6139 25 1 Gear wheel


1005 1616 6124 14 1 Gear wheel 1080 1614 6813 05 1 Gear wheel
1030 0211 1363 00 8 Cap screw 1100 0686 3115 38 1 Plug
1055 1616 6139 22 1 Gear wheel 10bar(e) 50Hz
1080 1614 6813 02 1 Gear wheel 1005 1616 6124 10 1 Gear wheel
1100 0686 3115 38 1 Plug 1030 0211 1363 00 8 Cap screw
8.6bar(e) 50Hz 1055 1616 6139 02 1 Gear wheel
1005 1616 6124 12 1 Gear wheel 1080 1614 6813 21 1 Gear wheel
1030 0211 1363 00 8 Cap screw 1100 0686 3115 38 1 Plug
1055 1616 6139 24 1 Gear wheel 10.4bar(e) 60Hz
1080 1614 6813 04 1 Gear wheel 1005 1616 6124 07 1 Gear wheel
1100 0686 3115 38 1 Plug 1030 0211 1363 00 8 Cap screw
8.6bar(e) 60Hz 1055 1616 6139 05 1 Gear wheel
1005 1616 6124 10 1 Gear wheel 1080 1614 6813 07 1 Gear wheel
1030 0211 1363 00 8 Cap screw 1100 0686 3115 38 1 Plug

8 2930 1519 00
Parts list

Compressor drive
4

70873

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1005 1616 6118 00 1 Drive shaft 1070 0335 1147 00 1 External circlip
1010 1616 6119 00 1 Retainer 1075 0335 2169 00 1 Internal circlip
1015 0502 1090 86 1 Bearing 1080 0337 0009 18 1 Parallel key
1020 1616 6463 00 1 Bearing housing 1085 1616 6294 00 1 Key
1025 0147 1330 03 4 Bolt 1110 0663 2107 88 1 O-ring
1030 0661 1000 42 4 Seal washer 1115 0147 1326 03 4 Bolt
1050 0663 2107 87 1 O-ring 1616 6120 00 1 Seal arr.
1055 0295 3114 00 1 Locknut 2005 1616 6121 00 1 Outer seal ring
1060 0147 1323 03 2 Bolt 2010 1616 6122 00 1 Inner seal ring
1065 0508 1100 50 1 Roller bearing

2930 1519 00 9
Parts list

70872

10 2930 1519 00
Parts list

Breather
5

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Breather 1085 0653 1100 00 1 Flat gasket


With aftercooler 1090 0580 0013 32 1 Coupling
1030 1621 7626 00 1 Pipe 1095 0653 1062 00 1 Flat gasket
1045 1621 7625 00 1 Pipe 1100 1623 1811 00 1 Pipe
1050 0580 0013 32 1 Coupling 1105 0580 0013 32 1 Coupling
1055 0661 1000 25 1 Seal washer 1110 0653 1062 00 1 Flat gasket
1060 0580 1404 00 1 Straight coupling 1115 1621 3529 00 1 Connection
1065 1621 5794 00 1 Pipe 1120 1619 5337 01 1 Bolt
1070 0580 0013 32 1 Coupling 1125 0300 8019 00 1 Washer
1075 0661 1000 25 1 Seal washer 1130 0580 0013 32 1 Coupling
2010 0663 2107 81 1 O-ring 1135 0653 1062 00 1 Flat gasket
2015 0211 1335 03 4 Cap screw 1140 0686 3716 01 1 Plug
2020 1614 8671 00 1 Housing 1145 0653 1062 00 1 Flat gasket
2025 0661 1000 25 1 Seal washer 2010 0663 2107 81 1 O-ring
2030 1614 8673 00 1 Filter element 2015 0211 1335 03 4 Cap screw
2035 0661 1000 30 1 Seal washer 2020 1614 8671 00 1 Housing
2040 1614 8672 00 1 Plug 2025 0653 1062 00 1 Flat gasket
1621 1865 80 1 Housing 2030 1614 8673 01 1 Filter element
3010 1621 1865 00 1 Housing 2035 0653 1189 00 1 Flat gasket
3 015 1202 6255 01 1 Filter element 2040 1614 8672 00 1 Plug
0663 9032 01 1 O-ring 1621 1865 83 1 Housing
3020 0663 2107 84 1 O-ring 3010 1621 1865 00 1 Housing
3025 1614 8222 00 1 Cover 3015 1202 6255 03 1 Filter element
3030 0211 1247 03 2 Cap screw 3020 0663 2107 84 1 O-ring
Hot air variant 3025 1614 8222 00 1 Cover
1030 1621 7626 00 1 Pipe 3030 0211 1247 03 2 Cap screw
1045 1621 7625 00 1 Pipe Connection
1050 0580 0013 32 1 Coupling With kit purge air during
1055 0653 1062 00 1 Seal washer standstill
1060 0580 1404 00 1 Straight coupling 4010 0580 4804 00 1 Pipe coupling
1065 1621 5794 00 1 Pipe Without kit purge air during
1070 0580 0013 32 1 Coupling standstill
1075 0653 1062 00 1 Seal washer 4010 0580 3404 00 1 Pipe coupling
1080 0686 3716 30 1 Plug

2930 1519 00 11
Parts list

70876

12 2930 1519 00
Parts list

Air inlet
6

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1010 0147 1478 03 2 Bolt High ambient condition


1015 0266 2114 00 2 Nut Outdoor version
1020 0147 1962 36 2 Bolt 1010 0147 1478 03 2 Bolt
1025 0301 2378 00 4 Washer 1015 0266 2114 00 2 Nut
1030 1202 9621 03 1 Gasket 1020 0147 1962 36 2 Bolt
1040 1621 3079 00 1 Valve seat 1025 0301 2378 00 4 Washer
1621 0071 88 1 Valve assembly 1030 1202 9621 03 1 Gasket
2005 1621 0071 05 1 Valve housing 1040 1621 3079 00 1 Valve seat
2010 1621 3786 00 1 Plug 1621 0071 88 1 Valve assembly
2015 0500 4510 10 2 Bearing 2005 1621 0071 05 1 Valve housing
2020 1621 0079 00 1 Piston 2010 1621 3786 00 1 Plug
2025 2102 0802 00 1 Spring 2015 0500 4510 10 2 Bearing
2030 2102 0804 00 1 Valve hp.unload 2020 1621 0079 00 1 Piston
2035 0335 1122 00 1 Ext.circlip 2025 2102 0802 00 1 Spring
2050 1621 3757 00 1 Valve 2030 2102 0804 00 1 Valve hp.unload
2055 1621 3758 00 1 Shaft 2035 0335 1122 00 1 Ext.circlip
2060 1621 0074 00 1 Bearing housing 2050 1621 3757 00 1 Valve
2065 1621 0075 00 1 Ring 2055 1621 3758 00 1 Shaft
2070 0301 2144 01 1 Washer 2060 1621 0074 00 1 Bearing housing
2075 1621 3759 00 1 Locknut 2065 1621 0075 00 1 Ring
2090 0500 4510 22 2 Bearing 2070 0301 2144 01 1 Washer
2095 1621 0076 00 2 Pivot pin 2075 1621 3759 00 1 Locknut
2100 0261 1099 11 2 Nut 2090 0500 4510 22 2 Bearing
2105 1621 0081 00 2 Washer 2095 1621 0076 00 2 Pivot pin
2120 1621 0078 00 1 Diaphragm 2100 0261 1099 11 2 Nut
2125 1621 3245 00 1 Valve cover 2105 1621 0081 00 2 Washer
2130 0147 1364 03 8 Bolt 2120 1621 0078 00 1 Diaphragm
2145 1621 5282 00 1 Manifold 2125 1621 3245 00 1 Valve cover
2150 1613 4036 00 1 Membrane 2130 0147 1364 03 8 Bolt
2155 1613 5723 00 1 Gasket 2145 1621 5282 00 1 Manifold
2160 0147 1331 03 2 Bolt 2150 1613 4036 00 1 Membrane
2165 0301 2335 00 2 Washer 2155 1613 5723 00 1 Gasket
2180 1621 3787 00 1 Bolt 2160 0147 1331 03 2 Bolt
2185 0261 1099 11 1 Nut 2165 0301 2335 00 2 Washer
3010 0580 0013 32 2 Coupling 2180 1621 3787 00 1 Bolt
3015 0661 1000 25 2 Seal washer 2185 0261 1099 11 1 Nut
3050 1623 0710 00 1 Pipe 3010 0580 0013 32 2 Coupling
3055 0580 0014 34 1 Pipe coupling 3015 0661 1000 25 2 Seal washer
3060 0661 1000 24 1 Seal washer 3020 0580 2404 00 1 Pipe coupling
3065 0580 0013 32 1 Coupling 3050 1623 0710 00 1 Pipe
3070 0661 1000 25 1 Seal washer 3055 0580 0014 34 1 Pipe coupling
3075 1089 0428 14 1 Solenoid valve 3060 0661 1000 24 1 Seal washer
3080 1621 5283 00 1 Manifold 3065 0580 0013 32 1 Coupling
3085 0147 1170 03 4 Bolt 3070 0661 1000 25 1 Seal washer
3090 1621 5284 00 1 Support 3075 1089 0590 21 1 Solenoid valve
3093 1619 5188 00 AR Seal 3080 1621 5285 00 1 Manifold
3095 1079 1472 05 2 Bolt 3085 0147 1170 03 4 Bolt
3100 0580 0013 32 2 Coupling 3090 1621 5284 00 1 Support
3105 0661 1000 25 2 Seal washer 3093 1619 5188 00 AR Seal
3110 0607 3000 18 1 Socket 3095 1079 1472 05 2 Bolt
3115 0661 1000 24 1 Seal washer 3100 0580 0013 32 3 Coupling
3120 0580 2404 00 1 Pipe coupling 3105 0661 1000 25 3 Seal washer
3125 2250 6353 04 1 Flexible 3107 0663 2108 63 3 O-ring
3130 2250 6353 05 1 Flexible 3112 0211 1251 03 4 Bolt
3135 2250 6353 05 1 Flexible 3117 2250 6353 03 3 Flexible
3122 1088 1301 04 1 Cable strip

2930 1519 00 13
Parts list

70877

14 2930 1519 00
Parts list

Air filter
7

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1030 1621 2244 00 1 Hose High ambient condition


1035 0347 6122 00 1 Hose clip Outdoor version
1040 0347 6124 00 2 Hose clip 1015 1621 4328 00 1 Hose
1045 1621 2696 00 1 Pipe 1020 0347 6122 00 2 Hose clip
1050 1621 2699 00 1 Pipe 1621 4337 81 1 Filter
1621 5387 81 1 Filter 2010 1621 1389 00 1 Filter element
2010 1621 1389 00 1 Filter element 2015 1621 2245 00 2 Clamp
2015 1621 2245 00 2 Clamp 1621 4337 80 1 Housing
1621 5387 80 1 Housing 3005 1621 4336 00 1 Housing
3005 1621 5387 00 1 Housing 3012 1621 4335 00 1 Inlet
3010 1621 4883 00 1 Ring 3020 1621 4337 00 1 Outlet
3015 1621 5386 00 1 Manifold
3020 1621 5388 00 1 Outlet

2930 1519 00 15
Parts list

70878

16 2930 1519 00
Parts list

Air flow - Low pressure outlet


8

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

7.5bar(e) 10bar(e) Outdoor version


8.6bar(e) 10.4bar(e) Outdoor version
10bar(e) Winterisation Outdoor
10.4bar(e) version
1088 0266 2112 00 8 Nut 1088 0266 2112 00 8 Nut
1116 0663 2107 33 4 O-ring 1116 1621 2254 32 4 O-ring
1120 1621 2764 00 1 Pipe 1120 1621 2764 00 1 Pipe
1125 1621 2253 00 2 Tie rod 1125 1621 2253 00 2 Tie rod
1130 0301 2371 00 4 Washer 1130 0301 2371 00 4 Washer
2005 1621 4728 11 1 Pipe 2005 1621 4728 12 1 Pipe
2007 0686 3716 01 2 Plug 2007 0686 3716 01 2 Plug
2008 0653 1062 00 2 Flat gasket 2008 0653 1062 00 2 Flat gasket
2009 0686 3716 30 1 Plug 2009 0686 3716 30 1 Plug
2010 0653 1100 00 1 Flat gasket 2010 0653 1100 00 1 Flat gasket
2012 0663 2107 33 1 O-ring 2012 1621 2254 00 1 O-ring
2015 0147 1962 31 4 Bolt 2015 0147 1962 31 4 Bolt
2020 1621 2762 00 1 Pipe 2020 1621 2762 00 1 Pipe
2025 0663 2107 33 2 O-ring 2025 1621 2254 32 2 O-ring
2030 1621 2250 00 1 Plate 2030 1621 2250 00 1 Plate
2032 0333 7131 12 2 Tab washer 2032 0333 7131 12 2 Tab washer
2035 1621 4714 00 2 Bolt 2035 1621 4714 00 2 Bolt
2040 1621 4727 11 1 Silencer 2040 1621 4727 12 1 Silencer
2045 0101 1951 52 1 Pin 2045 0101 1951 52 1 Pin
2050 0147 1477 03 2 Bolt 2050 0147 1477 03 2 Bolt
2053 0302 1274 04 2 Washer 2053 0302 1274 04 2 Washer
2055 1621 4101 00 1 Insert 2055 1621 4101 00 1 Insert
2060 1621 3925 00 1 Insulation 2060 1621 2255 00 1 Insulation
2065 0663 2107 50 2 O-ring 2065 1621 2254 02 2 O-ring
2070 0663 2107 49 1 O-ring 2070 1621 2254 03 1 O-ring
2075 0102 0460 00 2 Pin 2075 0102 0460 00 2 Pin
2080 1621 1411 11 1 Collector 2080 1621 1411 12 1 Collector
2085 0147 1402 03 5 Bolt 2085 0147 1402 03 5 Bolt
2087 0246 1956 58 1 Stud 2087 0246 1956 58 1 Stud
2088 0266 2112 00 1 Nut 2088 0266 2112 00 1 Nut
2090 0101 1951 52 1 Pin 2090 0101 1951 52 1 Pin
2095 0147 1477 03 2 Bolt 2095 0147 1477 03 2 Bolt
2098 0302 1274 04 2 Washer 2098 0302 1274 04 2 Washer
2100 1621 7436 11 1 Collector 2100 1621 7436 15 1 Collector
2105 0102 0460 00 2 Pin 2105 0102 0460 00 2 Pin
2110 0211 1404 03 3 Cap screw 2110 0211 1404 03 3 Cap screw
2115 0663 2107 33 1 O-ring 2115 1621 2254 00 1 O-ring
2145 1621 3074 00 1 Cover 2145 1621 3074 00 1 Cover
2150 0663 2107 97 1 O-ring 2150 1621 2254 12 1 O-ring
2155 0147 1962 29 4 Bolt 2155 0147 1962 29 4 Bolt
10bar(e) High ambient
condition
10.4bar(e) High ambient
condition

2930 1519 00 17
Parts list

70879

18 2930 1519 00
Parts list

Air flow - High pressure inlet


9

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1005 1621 2256 00 1 Pipe 1027 0686 3716 01 1 Plug


1010 0663 2107 33 1 O-ring 1028 0661 1000 25 1 Seal washer
1015 0147 1402 03 4 Bolt 1029 0560 4401 10 1 Tee
1020 0634 1001 06 2 Pipe coupling 1030 1621 2256 00 1 Pipe
1025 1621 2258 00 1 Pipe 1035 0663 2107 33 1 O-ring
1026 0603 4102 03 1 Hexagon nipple 1040 0147 1402 03 4 Bolt

2930 1519 00 19
Parts list

10

70880

20 2930 1519 00
Parts list

Air flow - High pressure outlet


10

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Pack - With aftercooler 1045 1621 3013 00 3 Bolt


7.5bar(e) 1046 1621 2254 06 1 Seal
8.6bar(e) 1050 1621 2262 00 1 Insulation
10bar(e) 1055 1621 2254 08 2 O-ring
10.4bar(e) 1060 1621 4108 00 1 Insert
1005 1621 3054 00 1 Pipe 1065 0147 1363 03 4 Bolt
1010 0663 2107 92 1 O-ring 1070 1621 3466 00 1 Valve seat
1015 0211 1402 03 4 Cap screw 1075 1621 2254 09 1 O-ring
1020 0686 3716 01 1 Plug 1080 1614 7368 00 1 Check valve
1025 0653 1070 00 1 Flat gasket 1085 1621 3014 00 1 Spring
1030 0147 1962 29 3 Bolt 1090 1621 2254 10 1 O-ring
1035 0663 2107 91 1 O-ring 1100 0147 1962 30 6 Bolt
1040 1621 3018 11 1 Silencer 1105 0147 1363 03 4 Bolt
1045 1621 3013 00 3 Bolt 1110 1621 2254 11 1 O-ring
1046 0663 2107 92 1 O-ring 1130 1621 2764 00 1 Pipe
1050 1621 3924 00 1 Insulation 1621 3008 83 1 Check valve
1055 0663 2107 15 2 O-ring 2005 1621 3008 15 1 Housing
1060 1621 4108 00 1 Insert 2010 0500 4510 11 1 Bearing
1065 0147 1363 03 4 Bolt Pack - Hot air variant
1070 1621 3466 00 1 Valve seat 7.5bar(e)
1075 0663 2107 16 1 O-ring 8.6bar(e)
1080 1614 7368 00 1 Check valve 10bar(e)
1085 1621 3014 00 1 Spring 10.4bar(e)
1090 0663 2107 93 1 O-ring 1005 1621 3054 00 1 Pipe
1100 0147 1962 30 6 Bolt 1010 0663 2107 92 1 O-ring
1105 0147 1363 03 4 Bolt 1015 0211 1402 03 4 Cap screw
1110 0663 2107 94 1 O-ring 1020 0686 3716 01 1 Plug
1130 1621 2764 00 1 Pipe 1025 0653 1070 00 1 Flat gasket
1621 3008 80 1 Check valve 1030 0147 1962 29 3 Bolt
2005 1 Housing 1035 0663 2107 91 1 O-ring
2010 0500 4510 11 1 Bearing 1040 1621 3018 11 1 Silencer
Pack - With aftercooler 1045 1621 3013 00 3 Bolt
10bar(e) High ambient 1046 0663 2107 92 1 O-ring
condition 1050 1621 3924 00 1 Insulation
10.4bar(e) High ambient 1055 0663 2107 15 2 O-ring
condition 1060 1621 4108 00 1 Insert
10bar(e) Outdoor version 1065 0147 1363 03 4 Bolt
10.4bar(e) Outdoor version 1070 1621 3466 00 1 Valve seat
Winterisation Outdoor 1075 0663 2107 16 1 O-ring
version 1080 1614 7368 00 1 Check valve
1005 1621 2260 00 1 Pipe 1085 1621 3014 00 1 Spring
1006 1621 5044 01 1 Cap 1090 0663 2107 93 1 O-ring
1007 0634 1000 27 1 Victaulic coupling 1100 0147 1962 30 6 Bolt
1008 1621 2254 05 1 Seal 1105 0147 1363 03 4 Bolt
1010 1621 2254 06 1 O-ring 1110 0663 2107 94 1 O-ring
1015 0211 1402 03 4 Cap screw 1125 0147 1962 29 4 Bolt
1020 0686 3716 01 1 Plug 1130 1621 2763 00 1 Pipe
1025 0653 1070 00 1 Flat gasket 1621 3008 80 1 Check valve
1030 0147 1962 29 3 Bolt 2005 1 Housing
1035 1621 2254 07 1 O-ring 2010 0500 4510 11 1 Bearing
1040 1621 3018 12 1 Silencer

2930 1519 00 21
Parts list

10

70880

22 2930 1519 00
Parts list

Air flow - High pressure outlet


10

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Full Feature - With 10.4bar(e) High ambient


aftercooler condition
7.5bar(e) 10bar(e) Outdoor version
8.6bar(e) 10.4bar(e) Outdoor version
10bar(e) Winterisation Outdoor
10.4bar(e) version
1005 1621 1407 00 1 Pipe 1005 1621 2260 00 1 Pipe
1010 0663 2107 92 1 O-ring 1010 1621 2254 06 1 Seal
1015 0211 1402 03 4 Cap screw 1015 0211 1402 03 4 Cap screw
1030 0147 1962 29 3 Bolt 1020 0686 3716 01 1 Plug
1035 0663 2107 91 1 O-ring 1025 0653 1070 00 1 Flat gasket
1040 1621 3018 11 1 Silencer 1030 0147 1962 29 3 Bolt
1045 1621 3013 00 3 Bolt 1035 1621 2254 07 1 Seal
1046 0663 2107 92 1 O-ring 1040 1621 3018 12 1 Silencer
1050 1621 3924 00 1 Insulation 1045 1621 3013 00 3 Bolt
1055 0663 2107 15 2 O-ring 1046 1621 2254 06 1 Seal
1060 1621 4108 00 1 Insert 1050 1621 2262 00 1 Insulation
1065 0147 1363 03 4 Bolt 1055 1621 2254 08 2 Seal
1070 1621 3466 00 1 Valve seat 1060 1621 4108 00 1 Insert
1075 0663 2107 16 1 O-ring 1065 0147 1363 03 4 Bolt
1080 1614 7368 00 1 Check valve 1070 1621 3466 00 1 Valve seat
1085 1621 3014 00 1 Spring 1075 1621 2254 09 1 Seal
1090 0663 2107 93 1 O-ring 1080 1614 7368 00 1 Check valve
1100 0147 1962 30 6 Bolt 1085 1621 3014 00 1 Spring
1105 0147 1363 03 4 Bolt 1090 1621 2254 10 1 Seal
1110 0663 2107 94 1 O-ring 1100 0147 1962 30 6 Bolt
1125 0147 1962 29 4 Bolt 1105 0147 1363 03 4 Bolt
1130 1621 2764 00 1 Pipe 1110 1621 2254 11 1 Seal
1621 3008 80 1 Check valve 1125 0147 1962 29 4 Bolt
2005 1 Housing 1130 1621 2764 00 1 Pipe
2010 0500 4510 11 1 Bearing 1621 3008 83 1 Check valve
Full Feature - With 2005 1 Housing
aftercooler 2010 0500 4510 11 1 Bearing
10bar(e) High ambient
condition

2930 1519 00 23
Parts list

11

70881

24 2930 1519 00
Parts list

Air outlet - Pack - With aftercooler


11

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1005 1621 2267 00 1 Pipe 1050 1619 2766 00 2 Bolt


1010 0663 2107 33 1 O-ring Air connection
1015 0147 1402 03 4 Bolt ANSI
1020 0634 1000 22 1 Victaulic coupling 2005 1621 8114 00 1 Compensator
1025 1621 4279 00 1 Pipe 2010 0147 1478 03 4 Bolt
1026 0147 1326 03 1 Bolt DIN
1027 0333 3227 00 1 Lock washer 2005 1621 3098 00 1 Compensator
1028 0300 0275 01 2 Plain washer 2010 0147 1478 03 4 Bolt
1029 0266 2110 00 1 Hexagon nut Outdoor version
1030 1619 2766 00 2 Bolt 3010 1621 5733 00 1 Pipe
1037 1621 4280 00 1 Bracket 3020 0147 1477 03 4 Bolt
1040 0634 1000 22 1 Victaulic coupling 3030 0663 2107 79 1 O-ring
1045 1621 4366 00 1 Pipe

2930 1519 00 25
Parts list

12

70882

26 2930 1519 00
Parts list

Air outlet - Pack - Hot air variant - Safety valve


12

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Outlet piping 7.5bar(e) CE


1005 0634 1000 22 1 Victaulic coupling 8.6bar(e) CE
1007 1621 2271 00 1 Seal 7.5bar(e) CHINA
1010 1621 2270 00 1 Pipe 8.6bar(e) CHINA
1012 0147 1326 03 1 Bolt 2035 0830 1006 25 1 Safety valve
1014 0333 3227 00 1 Lock washer 2040 0653 1227 00 1 Flat gasket
1016 0300 0275 01 2 Plain washer 10bar(e) CE
1018 0266 2110 00 1 Hexagon nut 10.4bar(e) CE
1025 0634 1000 22 1 Victaulic coupling 10bar(e) CHINA
1027 1621 2271 00 1 Seal 10.4bar(e) CHINA
1030 1621 4366 00 1 Pipe 2035 0830 1006 05 1 Safety valve
1032 1619 2766 00 2 Bolt 2040 0653 1227 00 1 Flat gasket
1035 1619 2766 00 2 Bolt Air Connection
1042 1621 4280 00 1 Bracket ANSI
1045 1621 4296 00 1 Pipe 3005 0663 2107 25 2 O-ring
1050 0147 1480 03 4 Bolt 3010 1621 4713 00 1 Spacer
1052 0266 2114 00 4 Nut 3015 0211 1479 03 4 Cap screw
1055 0663 2107 25 1 O-ring 3020 1621 0177 04 1 Compensator
1070 0070 9085 41 AR Insulation 3022 1621 6271 02 1 Compensator
1080 0017 9860 58 AR Tape 3023 1621 3520 00 1 Pipe
Safety valve 3024 0663 2107 25 2 O-ring
7.5bar(e) ASME (U Stamp) 3025 0147 1481 03 8 Bolt
8.6bar(e) ASME (U Stamp) 3026 0266 2114 00 8 Nut
7.5bar(e) DIR 3030 0147 1481 03 8 Bolt
8.6bar(e) DIR 3031 0266 2114 00 8 Nut
7.5bar(e) Lloyds 3035 0147 1481 03 4 Bolt
8.6bar(e) Lloyds 3040 0266 2114 00 4 Nut
7.5bar(e) Japan DIN
8.6bar(e) Japan 3005 0663 2107 25 2 O-ring
2025 0605 8700 81 1 Bushing 3010 1621 4713 00 1 Spacer
2035 0832 1001 06 1 Safety valve 3015 0211 1479 03 4 Cap screw
2040 0653 1227 00 1 Flat gasket 3020 1621 0177 04 2 Compensator
10bar(e) ASME (U Stamp) 3023 1621 3520 00 1 Pipe
10.4bar(e) ASME (U Stamp) 3024 0663 2107 25 2 O-ring
10bar(e) DIR 3025 0147 1481 03 8 Bolt
10.4bar(e) DIR 3026 0266 2114 00 8 Nut
10bar(e) Lloyds 3030 0147 1481 03 8 Bolt
10.4bar(e) Lloyds 3031 0266 2114 00 8 Nut
10bar(e) Japan 3035 0147 1481 03 4 Bolt
10.4bar(e) Japan 3040 0266 2114 00 4 Nut
2025 0605 8700 81 1 Bushing Outdoor version
2035 0832 1001 07 1 Safety valve 4010 1621 5733 00 1 Pipe
2040 0653 1227 00 1 Flat gasket 4020 0147 1477 03 4 Bolt
4030 0663 2107 79 1 O-ring

2930 1519 00 27
Parts list

13

70883

28 2930 1519 00
Parts list

Full Feature - IMD - Air outlet - Without PDp filter


13

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1005 1621 2275 00 1 Pipe 1110 0347 6105 00 2 Hose clip


1010 0650 0101 11 1 Gasket type 1115 0075 4005 51 AR Hose
1015 0211 1477 03 4 Cap screw 1120 1617 6173 00 1 Silencer
1020 0634 1000 22 1 Victaulic coupling 1130 0697 9809 02 2 Nut
1025 1621 4366 00 1 Pipe 1131 1088 0254 40 1 Enlarger
1030 1619 2766 00 2 Bolt 1140 0301 2321 00 2 Washer
1090 0147 1401 03 6 Bolt 1141 0291 1108 00 2 Locknut
1095 0301 2358 00 6 Washer Air connection
Low load ANSI
1020 0634 1000 22 1 Victaulic coupling 2005 1621 8114 00 1 Compensator
1025 1621 4366 00 1 Pipe 2010 0147 1478 03 4 Bolt
1045 0266 2111 00 2 Nut DIN
1050 0147 1366 03 2 Bolt 2005 1621 3098 00 1 Compensator
1055 0663 7143 00 1 O-ring 2010 0147 1478 03 4 Bolt
1060 1621 4405 00 1 Pipe Outdoor version
1080 1619 2766 00 2 Bolt 3010 1621 5733 00 1 Pipe
1090 0147 1401 03 6 Bolt 3020 0147 1477 03 4 Bolt
1095 0301 2358 00 6 Washer 3030 0663 2107 79 1 O-ring
1105 9000 0243 00 2 Hose nipple

2930 1519 00 29
Parts list

14

70884

30 2930 1519 00
Parts list

Full Feature - IMD - Air outlet - With PDp filter


14

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

No low load 1036 1 Pot. free contact


1005 1621 2276 00 1 Pipe 1617 7250 00 1 Contact
1010 0650 0101 11 1 Gasket 1040 1621 4163 00 1 Pipe
1015 0147 1476 03 4 Bolt 1045 0266 2111 00 2 Nut
1020 0266 2111 00 2 Nut 1050 0147 1365 03 2 Bolt
1025 0147 1365 03 2 Bolt 1055 0663 7143 00 1 O-ring
1030 0663 7143 00 1 O-ring 1060 1619 2766 00 2 Bolt
1036 1617 7250 00 1 Pot. free contact nc 1070 0634 1000 22 1 Victaulic coupling
1040 1621 2278 00 1 Pipe 1075 1621 4366 00 1 Pipe
1045 0266 2111 00 2 Nut 1095 0301 2358 00 6 Washer
1050 0147 1365 03 2 Bolt 1105 9000 0243 00 2 Hose nipple
1055 0663 7143 00 1 O-ring 1110 0347 6105 00 2 Hose clip
1060 1619 2766 00 2 Bolt 1115 0075 4005 51 AR Hose
1070 0634 1000 22 1 Victaulic coupling 1120 1617 6173 00 1 Silencer
1075 1621 4366 00 1 Pipe 1130 0697 9809 02 2 Nut
1080 1619 2766 00 2 Bolt 1131 1088 0254 40 1 Enlarger
1090 0147 1401 03 6 Bolt 1140 0301 2321 00 2 Washer
1095 0301 2358 00 6 Washer 1141 0291 1108 00 2 Locknut
8102 2641 50 1 Filter pd 390p 8102 2641 50 1 Filter pd 390p
1 Head/bowl 1 Head/bowl
2010 1617 7008 00 1 Head 2010 1617 7008 00 1 Head
2030 1617 7016 00 1 Bowl 2030 1617 7016 00 1 Bowl
2040 0663 2112 11 1 O-ring 2040 0663 2112 11 1 O-ring
2050 0160 0996 06 2 Screw 2050 0160 0996 06 2 Screw
2060 0661 1010 00 2 Seal washer 2060 0661 1010 00 2 Seal washer
2070 0663 9095 00 1 O-ring 2070 0663 9095 00 1 O-ring
2080 1617 7114 00 1 Sight glass 2080 1617 7114 00 1 Sight glass
2110 0690 1112 01 2 Atlas copco logo 2110 0690 1112 01 2 Atlas copco logo
2200 1079 9921 13 2 URL label 2200 1079 9921 13 2 URL label
1 Cartridge 1 Cartridge
3010 1617 7043 01 1 Filter element 3010 1617 7043 01 1 Filter element
1 Manual drain assy 1 Manual drain assy
4010 1617 7050 00 1 Manual drain valve 4010 1617 7050 00 1 Manual drain valve
4020 0663 2111 29 1 O-ring 4020 0663 2111 29 1 O-ring
4030 1617 7046 00 1 Nut 4030 1617 7046 00 1 Nut
1 Misc. parts 1 Misc. parts
5040 1624 1172 00 1 Diff. press.gauge 5040 1624 1172 00 1 Diff. press.gauge
5070 1624 1015 01 1 Label PD 390p 5070 1624 1015 01 1 Label PD 390p
Air connection Air connection
ANSI ANSI
6005 1621 8114 00 1 Compensator 6005 1621 8114 00 1 Compensator
6010 0147 1478 03 4 Bolt 6010 0147 1478 03 4 Bolt
DIN DIN
6005 1621 3098 00 1 Compensator 6005 1621 3098 00 1 Compensator
6010 0147 1478 03 4 Bolt 6010 0147 1478 03 4 Bolt
Low load Outdoor version
1020 0266 2111 00 2 Nut 7010 1621 5733 00 1 Pipe
1025 0147 1365 03 2 Bolt 7020 0147 1477 03 4 Bolt
1030 0663 7143 00 1 O-ring 7030 0663 2107 79 1 O-ring

2930 1519 00 31
Parts list

15

70885

32 2930 1519 00
Parts list

Full Feature - IMD - Pressure vessel and rotor


15

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Rotor 3090 0147 1401 03 12 Bolt


1010 1614 7618 53 1 Rotor 3100 0301 2358 00 12 Washer
1 020 1617 5380 05 1 Seal ring 4010 1617 5891 00 1 Support
1617 5322 00 AR Seal 4020 1617 5892 00 1 Support
Silicone-free rotor 4030 1617 5893 00 1 Support
1010 1614 7618 53 1 Rotor 4040 1617 5894 00 1 Support
1 020 1617 5380 05 1 Seal ring 4050 1617 5895 00 1 Support
1617 5322 00 AR Seal 4060 1617 5896 00 1 Guide
Pressure vessel 4070 1617 5897 00 1 Guide
ASME 4080 1617 5900 00 1 Plate
2030 1079 9923 75 1 Label 4090 1617 5901 00 1 Plate
1617 5968 86 1 Vessel 4100 1617 5903 00 2 Spacer
3010 1614 7358 00 1 Cover 4110 0147 1401 03 14 Bolt
3020 1614 7360 00 1 Housing 4120 0301 2358 00 14 Washer
3030 1614 7357 00 1 Cover 4130 0147 1360 03 8 Bolt
3040 0663 9307 00 2 O-ring 4140 0301 2344 00 8 Washer
3050 0147 1962 15 7 Bolt DIR
3060 0147 1962 48 25 Bolt LLOYDS
3070 0261 1090 68 25 Nut SA
3080 0301 2378 00 32 Washer TTK
3090 0147 1401 03 12 Bolt 2030 1079 9923 75 1 Label
3100 0301 2358 00 12 Washer 1617 5968 88 1 Vessel
4010 1617 5891 00 1 Support 3010 1614 7358 00 1 Cover
4020 1617 5892 00 1 Support 3020 1614 7360 00 1 Housing
4030 1617 5893 00 1 Support 3030 1614 7357 00 1 Cover
4040 1617 5894 00 1 Support 3040 0663 9307 00 2 O-ring
4050 1617 5895 00 1 Support 3050 0147 1480 03 7 Bolt
4060 1617 5896 00 1 Guide 3060 0147 1483 03 25 Bolt
4070 1617 5897 00 1 Guide 3070 0266 2114 00 25 Nut
4080 1617 5900 00 1 Plate 3080 0301 2378 00 32 Washer
4090 1617 5901 00 1 Plate 3090 0147 1401 03 12 Bolt
4100 1617 5903 00 2 Spacer 3100 0301 2358 00 12 Washer
4110 0147 1401 03 14 Bolt 4010 1617 5891 00 1 Support
4120 0301 2358 00 14 Washer 4020 1617 5892 00 1 Support
4130 0147 1360 03 8 Bolt 4030 1617 5893 00 1 Support
4140 0301 2344 00 8 Washer 4040 1617 5894 00 1 Support
CE 4050 1617 5895 00 1 Support
2030 1079 9923 75 1 Label 4060 1617 5896 00 1 Guide
1617 5968 99 1 Vessel 4070 1617 5897 00 1 Guide
3010 1614 7358 00 1 Cover 4080 1617 5900 00 1 Plate
3020 1614 7360 00 1 Housing 4090 1617 5901 00 1 Plate
3030 1614 7357 00 1 Cover 4100 1617 5903 00 2 Spacer
3040 0663 9307 00 2 O-ring 4110 0147 1401 03 14 Bolt
3050 0147 1962 15 7 Bolt 4120 0301 2358 00 14 Washer
3060 0147 1962 48 25 Bolt 4130 0147 1360 03 8 Bolt
3070 0261 1090 68 25 Nut 4140 0301 2344 00 8 Washer
3080 0301 2378 00 32 Washer

2930 1519 00 33
Parts list

15

70885

34 2930 1519 00
Parts list

Full Feature - IMD - Pressure vessel and rotor


15

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

MOL 3050 0147 1962 15 7 Bolt


2030 1079 9923 75 1 Label 3060 0147 1962 48 25 Bolt
1617 5968 80 1 Vessel 3070 0261 1090 68 25 Nut
3010 1614 7358 00 1 Cover 3080 0301 2378 00 32 Washer
3020 1614 7360 00 1 Housing 3090 0147 1401 03 12 Bolt
3030 1614 7357 00 1 Cover 3100 0301 2358 00 12 Washer
3040 0663 9307 00 2 O-ring 4010 1617 5891 00 1 Support
3050 0147 1962 15 7 Bolt 4020 1617 5892 00 1 Support
3060 0147 1962 48 25 Bolt 4030 1617 5893 00 1 Support
3070 0261 1090 68 25 Nut 4040 1617 5894 00 1 Support
3080 0301 2378 00 32 Washer 4050 1617 5895 00 1 Support
3090 0147 1401 03 12 Bolt 4060 1617 5896 00 1 Guide
3100 0301 2358 00 12 Washer 4070 1617 5897 00 1 Guide
4010 1617 5891 00 1 Support 4080 1617 5900 00 1 Plate
4020 1617 5892 00 1 Support 4090 1617 5901 00 1 Plate
4030 1617 5893 00 1 Support 4100 1617 5903 00 2 Spacer
4040 1617 5894 00 1 Support 4110 0147 1401 03 14 Bolt
4050 1617 5895 00 1 Support 4120 0301 2358 00 14 Washer
4060 1617 5896 00 1 Guide 4130 0147 1360 03 8 Bolt
4070 1617 5897 00 1 Guide 4140 0301 2344 00 8 Washer
4080 1617 5900 00 1 Plate Safety valve set
4090 1617 5901 00 1 Plate ASME With "Bypass"
4100 1617 5903 00 2 Spacer 5010 0830 1008 16 1 Safety valve
4110 0147 1401 03 14 Bolt 5020 0653 1189 00 1 Flat gasket
4120 0301 2358 00 14 Washer CE With "Bypass"
4130 0147 1360 03 8 Bolt DIR With "Bypass"
4140 0301 2344 00 8 Washer LLOYDS With "Bypass"
SQL SA With "Bypass"
2030 1079 9923 75 1 Label TTK With "Bypass"
1617 5968 84 1 Vessel MOL With "Bypass"
3010 1614 7358 00 1 Cover SQL With "Bypass"
3020 1614 7360 00 1 Housing 5010 0830 1008 12 1 Safety valve
3030 1614 7357 00 1 Cover 5020 0653 1189 00 1 Flat gasket
3040 0663 9307 00 2 O-ring

2930 1519 00 35
Parts list

16

70886

36 2930 1519 00
Parts list

Full Feature - IMD Mounts on vessel


16
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1010 1614 7605 10 1 Demister 2110 0147 1244 03 3 Bolt


1020 1614 7626 00 1 Seal ring 2120 0300 0274 64 3 Plain washer
1030 0211 1323 01 14 Hex sock. screw 2130 1617 5109 00 3 Nut
1040 1614 7657 00 1 Plate 2140 0852 0010 09 1 Ball valve
1050 1619 2473 00 AR Seal 2150 0686 3716 30 1 Plug
1060 0147 1247 02 2 Hex. head screw 2160 0653 1100 00 1 Flat gasket
1070 0333 3120 01 2 Lock washer Winterisation -
1080 0266 1108 02 2 Hexagon nut With "Bypass"
1090 1089 0574 46 1 Temperature sensor 2010 1614 7597 00 1 Housing
1095 1089 0574 46 1 Temperature sensor 2020 1617 5110 00 3 Valve
1210 0663 9868 00 1 O-ring 2030 1614 7595 00 3 Bonnet
1220 0211 1962 41 3 Hex sock. screw 2040 1614 7596 00 3 Valve spindle
1230 0301 2121 01 3 Plain washer 2050 0335 3512 00 3 Snap ring
1240 1614 7606 00 1 Sealing ring 2060 1614 7593 00 3 Packing nut
1250 1617 5598 80 1 Assembly 2070 0663 2104 03 3 O-ring
1260 1614 7592 00 1 Spring 2080 0653 1165 00 3 Flat gasket
1270 1614 7591 00 1 Seal ring 2090 0663 2112 26 3 O-ring
1280 1614 7604 00 1 Sealing sector 2095 1617 5976 00 3 Ring
1290 1617 5006 00 1 Ring 2100 1617 7374 00 3 Wheel
1300 0111 1279 01 3 Split pin 2110 0147 1244 03 3 Bolt
1310 0581 0016 01 1 Pipe coupling 2120 0300 0274 64 3 Plain washer
1320 0653 1062 00 1 Flat gasket 2130 1617 5109 00 3 Nut
1340 0581 0016 01 1 Pipe coupling 2150 0686 3716 30 1 Plug
1350 0653 1062 00 1 Flat gasket 2160 0653 1100 00 1 Flat gasket
1360 1614 7663 00 1 Strainer 2200 0603 4100 32 1 Hexagon nipple
1370 1614 7726 00 1 Washer 2210 0564 3304 01 1 Tee
1420 0147 1478 03 4 Bolt 2220 0852 0010 26 1 Ball valve
1430 1617 5806 00 2 O-ring Nozzle set
1440 0147 1421 03 2 Bolt 7bar(e)
1450 0147 1404 03 6 Bolt 7.5bar(e)
1460 0301 2358 00 6 Washer 8.6bar(e)
1490 1202 8854 00 1 Sight glass 3010 1614 7620 06 1 Nozzle
1500 1619 7420 00 1 Decal 10bar(e)
1510 1202 2227 00 1 Label 10.4bar(e)
1530 1617 7413 00 1 Dataplate 3010 1614 7620 05 1 Nozzle
1540 0129 3103 00 4 Blind rivet Connection set
1550 1617 5664 00 1 Data plate 4010 1617 7326 00 1 Pipe
1560 0129 3103 00 4 Blind rivet 4020 1089 0574 70 1 Temperature sensor
1570 0686 3716 15 1 Plug 4030 0650 0101 09 1 Gasket
1580 0661 1033 00 1 Sealing washer Winterisation set
1710 1614 7607 00 1 Ring Without "Bypass"
1810 0371 1100 25 1 Lifting eye 5020 0661 1033 00 3 Sealing washer
1830 0017 9892 10 4 Bolt 5030 1623 0032 00 3 Heater
1840 0300 0274 17 4 Washer 5040 1624 4107 00 1 Sleeve
1850 0147 1409 03 3 Bolt 5045 1503 0786 00 1 Rotation arrow
Without "Bypass" 1 Winterisation set
2010 1621 1405 00 1 Housing 6010 1624 4145 00 1 Insulation
2012 0686 3716 07 1 Plug 6030 1624 4182 80 1 Thermostat
2015 0653 1189 00 1 Flat gasket 6040 1624 4110 80 1 Tracing
2150 0686 3716 30 1 Plug 6050 1617 1621 03 1 Insulation
2160 0653 1100 00 1 Flat gasket 6070 1089 0555 52 AR Tape
With "Bypass" With "Bypass"
2010 1614 7597 00 1 Housing 5020 0661 1033 00 4 Sealing washer
2020 1617 5110 00 3 Valve 5030 1623 0032 00 4 Heater
2030 1614 7595 00 3 Bonnet 5040 1624 4107 00 1 Sleeve
2040 1614 7596 00 3 Valve spindle 5045 1503 0786 00 1 Rotation arrow
2050 0335 3512 00 3 Snap ring 1 Winterisation set
2060 1614 7593 00 3 Packing nut 6010 1624 4145 00 1 Insulation
2070 0663 2104 03 3 O-ring 6020 1624 4144 00 1 Insulation
2080 0653 1165 00 3 Flat gasket 6030 1624 4182 80 1 Thermostat
2090 0663 2112 26 3 O-ring 6040 1624 4110 80 1 Tracing
2095 1617 5976 00 3 Ring 6050 1617 1621 03 1 Insulation
2100 1617 7374 00 3 Wheel 6070 1089 0555 52 AR Tape

2930 1519 00 37
Parts list

17 Full Feature - IMD - Cooler

70908

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1005 1621 2306 00 1 Cooler 1030 0634 1000 82 2 Gasket


1010 1621 2307 00 2 Plate 1035 0634 1000 19 2 Victaulic coupling
1015 1079 1472 05 6 Bolt 1037 1621 2296 00 1 Pipe
1020 1621 5697 00 2 Support 1050 0634 1000 19 2 Victaulic coupling
1025 0147 1363 03 8 Bolt 1052 1621 2297 00 1 Pipe
1026 0301 2344 00 16 Washer 1060 0147 1360 03 4 Bolt
1028 0291 1128 20 8 Nut 1065 0301 2344 00 4 Washer

38 2930 1519 00
Parts list

Full Feature - IMD - Piping


18

70909

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

7.5bar(e) 1015 0147 1402 03 4 Bolt


8.6bar(e) 1020 0634 1000 22 1 Victaulic coupling
10bar(e) 1025 1621 4156 00 1 Pipe
10.4bar(e) 1030 0650 0101 11 1 Gasket
1005 1621 4186 00 1 Pipe 1035 0147 1477 03 4 Bolt
1010 0663 2107 33 1 O-ring

2930 1519 00 39
Parts list

19

70910

40 2930 1519 00
Parts list

Full Feature - IMD - Piping - High ambient condition, Outdoor version


19

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

10bar(e) 1065 0650 1001 34 2 Gasket


10.4bar(e) 1070 0147 1481 03 4 Bolt
1005 1621 4151 00 1 Pipe 1075 0266 2114 00 4 Nut
1010 0663 2107 33 1 O-ring 1621 5664 80 1 Valve
1015 0147 1402 03 4 Bolt 2010 1621 5607 00 1 Housing
1020 0634 1000 22 1 Victaulic coupling 2020 1621 5608 00 1 Spindle
1025 1621 4156 00 1 Pipe 2030 1621 5664 00 1 Nut
1030 0650 0101 11 1 Gasket 2040 0653 1174 00 1 Flat gasket
1035 0147 1477 03 4 Bolt 2050 0653 1124 00 1 Flat gasket
1045 0650 1001 34 1 Gasket 2060 1617 7461 00 1 Nut
1050 0147 1485 03 4 Bolt 2070 0261 1099 11 1 Nut
1052 1621 2962 00 4 Bushing 2080 0335 1104 29 1 Circlip
1055 1619 3122 00 1 Valve 2090 0686 3115 60 1 Plug
1060 1621 4187 00 1 Pipe

2930 1519 00 41
Parts list

20

70911

42 2930 1519 00
Parts list

Full Feature - IMD - Piping - Tropical dryer


20

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

7.5bar(e) 1028 AR Insulation


8.6bar(e) 0070 9085 41 L = 1000
10bar(e) 0070 9085 40 L = 500
10.4bar(e) 1030 0650 0101 11 1 Gasket
1005 1621 4186 00 1 Pipe 1031 0017 9860 58 AR Tape
1010 0663 2107 33 1 O-ring 1035 0147 1477 03 4 Bolt
1015 0147 1402 03 4 Bolt 1040 1621 5698 00 1 Plate
1020 0634 1000 22 1 Victaulic coupling 1042 0147 1323 03 2 Bolt
1025 1621 5702 00 1 Pipe 1045 0346 2900 23 2 U-bolt
1027 1621 4192 00 1 Pipe 1048 0301 2335 00 4 Washer

2930 1519 00 43
Parts list

21

70912

44 2930 1519 00
Parts list

Full Feature - IMD - Piping - Tropical dryer - High ambient condition


21

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

10bar(e) 1070 0147 1481 03 4 Bolt


10.4bar(e) 1075 0266 2114 00 4 Nut
1005 1621 4151 00 1 Pipe 1080 1621 5698 00 1 Plate
1010 0663 2107 33 1 O-ring 1085 0147 1323 03 2 Bolt
1015 0147 1402 03 4 Bolt 1090 0346 2900 23 2 U-bolt
1020 0634 1000 22 1 Victaulic coupling 1095 0301 2335 00 4 Washer
1025 1621 5702 00 1 Pipe 1621 5664 80 1 Valve
1027 1621 4192 00 1 Pipe 2010 1621 5607 00 1 Housing
1030 0650 0101 11 1 Gasket 2020 1621 5608 00 1 Spindle
1035 0147 1477 03 4 Bolt 2030 1621 5664 00 1 Nut
1045 0650 1001 34 1 Gasket 2040 0653 1174 00 1 Flat gasket
1050 0147 1485 03 4 Bolt 2050 0653 1124 00 1 Flat gasket
1052 1621 2962 00 4 Bushing 2060 1617 7461 00 1 Nut
1055 1619 3122 00 1 Valve 2070 0261 1099 11 1 Nut
1060 1621 4187 00 1 Pipe 2080 0335 1104 29 1 Circlip
1065 0650 1001 34 2 Gasket 2090 0686 3115 60 1 Plug

2930 1519 00 45
Parts list

22 Full Feature - IMD - Cooler piping

70887

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1010 1614 7630 00 1 Ring 1070 0147 1402 03 4 Bolt


1020 1614 7635 00 1 Ring 1080 0663 2112 74 1 O-ring
1030 0663 3150 00 1 O-ring 1090 0147 1402 03 4 Bolt
1040 0147 1476 02 1 Hex. head screw 1100 1617 7695 00 2 Pipe
1050 0261 1090 27 1 Hexagon nut 1120 0686 3716 02 2 Plug
1060 0663 2112 74 1 O-ring 1130 0661 1033 00 2 Sealing washer

46 2930 1519 00
Parts list

Full Feature - IMD - Gear casing and gear drive


23

70889

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

IEC CSA-UL
1020 1088 0031 63 1 Connector 1020 1088 0031 63 1 Connector
1030 0663 9228 00 1 O-ring 1030 0663 9228 00 1 O-ring
1040 1617 5321 00 1 Seal 1040 1617 5321 00 1 Seal
1050 0147 1363 03 6 Bolt 1050 0147 1363 03 6 Bolt
1060 0301 2344 00 6 Washer 1060 0301 2344 00 6 Washer
1070 1088 1001 01 1 Warning mark 1070 1088 1001 01 1 Warning mark
2 020 1080 3056 01 1 Motor 2 020 1080 3056 03 1 Motor
1617 7340 00 1 Fan cap motor 1617 7340 00 1 Fan cap motor
1617 7739 80 1 Gearbox 1617 7739 80 1 Gearbox
3010 1088 1001 02 1 Warning mark 3010 1088 1001 02 1 Warning mark
3020 1503 0786 00 1 Rotation arrow 3020 1503 0786 00 1 Rotation arrow
3040 1617 5863 00 1 Box 3040 1617 5863 00 1 Box
3050 1617 7737 00 1 Shaft 3050 1617 7737 00 1 Shaft
3060 1617 7742 00 1 Flange 3060 1617 7742 00 1 Flange
3070 1617 7744 00 1 Sensor 3070 1617 7744 00 1 Sensor
1624 4008 80 1 Gearbox 1624 4008 80 1 Gearbox
4010 1617 7743 00 1 Gearbox 4010 1617 7743 00 1 Gearbox
4020 1617 7971 80 1 Seal 4020 1617 7971 80 1 Seal
4030 1617 7963 80 1 Sensor assy 4030 1617 7963 80 1 Sensor assy

2930 1519 00 47
Parts list

24

70890

48 2930 1519 00
Parts list

Full Feature - IMD - Electronic Drain System


24

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

EWD connection CSA-UL


1 010 1617 7656 80 1 Pipe + coupling 2 010 1617 7080 80 3 Drain
1617 7656 00 1 Pipe 1617 7083 00 1 Label
0580 0411 02 2 Pipe coupling 1617 7084 00 1 Label
1020 0661 1033 00 2 Sealing washer 1079 9910 24 1 Label
1030 0581 1200 29 2 Pipe coupling 1079 9910 90 1 Label
1040 0070 6002 06 AR Plastic tube 2020 1088 0031 65 3 Connector
1080 0661 1033 00 2 Sealing washer 2030 1088 0031 06 1 Connection
1090 0686 3716 02 2 Plug Purge set - Low load
1200 1624 4125 00 1 Support 7bar(e)
1210 0147 1360 03 2 Bolt 7.5bar(e)
1220 0301 2344 00 2 Washer 8.6bar(e)
1230 0581 0000 71 2 Pipe coupling 3010 1089 0641 05 1 Exh valve
1240 0661 1033 00 3 Sealing washer 3020 0603 4100 49 2 Hexagon nipple
1250 0070 6002 13 AR Plastic tube 3030 0607 1100 86 1 Socket
1260 0581 1200 29 1 Pipe coupling 3040 1617 7573 00 1 Nozzle
1270 0581 0000 53 1 Pipe coupling 10bar(e)
1280 0661 1033 00 1 Sealing washer 10.4bar(e)
1290 0070 6002 06 AR Plastic tube 3010 1089 0641 05 1 Exh valve
1 400 1617 7656 80 1 Pipe + coupling 3020 0603 4100 49 2 Hexagon nipple
1617 7656 00 1 Pipe 3030 0607 1100 86 1 Socket
0580 0411 02 2 Pipe coupling 3040 1617 7572 00 1 Nozzle
1410 0661 1033 00 2 Sealing washer Drain connection
1420 1617 5473 80 1 Pipe coupling Full Feature
1430 0581 0000 53 1 Pipe coupling 4005 0075 4005 51 AR Hose
1440 0661 1033 00 2 Sealing washer 4020 9000 0243 00 3 Hose nipple
1450 0070 6002 06 AR Plastic tube 4025 0347 6105 00 6 Hose clip
EWD Outdoor version
IEC 4005 0075 4005 56 AR Hose
2 010 1617 7080 81 3 Drain 4020 0571 0020 23 3 Hose nipple
1617 7083 00 1 Label 4025 0347 6103 00 6 Hose clip
1617 7084 01 1 Label 4030 0571 0020 38 3 Hose nipple
1079 9910 24 1 Label 4060 0661 1000 27 3 Seal washer
1079 9910 90 1 Label
2020 1088 0031 65 3 Connector
2030 1088 0031 06 1 Connection

2930 1519 00 49
Parts list

25

70891

50 2930 1519 00
Parts list

Full Feature - IMD - Electronic Drain System - High ambient condition


25

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

EWD Connection 0147 1363 03 4 Bolt


1010 0580 0411 00 2 Straight coupling 0663 2106 17 1 O-ring
1020 1617 7712 00 1 Coupling 0335 2102 15 1 Circlip
1030 0581 0000 68 1 Straight coupling 1617 7680 00 1 Strainer
1040 0661 1033 00 4 Sealing washer 2 020 1617 7648 81 2 Assembly
1050 1617 7656 00 1 Pipe 1617 7648 01 1 Drain
1060 0070 6002 10 AR Plastic tube 1617 7651 01 1 Cover
1070 0586 3000 15 2 Union 0147 1363 03 4 Bolt
EWD 0333 3132 00 4 Lock washer
IEC 0301 2344 00 4 Washer
2 010 1617 7648 80 1 Assembly 0663 2106 17 1 O-ring
1617 7648 02 1 Drain 0335 2102 15 1 Circlip
1617 7651 00 1 Cover 1617 7680 00 1 Strainer
0333 3132 00 4 Lock washer 2030 0661 1033 00 6 Sealing washer
0301 2344 00 4 Washer 2040 1621 1249 00 6 Bushing
0147 1363 03 4 Bolt 2050 0661 1000 25 3 Seal washer
0663 2106 17 1 O-ring 2060 1089 0659 54 3 Switch
0335 2102 15 25 1 Circlip 2070 1089 9439 22 3 Valve
1617 7680 00 1 Strainer 2080 0603 4100 79 3 Hex.nipple
2 020 1617 7648 81 2 Assembly 2090 1617 7717 00 1 Wiring
1617 7648 01 1 Drain Purge set - Low load
1617 7651 01 1 Cover 7bar(e)
0147 1363 03 4 Bolt 7.5bar(e)
0333 3132 00 4 Lock washer 8.6bar(e)
0301 2344 00 4 Washer 3010 1089 0641 05 1 Exh valve
0663 2106 17 1 O-ring 3020 0603 4100 49 2 Hexagon nipple
0335 2102 15 1 Circlip 3030 0607 1100 86 1 Socket
1617 7680 00 1 Strainer 3040 1617 7573 00 1 Nozzle
2030 0661 1033 00 6 Sealing washer 10bar(e)
2040 1621 1249 00 6 Bushing 10.4bar(e)
2050 0661 1000 25 3 Seal washer 3010 1089 0641 05 1 Exh valve
2060 1089 0659 54 3 Switch 3020 0603 4100 49 2 Hexagon nipple
2070 1089 9439 21 3 Valve 3030 0607 1100 86 1 Socket
2080 0603 4100 79 3 Hex.nipple 3040 1617 7572 00 1 Nozzle
2090 1617 7717 00 1 Wiring Drain connection
CSA-UL Full Feature
2 010 1617 7648 80 1 Assembly 4010 0571 0020 23 3 Hose nipple
1617 7648 02 1 Drain 4015 0075 4005 56 AR Hose
1617 7651 00 1 Cover 4030 0347 6103 00 6 Hose clip
0333 3132 00 4 Lock washer 4040 0571 0020 38 3 Hose nipple
0301 2344 00 4 Washer 4060 0661 1000 27 3 Seal washer

2930 1519 00 51
Parts list

26

70892

52 2930 1519 00
Parts list

Full Feature - IMD - Electronic Drain System - Winterisation


26

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1010 1617 7116 00 1 Coupling 1420 0661 1033 00 1 Sealing washer


1 020 1617 7648 81 1 Assembly 1430 1617 7998 80 1 Pipe
1617 7648 01 1 Drain 1440 0581 1200 23 1 Elbow
1617 7651 01 1 Cover 1450 0070 6002 05 AR Plastic tube
0147 1363 03 4 Bolt 1460 0581 0000 73 1 Str. coupl.
0333 3132 00 4 Lock washer 1470 0661 1033 00 1 Sealing washer
0301 2344 00 4 Washer 1 480 1617 7648 80 1 Assembly
0663 2106 17 1 O-ring 1617 7648 02 1 Drain
0335 2102 15 1 Circlip 1617 7651 00 1 Cover
1617 7680 00 1 Strainer 0333 3132 00 4 Lock washer
1030 0661 1033 00 1 Sealing washer 0301 2344 00 4 Washer
1040 1621 7941 00 1 Bushing 0147 1363 03 4 Bolt
1050 0661 1000 25 1 Seal washer 0663 2106 17 1 O-ring
1060 1089 0659 54 1 Switch 0335 2102 15 1 Circlip
1070 0603 4104 01 1 Hex. Nipple 1617 7680 00 1 Strainer
1080 0564 3304 01 1 Tee 1490 0661 1033 00 1 Sealing washer
1090 0560 0200 87 1 Elbow 1500 1621 7941 00 1 Bushing
1100 0661 1033 00 2 Sealing washer 1510 0661 1000 25 1 Seal washer
1110 0686 3716 02 2 Plug 1520 1089 0659 54 1 Switch
1200 1617 7116 00 1 Coupling 1530 0603 4104 01 1 Hex. Nipple
1 210 1617 7648 81 1 Assembly 1540 0564 3304 01 1 Tee
1617 7648 01 1 Drain 1550 0661 1033 00 1 Sealing washer
1617 7651 01 1 Cover 1560 1617 7582 80 1 Pipe + coupling
0147 1363 03 4 Bolt 1570 0661 1033 00 1 Sealing washer
0333 3132 00 4 Lock washer 1580 0607 2154 02 1 Socket
0301 2344 00 4 Washer 1600 1624 4180 00 1 Wiring
0663 2106 17 1 O-ring Drain connection
0335 2102 15 1 Circlip Winterisation Outdoor
1617 7680 00 1 Strainer version
1220 0661 1033 00 1 Sealing washer 2174 0661 1000 25 1 Seal washer
1230 1621 7941 00 1 Bushing 2175 0603 4100 74 3 Hexagon nipple
1240 0661 1000 25 1 Seal washer 2180 0581 0001 04 3 Pipe coupling
1250 1089 0659 54 1 Switch 2185 0581 0000 71 3 Pipe coupling
1260 0603 4104 01 1 Hex. Nipple 2190 0661 1000 27 3 Seal washer
1270 0607 2154 02 1 Socket 2230 0560 4401 60 3 Tee
1280 0560 0200 87 1 Elbow 2235 0560 4401 51 3 Elbow
1290 0603 4104 01 1 Hex. Nipple 2240 0661 1000 27 3 Seal washer
1300 0564 3304 01 1 Tee 2245 0582 0116 00 3 Pipe coupling
1310 0603 4104 01 1 Hex. Nipple 2250 1623 0266 00 3 Pipe
1320 0607 2154 02 1 Socket 2255 0582 0116 00 3 Pipe coupling
1330 0560 0200 87 1 Elbow 2260 0661 1000 27 3 Seal washer
1400 0661 1033 00 1 Sealing washer 2265 0603 4100 74 6 Hexagon nipple
1410 1624 4103 80 1 Pipe + coupling 2270 0852 0010 26 3 Ball valve

2930 1519 00 53
Parts list

27

70895

54 2930 1519 00
Parts list

Full Feature - IMD - Pressure Difference Indicator


27

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1007 0211 1247 03 2 Cap screw 3020 1617 5289 00 1 Slide


1008 0300 0274 32 2 Plain washer 3030 0581 0000 87 2 Pipe coupling
1015 0580 0013 32 2 Coupling 3035 0653 1124 00 4 Flat gasket
1016 0661 1000 25 2 Seal washer 3040 9090 1508 00 2 Coupling
1020 1621 6843 00 1 Pipe 3050 0070 6002 43 AR Tube
1030 1621 6844 00 1 Pipe 3060 1617 5981 00 1 Label
1035 0580 0013 32 2 Coupling 3070 0989 4220 06 6 Grommet
1036 0661 1000 25 2 Seal washer 3080 9090 1519 00 2 Coupl. elbow
2100 0852 0010 29 2 Ball valve 3090 0852 0010 36 1 Ball valve
1617 5288 80 1 Indicator 3100 0070 6002 43 AR Tube
3010 1617 5288 00 1 Support

2930 1519 00 55
Parts list

28

70897

56 2930 1519 00
Parts list

Full Feature - IMD - Low load - Heaters


28

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Air cooled 460V CSA-UL


380V IEC 575V CSA-UL
400V IEC 1010 0650 1000 99 1 Gasket
1010 0650 1000 99 1 Gasket 1020 1624 4084 00 1 Heater pipe
1020 1624 4084 00 1 Heater pipe 1 030 1617 7787 81 1 Heater assembly
1 030 1617 7750 82 1 Heater assembly 1617 7787 80 1 Heater
1617 7750 80 1 Heater 1040 0266 2114 00 8 Nut
1040 0266 2114 00 8 Nut 1050 0301 2378 00 16 Washer
1050 0301 2378 00 16 Washer 1060 0147 1482 03 8 Bolt
1060 0147 1482 03 8 Bolt 1070 1617 7584 00 1 Plate
1070 1617 7584 00 1 Plate 1080 1079 9902 55 1 Label
1080 1079 9902 55 1 Label 1090 1088 1001 01 1 Warning mark
1090 1088 1001 01 1 Warning mark 1100 1089 0574 70 2 Temperature sensor
1100 1089 0574 70 2 Temperature sensor 1110 0348 0101 07 10 Cable tie
1110 0348 0101 07 10 Cable tie 1120 1088 1305 02 10 Push mount
1120 1088 1305 02 10 Push mount Insulation set
440V IEC 2 010 1 Insulation set
500V IEC 1617 7895 00 1 Insulation
1010 0650 1000 99 1 Gasket 1617 7900 00 1 Insulation
1020 1624 4084 00 1 Heater pipe 1617 7905 00 1 Insulation
1 030 1617 7750 81 1 Heater assembly 1617 7906 00 1 Insulation
1617 7750 80 1 Heater 1617 7907 00 2 Insulation
1040 0266 2114 00 8 Nut 1617 7908 00 1 Insulation
1050 0301 2378 00 16 Washer Wiring set
1060 0147 1482 03 8 Bolt IEC
1070 1617 7584 00 1 Plate 3010 1617 7953 80 1 Wiring
1080 1079 9902 55 1 Label CSA-UL
1090 1088 1001 01 1 Warning mark 3010 1617 7952 80 1 Wiring
1100 1089 0574 70 2 Temperature sensor
1110 0348 0101 07 10 Cable tie
1120 1088 1305 02 10 Push mount

2930 1519 00 57
Parts list

29

70898

58 2930 1519 00
Parts list

Full Feature - IMD - Low load - Piping


29

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1020 0650 0101 09 1 Gasket 1180 0301 2344 00 8 Washer


1030 0634 1000 85 1 Victaulic coupling 1190 0852 0010 57 1 Ball valve
1040 0634 1001 30 1 Seal 1200 1617 7472 00 1 Check valve
1050 0634 1000 85 1 Victaulic coupling 1210 0663 2107 25 2 O-ring
1060 1079 3463 03 2 U-bolt 1220 0147 1492 03 8 Bolt
1070 0301 2335 00 4 Washer 1230 0301 2378 00 8 Washer
1080 0266 2110 00 8 Hexagon nut 1240 0147 1477 03 4 Bolt
1090 1617 7483 00 1 Support 1250 0301 2378 00 4 Washer
1100 0147 1400 03 2 Bolt 1260 0650 0101 10 1 Gasket
1110 0301 2371 00 2 Washer 2010 1617 7491 00 1 Pipe
1120 0634 1000 85 1 Victaulic coupling 2020 1617 7492 00 1 Pipe
1130 0650 0101 06 1 Gasket 2030 1617 7475 00 1 Pipe
1140 0823 0050 14 1 Check valve 2040 1617 7474 00 1 Pipe
1150 0650 0100 99 1 Gasket 2050 1617 7473 00 1 Pipe
1160 0147 1371 03 4 Bolt 2060 1617 7493 00 1 Pipe
1170 0261 2111 00 4 Hexagon

2930 1519 00 59
Parts list

30

70900

60 2930 1519 00
Parts list

Full Feature - IMD - Regeneration air


30

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

7.5bar(e) 10bar(e) Outdoor version


8.6bar(e) 10.4bar(e) Outdoor version
10bar(e) 1015 0634 1000 27 1 Victaulic coupling
10.4bar(e) 1020 1621 2254 05 1 Seal
1015 0634 1000 27 1 Victaulic coupling 1025 1202 8522 09 1 Check valve
1020 1621 2254 05 1 Seal 1030 1621 2298 00 1 Pipe
1025 1202 8522 09 1 Check valve 1035 0650 1001 34 2 Gasket
1030 1621 2298 00 1 Pipe 1040 0147 1491 03 4 Bolt
1035 0650 1001 34 2 Gasket 1045 0266 2114 00 4 Nut
1040 0147 1491 03 4 Bolt 1050 1619 3122 00 1 Valve
1045 0266 2114 00 4 Nut 1055 0070 9085 28 1 Insulation
1050 1619 3122 00 1 Valve 1060 0650 1001 34 1 Gasket
1055 0070 9085 28 1 Insulation 1065 0147 1481 03 4 Bolt
1060 0650 1001 34 1 Gasket 1070 0266 2114 00 4 Nut
1065 0147 1481 03 4 Bolt 1075 1621 4182 00 1 Pipe
1070 0266 2114 00 4 Nut 1080 0650 1001 34 1 Gasket
1075 1621 2299 00 1 Pipe 1085 0147 1481 03 4 Bolt
1080 0650 1001 34 1 Gasket 1090 0266 2114 00 4 Nut
1085 0147 1481 03 4 Bolt 1095 0634 1000 27 1 Victaulic coupling
1090 0266 2114 00 4 Nut 1100 1621 2254 05 1 Seal
1095 0634 1000 27 1 Victaulic coupling 1105 0070 9085 04 1 Insulation
1100 1621 2254 05 1 Seal 1110 0017 9860 58 AR Tape
1105 0070 9085 04 1 Insulation 1115 0634 1000 27 1 Victaulic coupling
1621 2300 81 1 Valve assembly 1120 1621 2254 05 1 Seal
2005 1621 2300 00 1 Valve housing 1621 2300 81 1 Valve assembly
2010 1621 5443 00 1 Bushing 2005 1621 2300 00 1 Valve housing
2015 0653 1174 00 1 Flat gasket 2010 1621 5443 00 1 Bushing
2020 1617 7461 00 1 Nut 2015 0653 1174 00 1 Flat gasket
2025 0653 1124 00 1 Flat gasket 2020 1617 7461 00 1 Nut
2030 1617 7462 00 1 Spindle 2025 0653 1124 00 1 Flat gasket
2035 1617 7463 00 1 Disk 2030 1617 7462 00 1 Spindle
2040 0147 1963 77 2 Hexagon screw 2035 1617 7463 00 1 Disk
2045 0261 1099 11 1 Nut 2040 0147 1963 77 2 Hexagon screw
10bar(e) High ambient 2045 0261 1099 11 1 Nut
condition
10.4bar(e) High ambient
condition

2930 1519 00 61
Parts list

31

63340_10

62 2930 1519 00
Parts list

Full Feature - FDT - Bodywork


31

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Canopy and plates 1617 3607 80 1 Front panel assembly


1020 1088 0801 21 2 Grommet 3010 1 Front panel
1030 0698 0150 00 2 Grommet 3020 1613 8404 00 3 Hinge
1050 1617 3788 00 1 Data plate 3030 0160 6082 00 6 Screw
1060 0346 1000 42 1 Pipe clamp 3040 0333 3100 00 6 Lock washer
1070 1619 5225 00 6 Plug 1617 7581 80 1 Roof assembly
1110 1619 2766 00 6 Bolt 4010 1617 7581 00 1 Roof
1120 1079 0298 01 4 Cage nut 4020 1613 9963 00 4 Corner
1140 1619 2766 00 12 Bolt 1617 3307 80 1 Door assembly
1160 1619 2766 00 6 Bolt 5020 1613 8486 00 2 Lock
1170 1619 2766 00 3 Bolt 5010 1 Door
1180 1619 2766 00 6 Bolt 5030 0690 1125 01 1 House mark
1190 1619 2766 00 10 Bolt 5040 1079 9921 43 1 Label
1200 1619 2766 00 4 Bolt 5050 1088 1001 04 1 Warning mark
1210 1617 3718 00 1 Support 1617 3306 80 1 Cubicle assembly
1220 0226 3256 00 3 Tapping screw 6010 1 Cubicle
1 240 1603 1900 84 1 Foam canopy set 6020 1619 3843 00 1 Seal
1617 3741 00 2 Silencing foam 6030 1202 6584 00 1 Seal
1617 3740 00 2 Silencing foam 1617 7576 80 1 Rear panel assembly
1250 0226 3343 17 8 Tapping screw 7010 1 Rear panel
1260 0211 1322 03 6 Hex sock. screw 7020 1617 2848 00 1 Label
1270 1079 2901 01 4 Cage nut 7030 1088 1001 02 1 Warning mark
1280 0147 1320 03 1 Bolt 7040 1079 9915 89 1 Label
1290 1089 9068 01 1 Key 1617 3610 80 1 Frame assembly
1300 1617 3878 00 1 Support 8010 1617 3310 00 1 Frame
1400 1617 7580 00 2 Grating 8020 1079 9901 09 1 Label
1410 1619 2766 00 16 Bolt 8030 1079 9922 39 2 Label
1450 1079 9921 02 1 Label Anchor pads
1460 1617 7697 00 1 Label 9010 1617 2259 00 4 Anchor plate
2020 1617 3313 00 3 Panel 9020 0147 1363 03 8 Bolt
2030 1617 7642 00 1 Beam 9030 0226 9929 06 8 Wedge bolt
2040 1617 3315 00 2 Stay
2050 1617 3320 00 4 Baffle
2100 1617 7707 00 1 Box

2930 1519 00 63
Parts list

32

63347_03

64 2930 1519 00
Parts list

Full Feature - FDT - Connection set - without additional cooler


32

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1 030 1 Insulation set 1120 0634 1000 29 5 Victaulic coupling


0070 9085 16 AR Insulation 1130 0634 1000 22 2 Victaulic coupling
0070 9085 28 AR Insulation 2010 1617 7620 00 1 Pipe
1040 0017 9860 58 AR Tape 2020 1617 7621 00 1 Pipe
1050 0346 2900 15 2 U-bolt 2030 1617 7622 00 1 Pipe
1060 0301 2358 00 4 Washer 2040 1617 7623 00 1 Pipe
1070 0266 2112 00 8 Nut 2050 1617 7624 00 1 Pipe
1080 1079 3463 03 2 U-bolt 3010 1617 7625 00 1 Support
1090 0301 2335 00 8 Washer 3020 1617 7626 00 1 Support
1100 0266 2110 00 10 Hexagon nut 3030 1617 7628 00 1 Support
1110 0147 1330 03 2 Bolt

2930 1519 00 65
Parts list

33

70901

66 2930 1519 00
Parts list

Full Feature - FDT - Connection set - with additional cooler


33

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1 030 1 Insulation set 1140 0650 0101 08 2 Gasket


0070 9085 16 AR Insulation 1150 0147 1402 03 8 Bolt
0070 9085 28 AR Insulation 1160 0301 2358 00 8 Washer
1040 0017 9860 58 AR Tape 2010 1617 7620 00 1 Pipe
1050 0346 2900 15 2 U-bolt 2020 1617 7636 00 1 Pipe
1060 0301 2358 00 4 Washer 2030 1617 7622 00 1 Pipe
1070 0266 2112 00 8 Nut 2040 1617 7623 00 1 Pipe
1080 1079 3463 03 2 U-bolt 2050 1617 7624 00 1 Pipe
1090 0301 2335 00 8 Washer 2060 1617 7637 00 1 Pipe
1100 0266 2110 00 10 Hexagon nut 3010 1617 7625 00 1 Support
1110 0147 1330 03 2 Bolt 3020 1617 7626 00 1 Support
1120 0634 1000 29 5 Victaulic coupling 3030 1617 7628 00 1 Support
1130 0634 1000 22 2 Victaulic coupling

2930 1519 00 67
Parts list

34

63349_04

68 2930 1519 00
Parts list

Full Feature - FDT - Heat exchangers and drains


34

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Heat exchanger 2020 0584 0080 10 1 Clamping ring


1010 1617 7649 00 1 Heat exchanger 2030 0070 6002 05 AR Plastic tube
1 030 1 Insulation set 1)2) 2060 0586 3000 15 1 Union
1050 0196 1552 96 4 Set screw Electronic water drain
1060 0301 2335 00 4 Washer 3200 1613 8913 11 2 Ewd
1070 0266 2110 00 4 Hexagon nut
1080 0333 3227 00 4 Lock washer 1-2) 0013 2959 90 Polystyreen EPS
1617 2855 80 2 Drain assembly 1) thickness 10mm
2010 0581 0000 94 1 Pipe coupling 2) thickness 20mm

2930 1519 00 69
Parts list

35

63354_12

70 2930 1519 00
Parts list

Full Feature - FDT - Cubicle


35

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Electrical components 2090 1089 9551 22 1 Circuit breaker


400V 50Hz IEC 2100 1089 9551 99 1 Aux.Contact
440V 60Hz CSA-UL 2110 1900 0710 41 1 Analog input expansion
460V 60Hz CSA-UL 2120 1089 9514 22 1 Transformer
1300 1900 0710 12 1 Regulator - Normal display 2130 1619 7689 01 1 Carter heater
1310 0301 2315 00 4 Washer 2140 1617 7714 00 1 Valve coil
1320 0333 3214 00 4 Lock washer 2150 1089 0574 73 4 Temperature sensor
1330 0160 6039 00 4 Screw 2160 1089 0577 13 3 Terminals
1420 1619 2766 00 12 Bolt 2170 1089 0577 39 1 Earth-terminal
1520 9827 1748 00 1 Service diagram 2180 1089 0577 35 1 Earth-terminal
1 Control panel 2190 1089 0577 31 6 Earth-terminal
1900 5105 51 400V 50Hz IEC 2200 1089 0577 12 35 Terminals
1900 5105 51 460V 60Hz CSA-UL 2210 1088 0031 12 1 Connector
1900 5105 51 440V 60Hz CSA-UL 2220 1088 0031 13 1 Connector
With additional cooler 2230 1088 0031 29 1 Connector
2010 1089 9489 79 1 Contactor 2240 1088 0031 49 1 Connector
2020 1089 9523 51 1 Drive VSD 2250 9827 1746 00 1 Mounting-plate
2030 1089 9551 04 1 Circuit breaker 3010 1900 0712 81 1 Regulator - High Resolution
2040 1089 9551 97 1 Aux.Contact display
2050 1089 9551 04 1 Circuit breaker 1900 5105 53 1 Option CSA/ULApproval
2060 1089 9604 26 1 Circuit breaker 4010 1617 9401 00 1 Data-plate
2070 1089 9489 30 3 Contactor fan 4020 1079 9911 01 1 Label
2080 1089 9551 29 1 Circuit breaker

2930 1519 00 71
Parts list

36

70902

72 2930 1519 00
Parts list

Full Feature - FDT - Electrical and mechanical components


36

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1020 1617 3572 00 1 Separator 3420 1617 7713 00 2 Support


1030 1617 2232 02 1 Thermostatic valve (Orifice) 3430 1619 2766 00 4 Bolt
1040 1617 2231 01 1 Thermostatic valve (Bulb) Electrical components
1060 1617 0165 00 1 Ring IEC
1070 1617 2008 00 1 Ring 4010 1617 2908 02 1 Refrigerant compressor
1080 1617 7554 00 1 Condensor 4100 1617 2856 80 2 Fan assembly
1085 1619 2766 00 4 Bolt 4110 0147 1325 03 8 Bolt
1200 1617 7708 80 1 Insulation assembly 4120 0301 2335 00 8 Washer
2 010 1 Pipe assembly 4130 0333 3227 00 8 Lock washer
1619 5566 04 1 Freon dryer 4500 1089 9139 62 1 Pressure switch
1619 5563 07 3 Valve schrader 4510 0226 3256 00 3 Tapping
2 020 1 Pipe assembly 4520 0301 2315 00 3 Washer
1617 2215 03 1 Body solenoid valve 4530 0266 2106 00 3 Nut
1617 0488 00 1 Sleeve 4540 0147 1173 03 3 Bolt
1617 0476 00 1 Nut 4550 1619 2766 00 8 Bolt
1617 1524 06 1 Hrbiger valve 4560 0333 3214 00 3 Lock washer
2030 1617 3337 00 1 Pipe CSA-UL
2 040 1 Pipe assembly 4010 1617 2908 02 1 Refrigerant compressor
1617 0386 00 1 Sleeve 4100 1617 2856 80 2 Fan assembly
1617 0314 00 1 Nut 4110 0147 1325 03 8 Bolt
1617 2384 00 1 Non return valve 4120 0301 2335 00 8 Washer
2 050 1 Pipe assembly 4130 0333 3227 00 8 Lock washer
1617 0476 00 1 Nut 4500 1089 9139 62 1 Pressure switch
1617 0488 00 1 Sleeve 4510 0226 3256 00 3 Tapping screw
2 070 1 Pipe assembly 4520 0301 2315 00 3 Washer
1619 5567 04 1 Sight glass 4530 0266 2106 00 3 Nut
1617 3509 00 1 Themostatic valve 4540 0147 1173 03 3 Bolt
1617 0488 00 1 Sleeve 4550 1619 2766 00 8 Bolt
1617 0476 00 1 Nut 4560 0333 3214 00 3 Lock washer

2930 1519 00 73
Parts list

37

63356_04

74 2930 1519 00
Parts list

Full Feature - FDT - Additional Cooler Set


37

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1020 1617 7638 00 2 Support 2050 1617 7725 00 1 Fan


1030 1619 5337 01 4 Bolt 2060 1617 7824 00 AR Seal
1040 1619 2766 00 4 Bolt 2070 1617 7824 00 AR Seal
1050 1088 1301 04 4 Cable strip 2080 0147 1325 03 4 Bolt
1617 7715 80 1 Cooler and fan assembly 2090 0301 2335 00 4 Washer
2010 1617 5069 00 1 Cooler 2100 0147 1326 03 4 Bolt
2020 1617 7716 00 1 Support 2110 0301 2335 00 4 Washer
2030 1617 7724 00 1 Grating 2120 0147 1323 03 6 Bolt
2040 1080 4068 01 1 Motor 2130 0300 8019 00 6 Washer

2930 1519 00 75
Parts list

38

70903

76 2930 1519 00
Parts list

Drain system - Safety valves - With aftercooler


38

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Water separator 3095 0663 2107 33 1 O-ring


1005 1621 1408 00 1 Pipe connection 3100 0147 1407 03 4 Bolt
1010 0147 1402 03 4 Bolt 3105 0301 2358 00 8 Washer
1017 0686 3716 30 1 Plug 3110 0266 2112 00 4 Nut
1018 0661 1000 26 1 Seal washer 3115 0560 4401 51 1 Elbow
1020 0663 2107 33 2 O-ring 3120 0586 3000 15 1 Union
1023 0211 1403 03 4 Cap screw 3125 0560 4401 51 1 Elbow
1030 0301 2358 00 4 Washer 3140 0605 8300 48 1 Bushing
1060 0603 5125 03 1 Hexagon nipple 3145 0075 4005 51 AR Hose
1070 0586 1000 32 1 Union coupling 3150 9000 0243 00 2 Hose nipple
1080 0603 4106 03 1 Hexagon nipple 3155 0347 6105 00 2 Hose clip
1090 1621 2354 00 1 Flange 3170 0017 9860 68 4 Protection
1095 0663 2107 33 1 O-ring 3180 1079 9905 49 1 Label
1100 0147 1407 03 4 Bolt 1621 1384 80 1 Valve housing
1105 0301 2358 00 8 Washer 4010 1621 1384 00 1 Valve housing
1110 0266 2112 00 4 Nut 4020 1621 3238 00 1 Spacer
1125 0560 4401 51 1 Elbow 4025 1614 6482 00 1 Swirler
1130 0586 3000 15 1 Union 4030 1621 3487 00 1 Impinger
1135 0560 4401 51 1 Elbow 4035 0663 6140 00 1 O-ring
1140 0605 8300 48 1 Bushing 4040 0147 1383 03 1 Bolt
1145 8204 0940 34 1 Valve 4080 1621 3229 00 1 Valve base
1150 9000 0243 00 2 Hose nipple 4090 1621 3236 00 4 Rod
1155 0075 4005 51 AR Hose 4095 1621 8863 00 1 Plate
1170 0347 6105 00 2 Hose clip 4100 0147 1962 65 4 Bolt
1200 1079 9905 49 1 Label 4110 0686 6442 03 1 Plug
1621 1384 80 1 Valve housing 4115 0661 1000 25 1 Seal washer
2010 1621 1384 00 1 Valve housing 4130 0686 6444 03 1 Plug
2020 1621 3238 00 1 Spacer 4135 0661 1000 27 1 Seal washer
2025 1614 6482 00 1 Swirler 4150 0663 6155 00 1 O-ring
2030 1621 3487 00 1 Impinger 4155 0147 1403 03 4 Bolt
2035 0663 6140 00 1 O-ring 4160 0301 2358 00 4 Washer
2040 0147 1383 03 1 Bolt Drain
2080 1621 3229 00 1 Valve base IEC
2090 1621 3236 00 4 Rod 5010 1621 4450 00 1 Cable
2095 1621 8863 00 1 Plate 5020 1621 6822 00 1 Drain
2100 0147 1962 65 4 Bolt 5030 1621 6822 00 1 Drain
2110 0686 6442 03 1 Plug CSA-UL
2115 0661 1000 25 1 Seal washer 5010 1621 4450 00 1 Cable
2130 0686 6444 03 1 Plug 5020 1621 6823 00 1 Drain
2135 0661 1000 27 1 Seal washer 5030 1621 6823 00 1 Drain
2150 0663 6155 00 1 O-ring Safety valve
2155 0147 1403 03 4 Bolt 7.5bar(e)
2160 0301 2358 00 4 Washer 8.6bar(e)
With aftercooler 6005 0830 1008 23 1 Safety valve
3012 0686 3716 30 1 Plug 6010 0661 1000 32 1 Seal washer
3013 0661 1000 26 1 Seal washer 6035 0830 1008 07 1 Safety valve
3015 0663 2107 33 1 O-ring 6040 0661 1000 30 1 Seal washer
3023 0211 1403 03 4 Cap screw 10bar(e)
3025 0301 2358 00 4 Washer 10.4bar(e)
3040 0686 3716 10 1 Plug 6005 0830 1008 23 1 Safety valve
3045 0661 1000 32 1 Seal washer 6010 0661 1000 32 1 Seal washer
3050 0605 8700 70 1 Bushing 6035 0830 1008 12 1 Safety valve
3055 0661 1000 32 1 Seal washer 6040 0661 1000 30 1 Seal washer
3090 1621 2354 00 1 Flange

2930 1519 00 77
Parts list

39

70942

78 2930 1519 00
Parts list

Drain system - Safey valves - With aftercooler - High ambient


condition, Outdoor version, Winterisation 39
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Water separator 3117 0580 0500 02 1 Straight coupling


1005 1621 1408 00 1 Pipe connection 3120 0661 1000 25 1 Seal washer
1010 0147 1402 03 4 Bolt 3140 0571 0020 23 1 Hose nipple
1017 0686 3716 30 1 Plug 3145 0075 4005 56 AR Hose
1018 0661 1000 26 1 Seal washer 3150 0347 6103 00 2 Hose clip
1020 0663 2107 33 2 O-ring 3155 0571 0020 38 1 Hose nipple
1023 0211 1403 03 4 Cap screw 3170 0017 9860 68 4 Protection
1030 0301 2358 00 4 Washer 3180 1079 9905 49 1 Label
1060 0603 5125 03 1 Hexagon nipple 1621 1384 81 1 Housing
1070 0586 1000 32 1 Union coupling 4010 1621 1384 00 1 Valve housing
1080 0603 4106 03 1 Hexagon nipple 4020 1621 3238 00 1 Spacer
1090 1621 2354 00 1 Flange 4025 1614 6482 00 1 Swirler
1095 0663 2107 33 1 O-ring 4030 1621 3487 00 1 Impinger
1100 0147 1407 03 4 Bolt 4035 0663 6140 00 1 O-ring
1105 0301 2358 00 8 Washer 4040 0147 1383 03 1 Bolt
1110 0266 2112 00 4 Nut 4060 1621 5087 00 1 Rod
1125 0560 4401 51 1 Elbow 4065 0301 2121 01 1 Plain washer
1130 0586 3000 15 1 Union 4070 1621 5086 00 1 Plate
1135 0560 4401 51 1 Elbow 4075 0301 2121 01 1 Plain washer
1140 0605 8300 48 1 Bushing 4080 0147 1962 65 1 Bolt
1145 8204 0940 34 1 Valve 4085 0663 2108 94 1 O-ring
1150 9000 0243 00 2 Hose nipple 4090 0147 1407 03 4 Bolt
1155 0075 4005 51 AR Hose 4095 0301 2358 00 8 Washer
1170 0347 6105 00 2 Hose clip 4100 0266 2112 00 4 Nut
1200 1079 9905 49 1 Label 1621 4396 81 1 Cover
1621 1384 80 1 Valve housing 5010 1621 4396 01 1 Cover
2010 1621 1384 00 1 Valve housing 5020 1621 7941 00 2 Bushing
2020 1621 3238 00 1 Spacer 5025 0661 1000 27 2 Seal washer
2025 1614 6482 00 1 Swirler 5030 1621 4418 00 1 Plate
2030 1621 3487 00 1 Impinger 5040 0147 1962 65 4 Bolt
2035 0663 6140 00 1 O-ring Winterisation Outdoor
2040 0147 1383 03 1 Bolt version
2080 1621 3229 00 1 Valve base 3012 0686 3716 30 1 Plug
2090 1621 3236 00 4 Rod 3013 0661 1000 26 1 Seal washer
2095 1621 8863 00 1 Plate 3015 0663 2107 33 1 O-ring
2100 0147 1962 65 4 Bolt 3023 0211 1403 03 4 Cap screw
2110 0686 6442 03 1 Plug 3025 0301 2358 00 4 Washer
2115 0661 1000 25 1 Seal washer 3040 0686 3716 10 1 Plug
2130 0686 6444 03 1 Plug 3045 0661 1000 32 1 Seal washer
2135 0661 1000 27 1 Seal washer 3050 0605 8700 70 1 Bushing
2150 0663 6155 00 1 O-ring 3055 0661 1000 32 1 Seal washer
2155 0147 1403 03 4 Bolt 3090 1621 2354 00 1 Flange
2160 0301 2358 00 4 Washer 3095 0663 2107 33 1 O-ring
High ambient condition 3100 0147 1407 03 4 Bolt
Outdoor version 3105 0301 2358 00 8 Washer
3012 0686 3716 30 1 Plug 3110 0266 2112 00 4 Nut
3013 0661 1000 26 1 Seal washer 3127 0661 1000 25 1 Seal washer
3015 0663 2107 33 1 O-ring 3128 0603 4100 74 1 Hexagon nipple
3023 0211 1403 03 4 Cap screw 3130 0581 0001 04 1 Pipe coupling
3025 0301 2358 00 4 Washer 3132 0581 0000 71 1 Pipe coupling
3040 0686 3716 10 1 Plug 3135 0661 1000 27 1 Seal washer
3045 0661 1000 32 1 Seal washer 3230 0560 4401 60 1 Tee
3050 0605 8700 70 1 Bushing 3235 0560 4401 51 1 Elbow
3055 0661 1000 32 1 Seal washer 3240 0661 1000 27 1 Seal washer
3090 1621 2354 00 1 Flange 3245 0582 0116 00 1 Pipe coupling
3095 0663 2107 33 1 O-ring 3250 1623 0266 00 1 Pipe
3100 0147 1407 03 4 Bolt 3255 0582 0116 00 1 Pipe coupling
3105 0301 2358 00 8 Washer 3260 0661 1000 27 1 Seal washer
3110 0266 2112 00 4 Nut 3265 0603 4100 74 2 Hexagon nipple
3115 0661 1000 25 1 Seal washer 3270 0852 0010 26 1 Ball valve
3116 0580 0400 03 1 Straight coupling

2930 1519 00 79
Parts list

39

70942

80 2930 1519 00
Parts list

Drain system - Safey valves - With aftercooler - High ambient


condition, Outdoor version, Winterisation 39

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1621 1384 82 1 Housing Full Feature


4010 1621 1384 00 1 Valve housing Outdoor version
4020 1621 3238 00 1 Spacer 6005 0581 0000 86 5 Pipe coupling
4025 1614 6482 00 1 Swirler 6020 0347 4052 22 10 Hose clip
4030 1621 3487 00 1 Impinger 6030 0571 0020 14 10 Hose nipple
4035 0663 6140 00 1 O-ring 6040 0661 1000 27 10 Seal washer
4040 0147 1383 03 1 Bolt 6050 0075 4005 56 AR Hose
4060 1621 5087 00 1 Rod Winterisation Outdoor
4065 0301 2121 01 1 Plain washer version
4070 1621 5086 00 1 Plate 6020 0347 4052 22 20 Hose clip
4075 0301 2121 01 1 Plain washer 6030 0571 0020 14 20 Hose nipple
4080 0147 1962 65 1 Bolt 6040 0661 1000 27 20 Seal washer
4085 0663 2108 94 1 O-ring 6050 0075 4005 56 AR Hose
4090 0147 1407 03 4 Bolt Drain
4095 0301 2358 00 8 Washer IEC
4100 0266 2112 00 4 Nut 7010 1621 4450 00 1 Cable
1621 5628 81 1 Cover 7020 1621 6822 00 1 Drain
5010 1621 5628 01 1 Cover 7030 1621 6822 00 1 Drain
5020 1621 7941 00 2 Bushing CSA-UL
5025 0661 1000 27 2 Seal washer 7010 1621 4450 00 1 Cable
5030 1621 4418 00 1 Plate 7020 1621 6823 00 1 Drain
5040 0147 1962 65 4 Bolt 7030 1621 6823 00 1 Drain
5050 0686 3716 45 1 Hexagon plug Safety valve
5060 0661 1000 27 1 Seal washer 7.5bar(e)
Drain connection 8.6bar(e)
Pack 8005 0830 1008 23 1 Safety valve
Outdoor version 8010 0661 1000 32 1 Seal washer
6005 0581 0000 86 2 Pipe coupling 8035 0830 1008 07 1 Safety valve
6020 0347 4052 22 4 Hose clip 8040 0661 1000 30 1 Seal washer
6030 0571 0020 14 4 Hose nipple 10bar(e)
6040 0661 1000 27 4 Seal washer 10.4bar(e)
6050 0075 4005 56 AR Hose 8005 0830 1008 23 1 Safety valve
Winterisation Outdoor 8010 0661 1000 32 1 Seal washer
version 8035 0830 1008 12 1 Safety valve
6020 0347 4052 22 8 Hose clip 8040 0661 1000 30 1 Seal washer
6030 0571 0020 14 8 Hose nipple
6040 0661 1000 27 8 Seal washer
6050 0075 4005 56 AR Hose

2930 1519 00 81
Parts list

40

70904

82 2930 1519 00
Parts list

Drain system - Safety valves - Hot air variant


40

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Water separator Drain


1005 1621 1408 00 1 Pipe connection IEC
1010 0147 1402 03 4 Bolt 3010 1621 4449 00 1 Cable
1017 0686 3716 30 1 Plug 3020 1621 6822 01 1 Drain
1018 0661 1000 26 1 Seal washer CSA-UL
1020 0663 2107 33 2 O-ring 3010 1621 4449 00 1 Cable
1023 0211 1403 03 4 Cap screw 3020 1621 6823 01 1 Drain
1030 0301 2358 00 4 Washer Safety valve
1060 0603 5125 03 1 Hexagon nipple 7.5bar(e) ASME (U Stamp)
1070 0586 1000 32 1 Union coupling 8.6bar(e) ASME (U Stamp)
1080 0603 4106 03 1 Hexagon nipple 7.5bar(e) DIR
1090 1621 2354 00 1 Flange 8.6bar(e) DIR
1095 0663 2107 33 1 O-ring 7.5bar(e) Lloyds
1100 0147 1407 03 4 Bolt 8.6bar(e) Lloyds
1105 0301 2358 00 8 Washer 7.5bar(e) Japan
1110 0266 2112 00 4 Nut 8.6bar(e) Japan
1125 0560 4401 51 1 Elbow 4005 0830 1008 23 1 Safety valve
1130 0586 3000 15 1 Union 4010 0661 1000 32 1 Seal washer
1135 0560 4401 51 1 Elbow 10bar(e) ASME (U Stamp)
1140 0605 8300 48 1 Bushing 10.4bar(e) ASME (U Stamp)
1145 8204 0940 34 1 Valve 10bar(e) DIR
1150 9000 0243 00 2 Hose nipple 10.4bar(e) DIR
1155 0075 4005 51 AR Hose 10bar(e) Lloyds
1170 0347 6105 00 2 Hose clip 10.4bar(e) Lloyds
1200 1079 9905 49 1 Label 10bar(e) Japan
1621 1384 80 1 Valve housing 10.4bar(e) Japan
2010 1621 1384 00 1 Valve housing 4005 0830 1008 23 1 Safety valve
2020 1621 3238 00 1 Spacer 4010 0661 1000 32 1 Seal washer
2025 1614 6482 00 1 Swirler 7.5bar(e) CE
2030 1621 3487 00 1 Impinger 8.6bar(e) CE
2035 0663 6140 00 1 O-ring 7.5bar(e) CHINA
2040 0147 1383 03 1 Bolt 8.6bar(e) CHINA
2080 1621 3229 00 1 Valve base 4005 0830 1008 23 1 Safety valve
2090 1621 3236 00 4 Rod 4010 0661 1000 32 1 Seal washer
2095 1621 8863 00 1 Plate 10bar(e) CE
2100 0147 1962 65 4 Bolt 10.4bar(e) CE
2110 0686 6442 03 1 Plug 10bar(e) CHINA
2115 0661 1000 25 1 Seal washer 10.4bar(e) CHINA
2130 0686 6444 03 1 Plug 4005 0830 1008 23 1 Safety valve
2135 0661 1000 27 1 Seal washer 4010 0661 1000 32 1 Seal washer
2150 0663 6155 00 1 O-ring
2155 0147 1403 03 4 Bolt
2160 0301 2358 00 4 Washer

2930 1519 00 83
Parts list

41

70943

84 2930 1519 00
Parts list

Drain system - Safety valves - Hot air variant - High ambient condition,
Outdoor version, Winterisation 41

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Water separator Winterisation Outdoor


High ambient condition version
Outdoor version 1005 1621 1408 00 1 Pipe connection
1005 1621 1408 00 1 Pipe connection 1010 0147 1402 03 4 Bolt
1010 0147 1402 03 4 Bolt 1017 0686 3716 30 1 Plug
1017 0686 3716 30 1 Plug 1018 0661 1000 26 1 Seal washer
1018 0661 1000 26 1 Seal washer 1020 0663 2107 33 2 O-ring
1020 0663 2107 33 2 O-ring 1023 0211 1403 03 4 Cap screw
1023 0211 1403 03 4 Cap screw 1030 0301 2358 00 4 Washer
1030 0301 2358 00 4 Washer 1060 0603 5125 03 1 Hexagon nipple
1060 0603 5125 03 1 Hexagon nipple 1070 0586 1000 32 1 Union coupling
1070 0586 1000 32 1 Union coupling 1080 0603 4106 03 1 Hexagon nipple
1080 0603 4106 03 1 Hexagon nipple 1090 1621 2354 00 1 Flange
1090 1621 2354 00 1 Flange 1095 0663 2107 33 1 O-ring
1095 0663 2107 33 1 O-ring 1100 0147 1407 03 4 Bolt
1100 0147 1407 03 4 Bolt 1105 0301 2358 00 8 Washer
1105 0301 2358 00 8 Washer 1110 0266 2112 00 4 Nut
1110 0266 2112 00 4 Nut 1127 0661 1000 25 1 Seal washer
1115 0661 1000 25 1 Seal washer 1128 0603 4100 74 1 Hexagon nipple
1116 0580 0400 03 1 Straight coupling 1130 0581 0001 04 1 Pipe coupling
1117 0580 0500 02 1 Straight coupling 1132 0581 0000 71 1 Pipe coupling
1120 0661 1000 25 1 Seal washer 1135 0661 1000 27 1 Seal washer
1140 0571 0020 23 1 Hose nipple 1160 8204 0940 34 1 Valve
1145 0075 4005 56 AR Hose 1170 1503 2564 04 1 Nipple
1150 0347 6103 00 2 Hose clip 1230 0560 4401 60 1 Tee
1155 0571 0020 38 1 Hose nipple 1235 0560 4401 51 1 Elbow
1160 8204 0940 34 1 Valve 1240 0661 1000 27 1 Seal washer
1170 1503 2564 04 1 Nipple 1245 0582 0116 00 1 Pipe coupling
1190 1079 9905 49 1 Label 1250 1623 0266 00 1 Pipe
1621 1384 81 1 Housing 1255 0582 0116 00 1 Pipe coupling
2010 1621 1384 00 1 Valve housing 1260 0661 1000 27 1 Seal washer
2020 1621 3238 00 1 Spacer 1265 0603 4100 74 2 Hexagon nipple
2025 1614 6482 00 1 Swirler 1270 0852 0010 26 1 Ball valve
2030 1621 3487 00 1 Impinger 1275 1621 7688 00 1 Support
2035 0663 6140 00 1 O-ring 1279 0300 0274 32 3 Plain washer
2040 0147 1383 03 1 Bolt 1280 0226 0300 16 3 Tapping screw
2060 1621 5087 00 1 Rod 1285 0581 0000 86 10 Pipe coupling
2065 0301 2121 01 1 Plain washer 1621 1384 82 1 Housing
2070 1621 5086 00 1 Plate 2010 1621 1384 00 1 Valve housing
2075 0301 2121 01 1 Plain washer 2020 1621 3238 00 1 Spacer
2080 0147 1962 65 1 Bolt 2025 1614 6482 00 1 Swirler
2085 0663 2108 94 1 O-ring 2030 1621 3487 00 1 Impinger
2090 0147 1407 03 4 Bolt 2035 0663 6140 00 1 O-ring
2095 0301 2358 00 8 Washer 2040 0147 1383 03 1 Bolt
2100 0266 2112 00 4 Nut 2060 1621 5087 00 1 Rod
1621 4396 81 1 Cover 2065 0301 2121 01 1 Plain washer
3010 1621 4396 01 1 Cover 2070 1621 5086 00 1 Plate
3020 1621 7941 00 2 Bushing 2075 0301 2121 01 1 Plain washer
3025 0661 1000 27 2 Seal washer 2080 0147 1962 65 1 Bolt
3030 1621 4418 00 1 Plate 2085 0663 2108 94 1 O-ring
3040 0147 1962 65 4 Bolt 2090 0147 1407 03 4 Bolt

2930 1519 00 85
Parts list

41

70943

86 2930 1519 00
Parts list

Drain system - Safety valves - Hot air variant - High ambient condition,
Outdoor version, Winterisation 41

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

2095 0301 2358 00 8 Washer 7.5bar(e) Lloyds


2100 0266 2112 00 4 Nut 8.6bar(e) Lloyds
1621 5628 81 1 Cover 7.5bar(e) Japan
3010 1621 5628 01 1 Cover 8.6bar(e) Japan
3020 1621 7941 00 2 Bushing 6005 0830 1008 23 1 Safety valve
3025 0661 1000 27 2 Seal washer 6010 0661 1000 32 1 Seal washer
3030 1621 4418 00 1 Plate 10bar(e) ASME (U Stamp)
3040 0147 1962 65 4 Bolt 10.4bar(e) ASME (U Stamp)
3050 0686 3716 45 1 Hexagon plug 10bar(e) DIR
3060 0661 1000 27 1 Seal washer 10.4bar(e) DIR
Drain connection 10bar(e) Lloyds
Pack - Outdoor version 10.4bar(e) Lloyds
4005 0581 0000 86 1 Pipe coupling 10bar(e) Japan
4020 0347 4052 22 2 Hose clip 10.4bar(e) Japan
4030 0571 0020 14 2 Hose nipple 6005 0830 1008 23 1 Safety valve
4040 0661 1000 27 2 Seal washer 6010 0661 1000 32 1 Seal washer
4050 0075 4005 56 AR Hose 7.5bar(e) CE
Drain 8.6bar(e) CE
IEC 7.5bar(e) CHINA
5010 1621 4449 00 1 Cable 8.6bar(e) CHINA
5020 1621 6822 01 1 Drain 6005 0830 1008 23 1 Safety valve
CSA-UL 6010 0661 1000 32 1 Seal washer
5010 1621 4449 00 1 Cable 10bar(e) CE
5020 1621 6823 01 1 Drain 10.4bar(e) CE
Safety valve 10bar(e) CHINA
7.5bar(e) ASME (U Stamp) 10.4bar(e) CHINA
8.6bar(e) ASME (U Stamp) 6005 0830 1008 23 1 Safety valve
7.5bar(e) DIR 6010 0661 1000 32 1 Seal washer
8.6bar(e) DIR

2930 1519 00 87
Parts list

42

70905

88 2930 1519 00
Parts list

Cooler(s) - Cooling system


42

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Fan assembly 1080 1088 1001 04 1 Warning mark


380V 50Hz 2005 1621 2530 00 1 Strip
440V 50Hz 2010 1619 2766 00 2 Bolt
1010 1621 2521 01 2 Fan assembly 2015 0147 1249 03 2 Bolt
1015 1503 0786 00 2 Rotation arrow 2016 0266 2108 00 2 Nut
1025 1621 2447 00 2 Support 2020 1621 1436 00 1 Cable box
1030 0147 1440 03 8 Bolt 2030 1088 0254 40 1 Enlarger
1035 0301 2358 00 8 Washer 2040 0698 5140 73 2 Cable gland
1060 0147 1440 03 8 Bolt 2041 0698 5140 72 2 Cable gland
1065 0301 2358 00 8 Washer 2045 0697 9809 22 1 Locknut
1070 1619 2766 00 2 Bolt 2100 1088 1001 02 1 Warning mark
1075 1619 2766 00 4 Bolt 575V 60Hz
1080 1088 1001 04 1 Warning mark 1010 1621 2521 04 2 Fan assembly
2005 1621 2530 00 1 Strip 1015 1503 0786 00 2 Rotation arrow
2010 1619 2766 00 2 Bolt 1025 1621 2447 00 2 Support
2015 0147 1249 03 2 Bolt 1030 0147 1440 03 8 Bolt
2016 0266 2108 00 2 Nut 1035 0301 2358 00 8 Washer
2020 1621 1436 00 1 Cable box 1060 0147 1440 03 8 Bolt
2030 1088 0254 40 1 Enlarger 1065 0301 2358 00 8 Washer
2040 0698 5140 73 2 Cable gland 1070 1619 2766 00 2 Bolt
2041 0698 5140 72 2 Cable gland 1075 1619 2766 00 4 Bolt
2045 0697 9809 22 1 Locknut 1080 1088 1001 04 1 Warning mark
2100 1088 1001 02 1 Warning mark 2005 1621 2530 00 1 Strip
500V 50Hz 2010 1619 2766 00 2 Bolt
1010 1621 2521 02 2 Fan assembly 2015 0147 1249 03 2 Bolt
1015 1503 0786 00 2 Rotation arrow 2016 0266 2108 00 2 Nut
1025 1621 2447 00 2 Support 2020 1089 0699 01 1 Box
1030 0147 1440 03 8 Bolt 2030 1088 0254 40 1 Enlarger
1035 0301 2358 00 8 Washer 2040 0698 5140 73 2 Cable gland
1060 0147 1440 03 8 Bolt 2041 0698 5140 72 2 Cable gland
1065 0301 2358 00 8 Washer 2045 0697 9809 22 1 Locknut
1070 1619 2766 00 2 Bolt 2100 1088 1001 02 1 Warning mark
1075 1619 2766 00 4 Bolt 460V 60Hz
1080 1088 1001 04 1 Warning mark 1010 1621 2521 03 1 Fan assembly
2005 1621 2530 00 1 Strip 1012 1621 2521 03 1 Fan assembly
2010 1619 2766 00 2 Bolt 1015 1503 0786 00 2 Rotation arrow
2015 0147 1249 03 2 Bolt 1025 1621 2447 00 2 Support
2016 0266 2108 00 2 Nut 1030 0147 1440 03 8 Bolt
2020 1621 1436 00 1 Cable box 1035 0301 2358 00 8 Washer
2030 1088 0254 40 1 Enlarger 1060 0147 1440 03 8 Bolt
2040 0698 5140 73 2 Cable gland 1065 0301 2358 00 8 Washer
2041 0698 5140 72 2 Cable gland 1070 1619 2766 00 2 Bolt
2045 0697 9809 22 1 Locknut 1075 1619 2766 00 4 Bolt
2100 1088 1001 02 1 Warning mark 1080 1088 1001 04 1 Warning mark
380V 60Hz 2005 1621 2530 00 1 Strip
440V 60Hz 2010 1619 2766 00 2 Bolt
1010 1621 2521 03 2 Fan assembly 2015 0147 1249 03 2 Bolt
1015 1503 0786 00 2 Rotation arrow 2016 0266 2108 00 2 Nut
1025 1621 2447 00 2 Support 2020 1089 0699 01 1 Box
1030 0147 1440 03 8 Bolt 2030 1088 0254 40 1 Enlarger
1035 0301 2358 00 8 Washer 2040 0698 5140 73 2 Cable gland
1060 0147 1440 03 8 Bolt 2041 0698 5140 72 2 Cable gland
1065 0301 2358 00 8 Washer 2045 0697 9809 22 1 Locknut
1070 1619 2766 00 2 Bolt 2100 1088 1001 02 1 Warning mark
1075 1619 2766 00 4 Bolt

2930 1519 00 89
Parts list

43

70906

90 2930 1519 00
Parts list

Cooler(s) - With aftercooler


43

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

7.5bar(e) 10bar(e) High ambient


8.6bar(e) condition
10bar(e) 10.4bar(e) High ambient
10.4bar(e) condition
1009 0211 1413 03 2 Cap screw 10bar(e) Outdoor version
1010 0147 1402 03 4 Bolt 10.4bar(e) Outdoor version
1011 0147 1400 03 7 Bolt 1009 0211 1413 03 2 Cap screw
1012 0301 2358 00 7 Washer 1010 0147 1402 03 4 Bolt
1015 1621 2711 00 1 Intercooler 1011 0147 1400 03 7 Bolt
1020 1621 2710 00 1 Aftercooler 1012 0301 2358 00 7 Washer
1021 0147 1401 03 4 Bolt 1015 1621 2711 00 1 Intercooler
1023 0301 2358 00 4 Washer 1020 1621 2710 00 1 Aftercooler
1030 0663 2107 13 2 O-ring 1021 0147 1401 03 4 Bolt
1072 0147 1363 03 2 Bolt 1023 0301 2358 00 4 Washer
1075 0147 1362 03 2 Bolt 1030 0663 2107 13 2 O-ring
1080 0301 2344 00 4 Washer 1072 0147 1363 03 2 Bolt
1085 1621 2714 00 1 Plate 1075 0147 1362 03 2 Bolt
1090 1621 2712 00 1 Plate 1080 0301 2344 00 4 Washer
1095 1621 2164 00 1 Plate 1085 1621 2714 00 1 Plate
1100 1619 2766 00 2 Bolt 1090 1621 2712 00 1 Plate
1110 0147 1362 03 2 Bolt 1095 1621 2164 00 1 Plate
1111 0302 1274 01 2 Washer 1100 1619 2766 00 2 Bolt
1115 0147 1400 03 2 Bolt 1110 0147 1362 03 2 Bolt
1116 0302 1274 02 2 Washer 1111 0302 1274 01 2 Washer
1621 2163 80 1 Cooler assembly 1115 0147 1400 03 2 Bolt
2005 1621 2163 00 1 Cooler core 1116 0302 1274 02 2 Washer
2010 1621 2925 11 1 Manifold 1621 2201 80 1 Cooler assembly
2015 1621 2165 00 2 Manifold 2005 1621 2201 00 1 Cooler core
2020 0663 2107 93 4 O-ring 2010 1621 2925 12 1 Manifold
2025 1621 2180 00 2 Plate 2015 1621 2165 00 2 Manifold
2030 1621 2179 00 1 Baffle 2020 1621 2281 00 2 Seal
2035 0147 1322 03 2 Bolt 2025 0663 2107 93 2 O-ring
2040 0147 1325 03 32 Bolt 2030 1621 2180 01 2 Plate
2045 0301 2335 00 32 Washer 2035 1621 2179 01 1 Baffle
2050 0211 1325 03 12 Cap screw 2040 0147 1322 03 2 Bolt
2055 0301 2335 00 12 Washer 2045 0147 1325 03 32 Bolt
1621 2169 80 1 Oil cooler 2050 0301 2335 00 32 Washer
3005 1621 2169 00 1 Oil cooler 2055 0147 1325 03 12 Bolt
3010 1621 2170 00 1 Pipe 2060 0301 2335 00 12 Washer
3015 0663 2107 81 1 O-ring 1621 2169 80 1 Oil cooler
3020 0686 3716 01 2 Plug 3005 1621 2169 00 1 Oil cooler
3025 0661 1000 25 2 Seal washer 3010 1621 2170 00 1 Pipe
3030 0147 1363 03 4 Bolt 3015 0663 2107 81 1 O-ring
3035 0301 2344 00 4 Washer 3020 0686 3716 01 2 Plug
3025 0661 1000 25 2 Seal washer
3030 0147 1363 03 4 Bolt
3035 0301 2344 00 4 Washer

2930 1519 00 91
Parts list

44

70907

92 2930 1519 00
Parts list

Cooler(s) - Hot air variant


44

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

7.5bar(e) 1099 1621 2164 00 1 Plate


8.6bar(e) 1100 1619 2766 00 2 Bolt
10bar(e) 1110 0147 1362 03 2 Bolt
10.4bar(e) 1111 0302 1274 01 2 Washer
1009 0211 1413 03 1 Cap screw 1115 0147 1400 03 2 Bolt
1010 0147 1402 03 2 Bolt 1116 0302 1274 02 2 Washer
1011 0147 1400 03 5 Bolt 1621 2284 80 1 Cooler assembly
1012 0301 2358 00 5 Washer 2005 1621 2284 00 1 Cooler core
1015 1621 2711 00 1 Intercooler 2010 1621 2925 11 1 Manifold
1021 0147 1401 03 2 Bolt 2015 1621 2165 00 1 Manifold
1023 0301 2358 00 2 Washer 2020 0663 2107 93 3 O-ring
1030 0663 2107 13 1 O-ring 2025 0147 1325 03 32 Bolt
1072 0147 1363 03 2 Bolt 2030 0301 2335 00 32 Washer
1075 0147 1362 03 2 Bolt 2035 1621 2283 00 1 Plate
1080 0301 2344 00 4 Washer 1621 2169 80 1 Oil cooler
1085 1621 2714 00 1 Plate 3005 1621 2169 00 1 Oil cooler
1090 1621 2712 00 1 Plate 3010 1621 2170 00 1 Pipe
1091 1621 2285 00 1 Plate 3015 0663 2107 81 1 O-ring
1092 1619 2766 00 4 Bolt 3020 0686 3716 01 2 Plug
1093 1621 2286 00 1 Plate 3025 0661 1000 25 2 Seal washer
1094 1619 2766 00 4 Bolt 3030 0147 1363 03 4 Bolt
1096 1619 2766 00 7 Bolt 3035 0301 2344 00 4 Washer

2930 1519 00 93
Parts list

45

70913

94 2930 1519 00
Parts list

Oil system - With Single oil filter


45

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Connection 3 305 1621 6642 80 1 Pipe


1005 0560 0200 50 1 Elbow 1621 6642 00 1 Pipe
1010 0661 1000 31 1 Seal washer 0686 3716 44 1 Hexagon plug
1015 0686 3716 09 1 Plug 0661 1000 25 1 Seal washer
1 040 1616 5537 00 1 Level indicator 3310 0663 2107 81 1 O-ring
0663 2104 37 4 O-ring 3315 0663 2107 90 1 O-ring
1065 0603 4105 03 1 Hexagon nipple 3320 0147 1363 03 2 Bolt
1070 1619 6153 05 1 Ball valve 3325 0301 2344 00 2 Washer
1075 0571 0020 17 1 Hose nipple 3330 0147 1411 03 2 Bolt
1080 0347 6105 00 1 Hose clip 3335 0301 2358 00 2 Washer
1085 0075 4005 51 AR Hose 3 345 1621 6643 80 1 Pipe
1090 1613 2685 00 1 Hose support 1621 6643 00 1 Pipe
1093 0301 2335 00 1 Washer 0686 3716 44 1 Hexagon plug
1095 0147 1325 03 1 Bolt 0661 1000 25 1 Seal washer
1100 1621 6099 00 1 Piston 3350 0663 2107 90 2 O-ring
1110 1621 6101 00 1 Orifice 3355 0147 1411 03 2 Bolt
1125 1621 7254 00 1 Spring 3360 0147 1413 03 2 Bolt
1130 0335 2120 00 1 Circlip 3365 0301 2358 00 4 Washer
1135 1621 6366 01 1 Plug 3375 1621 2337 00 1 Pipe
1140 0661 1000 29 1 Seal washer 3380 0663 2107 90 2 O-ring
1165 1621 3017 00 1 Pipe 3385 0147 1413 03 2 Bolt
1170 0581 2024 34 1 Male coupling 3390 0301 2358 00 2 Washer
1175 0580 2501 42 1 Elbow coupling 3395 0147 1363 03 2 Bolt
1180 0661 1000 29 1 Seal washer 3400 0301 2344 00 2 Washer
2265 0661 1000 31 2 Seal washer 3410 0686 3716 30 1 Plug
2267 0580 0014 42 2 Pipe coupling 3420 0661 1000 26 1 Seal washer
2270 1621 2760 00 2 Pipe Oil filter
2275 0346 1000 15 2 Pipe clamp 4005 1614 8747 00 1 Oil filter
2276 1619 2766 00 2 Bolt 4010 1621 4024 00 1 Nipple
3200 1621 3783 00 1 Housing Oil pump
3205 0663 2107 81 3 O-ring 50Hz
3210 0147 1326 03 3 Bolt 5005 1616 5439 00 1 Distance ring
3215 2255 0831 00 1 Valve 5010 1621 5783 00 1 Eccentric ring
3220 2250 4490 00 1 Spring 5015 1616 6127 00 1 Oil pump
3225 0661 1000 30 1 Seal washer 5020 0101 1951 36 1 Pin
3230 2255 0833 03 1 Plug 5025 1616 6461 00 1 Pump cover
3235 1621 3219 00 3 Drain plug 5030 0663 2106 16 1 O-ring
3240 0653 1100 00 3 Flat gasket 5035 0147 1327 03 3 Bolt
3245 0663 3125 00 3 O-ring 60Hz
3271 1621 2761 00 2 Pipe 5005 1616 6125 00 1 Distance ring
3272 0661 1000 25 4 Seal washer 5010 1621 5784 00 1 Eccentric ring
3273 0686 3716 01 4 Plug 5015 1616 5436 00 1 Oil pump
3280 0663 2107 90 2 O-ring 5020 0101 1951 36 1 Pin
3285 0147 1363 03 4 Bolt 5025 1616 6461 00 1 Pump cover
5030 0663 2106 16 1 O-ring
5035 0147 1327 03 3 Bolt

2930 1519 00 95
Parts list

46

70914

96 2930 1519 00
Parts list

Oil system - With Duplex oil filter


46

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Connection 3350 0663 2107 90 2 O-ring


1005 0560 0200 50 1 Elbow 3355 0147 1411 03 2 Bolt
1010 0661 1000 31 1 Seal washer 3360 0147 1413 03 2 Bolt
1015 0686 3716 09 1 Plug 3365 0301 2358 00 4 Washer
1 040 1616 5537 00 1 Level indicator 3375 1621 2337 00 1 Pipe
0663 2104 37 4 O-ring 3380 0663 2107 90 2 O-ring
1065 0603 4105 03 1 Hexagon nipple 3385 0147 1413 03 2 Bolt
1070 1619 6153 05 1 Ball valve 3390 0301 2358 00 2 Washer
1075 0571 0020 17 1 Hose nipple 3395 0147 1363 03 2 Bolt
1080 0347 6105 00 1 Hose clip 3400 0301 2344 00 2 Washer
1085 0075 4005 51 AR Hose 3410 0686 3716 30 1 Plug
1090 1613 2685 00 1 Hose support 3420 0661 1000 26 1 Seal washer
1093 0301 2335 00 1 Washer Oil filter
1095 0147 1325 03 1 Bolt 4005 0663 2102 89 1 O-ring
1100 1621 6099 00 1 Piston 4010 1621 3832 00 1 Spacer
1110 1621 6101 00 1 Orifice 4015 0663 2108 08 1 O-ring
1125 1621 7254 00 1 Spring 4020 1621 3833 00 1 Nipple
1130 0335 2120 00 1 Circlip 4025 0661 1000 29 1 Seal washer
1135 1621 6366 01 1 Plug 4030 0580 0014 43 1 Pipe coupling
1140 0661 1000 29 1 Seal washer 4035 1621 4239 00 1 Pipe
1165 1621 3017 00 1 Pipe 4036 0580 0816 00 1 Pipe coupling
1170 0581 2024 34 1 Male coupling 4045 0661 1000 29 1 Seal washer
1175 0580 2501 42 1 Elbow coupling 4050 0603 4200 21 1 Nipple
1180 0661 1000 29 1 Seal washer 4055 0661 1000 34 1 Seal washer
2265 0661 1000 31 2 Seal washer 4060 1610 6667 00 1 Housing
2267 0580 0014 42 2 Pipe coupling 4065 1621 4024 00 2 Nipple
2270 1621 2760 00 2 Pipe 4070 1614 8747 00 2 Oil filter
2275 0346 1000 15 2 Pipe clamp 4075 0661 1000 34 1 Seal washer
2276 1619 2766 00 2 Bolt 4080 0603 4200 21 1 Nipple
3200 1621 3783 00 1 Housing 4085 0661 1000 29 1 Seal washer
3205 0663 2107 81 3 O-ring 4086 0580 0816 00 1 Pipe coupling
3210 0147 1326 03 3 Bolt 4095 1621 4240 00 1 Pipe
3215 2255 0831 00 1 Valve 4100 0580 0014 43 1 Pipe coupling
3220 2250 4490 00 1 Spring 4105 0661 1000 29 1 Seal washer
3225 0661 1000 30 1 Seal washer 4110 1621 2311 00 1 Support
3230 2255 0833 03 1 Plug 4111 0266 2111 00 2 Nut
3235 1621 3219 00 3 Drain plug 4115 0147 1381 03 2 Bolt
3240 0653 1100 00 3 Flat gasket 4120 0301 2378 00 2 Washer
3245 0663 3125 00 3 O-ring 4121 1202 6668 06 2 Spacer
3271 1621 2761 00 2 Pipe 4125 0147 1475 03 2 Bolt
3272 0661 1000 25 4 Seal washer Oil pump
3273 0686 3716 01 4 Plug 50Hz
3280 0663 2107 90 2 O-ring 5005 1616 5439 00 1 Distance ring
3285 0147 1363 03 4 Bolt 5010 1621 5783 00 1 Eccentric ring
3 305 1621 6642 80 1 Pipe 5015 1616 6127 00 1 Oil pump
1621 6642 00 1 Pipe 5020 0101 1951 36 1 Pin
0686 3716 44 1 Hexagon plug 5025 1616 6461 00 1 Pump cover
0661 1000 25 1 Seal washer 5030 0663 2106 16 1 O-ring
3310 0663 2107 81 1 O-ring 5035 0147 1327 03 3 Bolt
3315 0663 2107 90 1 O-ring 60Hz
3320 0147 1363 03 2 Bolt 5005 1616 6125 00 1 Distance ring
3325 0301 2344 00 2 Washer 5010 1621 5784 00 1 Eccentric ring
3330 0147 1411 03 2 Bolt 5015 1616 5436 00 1 Oil pump
3335 0301 2358 00 2 Washer 5020 0101 1951 36 1 Pin
3 345 1621 6643 80 1 Pipe 5025 1616 6461 00 1 Pump cover
1621 6643 00 1 Pipe 5030 0663 2106 16 1 O-ring
0686 3716 44 1 Hexagon plug 5035 0147 1327 03 3 Bolt
0661 1000 25 1 Seal washer

2930 1519 00 97
Parts list

47

70915

98 2930 1519 00
Parts list

Drive arrangement - Arr. E


47
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Coupling housing and half With PT 1000s in the


380V IEC windings and bearings
400V IEC 1080 4205 30 380V 50Hz IEC
440V IEC 1080 4205 13 380V 60Hz IEC
500V IEC 1080 4205 11 400V 50Hz IEC
1005 1621 3727 00 1 Coupling housing 1080 4205 14 440V 60Hz IEC
1010 0147 1405 03 8 Bolt 1080 4207 01 460V 60Hz CSA-UL
1015 1621 3088 00 2 Coupling guard 1080 4205 12 500V 50Hz IEC
1045 1621 4874 00 1 Coupling 1080 4207 02 575V 60Hz CSA-UL
1621 3446 00 1 Coupling half With Anti-condensation
2010 1621 3446 01 1 Coupling half heaters
2020 1621 0206 00 8 Coupling element 1080 4205 30 380V 50Hz IEC
460V CSA-UL 1080 4205 13 380V 60Hz IEC
575V CSA-UL 1080 4205 11 400V 50Hz IEC
1005 1621 1406 00 1 Coupling housing 1080 4205 14 440V 60Hz IEC
1010 0147 1405 03 8 Bolt 1080 4207 01 460V 60Hz CSA-UL
1015 1621 3088 00 2 Coupling guard 1080 4205 12 500V 50Hz IEC
1045 1621 2348 00 1 Coupling 1080 4207 02 575V 60Hz CSA-UL
1621 3446 00 1 Coupling half With Anti-condensation
2010 1621 3446 01 1 Coupling half heaters and With PT 1000s
2020 1621 0206 00 8 Coupling element in the bearings
Without main motor 1080 4205 30 380V 50Hz IEC
1005 1621 3727 00 1 Coupling housing 1080 4205 13 380V 60Hz IEC
1010 0147 1405 03 8 Bolt 1080 4205 11 400V 50Hz IEC
1015 1621 3088 00 2 Coupling guard 1080 4205 14 440V 60Hz IEC
1621 3446 00 1 Coupling half 1080 4207 01 460V 60Hz CSA-UL
2010 1621 3446 01 1 Coupling half 1080 4205 12 500V 50Hz IEC
2020 1621 0206 00 8 Coupling element 1080 4207 02 575V 60Hz CSA-UL
Without main motor With Anti-condensation
Japanese version heaters and With PT 1000s
1005 1621 3727 00 1 Coupling housing in the windings
1010 0147 1405 03 8 Bolt 1080 4205 30 380V 50Hz IEC
1015 1621 3088 00 2 Coupling guard 1080 4205 13 380V 60Hz IEC
1621 3446 00 1 Coupling half 1080 4205 11 400V 50Hz IEC
2010 1621 3446 01 1 Coupling half 1080 4205 14 440V 60Hz IEC
2020 1621 0206 00 8 Coupling element 1080 4207 01 460V 60Hz CSA-UL
Motor 1080 4205 12 500V 50Hz IEC
3135 1 Motor 1080 4207 02 575V 60Hz CSA-UL
1080 4205 29 380V 50Hz IEC With Anti-condensation
1080 4205 13 380V 60Hz IEC heaters and With PT 1000s in
1080 4205 01 400V 50Hz IEC the windings and bearings
1080 4205 14 440V 60Hz IEC 1080 4205 30 380V 50Hz IEC
1080 4207 01 460V 60Hz CSA-UL 1080 4205 13 380V 60Hz IEC
1080 4205 02 500V 50Hz IEC 1080 4205 11 400V 50Hz IEC
1080 4207 02 575V 60Hz CSA-UL 1080 4205 14 440V 60Hz IEC
With PT 1000s in 1080 4207 01 460V 60Hz CSA-UL
the bearings 1080 4205 12 500V 50Hz IEC
1080 4205 30 380V 50Hz IEC 1080 4207 02 575V 60Hz CSA-UL
1080 4205 13 380V 60Hz IEC High ambient condition
1080 4205 11 400V 50Hz IEC 1080 4200 29 380V 50Hz IEC
1080 4205 14 440V 60Hz IEC 1080 4206 13 380V 60Hz IEC
1080 4207 01 460V 60Hz CSA-UL 1080 4200 01 400V 50Hz IEC
1080 4205 12 500V 50Hz IEC 1080 4206 14 440V 60Hz IEC
1080 4207 02 575V 60Hz CSA-UL 1080 4208 01 460V 60Hz CSA-UL
With PT 1000s in 1080 4200 02 500V 50Hz IEC
the windings 1080 4208 02 575V 60Hz CSA-UL
1080 4205 30 380V 50Hz IEC With PT 1000s in the
1080 4205 13 380V 60Hz IEC bearings
1080 4205 11 400V 50Hz IEC 1080 4200 30 380V 50Hz IEC
1080 4205 14 440V 60Hz IEC 1080 4206 13 380V 60Hz IEC
1080 4207 01 460V 60Hz CSA-UL 1080 4200 11 400V 50Hz IEC
1080 4205 12 500V 50Hz IEC 1080 4206 14 440V 60Hz IEC
1080 4207 02 575V 60Hz CSA-UL 1080 4208 01 460V 60Hz CSA-UL
1080 4200 12 500V 50Hz IEC
1080 4208 02 575V 60Hz CSA-UL

2930 1519 00 99
Parts list

47

70915

100 2930 1519 00


Parts list

Drive arrangement - Arr. E


47
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

With PT 1000s in With PT 1000s in the


the windings bearings
1080 4200 30 380V 50Hz IEC 1080 4200 30 380V 50Hz IEC
1080 4206 13 380V 60Hz IEC 1080 4206 13 380V 60Hz IEC
1080 4200 11 400V 50Hz IEC 1080 4200 11 400V 50Hz IEC
1080 4206 14 440V 60Hz IEC 1080 4206 14 440V 60Hz IEC
1080 4208 01 460V 60Hz CSA-UL 1080 4208 01 460V 60Hz CSA-UL
1080 4200 12 500V 50Hz IEC 1080 4200 12 500V 50Hz IEC
1080 4208 02 575V 60Hz CSA-UL 1080 4208 02 575V 60Hz CSA-UL
With PT 1000s in the With PT 1000s in the
windings and bearings windings
1080 4200 30 380V 50Hz IEC 1080 4200 30 380V 50Hz IEC
1080 4206 13 380V 60Hz IEC 1080 4206 13 380V 60Hz IEC
1080 4200 11 400V 50Hz IEC 1080 4200 11 400V 50Hz IEC
1080 4206 14 440V 60Hz IEC 1080 4206 14 440V 60Hz IEC
1080 4208 01 460V 60Hz CSA-UL 1080 4208 01 460V 60Hz CSA-UL
1080 4200 12 500V 50Hz IEC 1080 4200 12 500V 50Hz IEC
1080 4208 02 575V 60Hz CSA-UL 1080 4208 02 575V 60Hz CSA-UL
With Anti-condensation With PT 1000s in the
heaters windings and bearings
1080 4200 30 380V 50Hz IEC 1080 4200 30 380V 50Hz IEC
1080 4206 13 380V 60Hz IEC 1080 4206 13 380V 60Hz IEC
1080 4200 11 400V 50Hz IEC 1080 4200 11 400V 50Hz IEC
1080 4206 14 440V 60Hz IEC 1080 4206 14 440V 60Hz IEC
1080 4208 01 460V 60Hz CSA-UL 1080 4208 01 460V 60Hz CSA-UL
1080 4200 12 500V 50Hz IEC 1080 4200 12 500V 50Hz IEC
1080 4208 02 575V 60Hz CSA-UL 1080 4208 02 575V 60Hz CSA-UL
With Anti-condensation With Anti-condensation
heaters and With PT 1000s in heaters
the bearings 1080 4200 30 380V 50Hz IEC
1080 4200 30 380V 50Hz IEC 1080 4206 13 380V 60Hz IEC
1080 4206 13 380V 60Hz IEC 1080 4200 11 400V 50Hz IEC
1080 4200 11 400V 50Hz IEC 1080 4206 14 440V 60Hz IEC
1080 4206 14 440V 60Hz IEC 1080 4208 01 460V 60Hz CSA-UL
1080 4208 01 460V 60Hz CSA-UL 1080 4200 12 500V 50Hz IEC
1080 4200 12 500V 50Hz IEC 1080 4208 02 575V 60Hz CSA-UL
1080 4208 02 575V 60Hz CSA-UL With Anti-condensation
With Anti-condensation heaters and With PT 1000s in
heaters and With PT 1000s in the bearings
the windings 1080 4200 30 380V 50Hz IEC
1080 4200 30 380V 50Hz IEC 1080 4206 13 380V 60Hz IEC
1080 4206 13 380V 60Hz IEC 1080 4200 11 400V 50Hz IEC
1080 4200 11 400V 50Hz IEC 1080 4206 14 440V 60Hz IEC
1080 4206 14 440V 60Hz IEC 1080 4208 01 460V 60Hz CSA-UL
1080 4208 01 460V 60Hz CSA-UL 1080 4200 12 500V 50Hz IEC
1080 4200 12 500V 50Hz IEC 1080 4208 02 575V 60Hz CSA-UL
1080 4208 02 575V 60Hz CSA-UL With Anti-condensation
With Anti-condensation heaters and With PT 1000s in
heaters and With PT 1000s in the windings
the windings and bearings 1080 4200 30 380V 50Hz IEC
1080 4200 30 380V 50Hz IEC 1080 4206 13 380V 60Hz IEC
1080 4206 13 380V 60Hz IEC 1080 4200 11 400V 50Hz IEC
1080 4200 11 400V 50Hz IEC 1080 4206 14 440V 60Hz IEC
1080 4206 14 440V 60Hz IEC 1080 4208 01 460V 60Hz CSA-UL
1080 4208 01 460V 60Hz CSA-UL 1080 4200 12 500V 50Hz IEC
1080 4200 12 500V 50Hz IEC 1080 4208 02 575V 60Hz CSA-UL
1080 4208 02 575V 60Hz CSA-UL With Anti-condensation
Outdoor version heaters and With PT 1000s in
1080 4200 29 380V 50Hz IEC the windings and bearings
1080 4206 13 380V 60Hz IEC 1080 4200 30 380V 50Hz IEC
1080 4200 01 400V 50Hz IEC 1080 4206 13 380V 60Hz IEC
1080 4206 14 440V 60Hz IEC 1080 4200 11 400V 50Hz IEC
1080 4208 01 460V 60Hz CSA-UL 1080 4206 14 440V 60Hz IEC
1080 4200 02 500V 50Hz IEC 1080 4208 01 460V 60Hz CSA-UL
1080 4208 02 575V 60Hz CSA-UL 1080 4200 12 500V 50Hz IEC
1080 4208 02 575V 60Hz CSA-UL

2930 1519 00 101


Parts list

47

70915

102 2930 1519 00


Parts list

Drive arrangement - Arr. E


47

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Oversized motor With Anti-condensation


1080 4200 29 380V 50Hz IEC heaters and With PT 1000s in
1080 4206 13 380V 60Hz IEC the bearings
1080 4200 01 400V 50Hz IEC 1080 4200 30 380V 50Hz IEC
1080 4206 14 440V 60Hz IEC 1080 4206 13 380V 60Hz IEC
1080 4208 01 460V 60Hz CSA-UL 1080 4200 11 400V 50Hz IEC
1080 4200 02 500V 50Hz IEC 1080 4206 14 440V 60Hz IEC
1080 4208 02 575V 60Hz CSA-UL 1080 4208 01 460V 60Hz CSA-UL
With PT 1000s in 1080 4200 12 500V 50Hz IEC
the bearings 1080 4208 02 575V 60Hz CSA-UL
1080 4200 30 380V 50Hz IEC With Anti-condensation
1080 4206 13 380V 60Hz IEC heaters and With PT 1000s
1080 4200 11 400V 50Hz IEC in the windings
1080 4206 14 440V 60Hz IEC 1080 4200 30 380V 50Hz IEC
1080 4208 01 460V 60Hz CSA-UL 1080 4206 13 380V 60Hz IEC
1080 4200 12 500V 50Hz IEC 1080 4200 11 400V 50Hz IEC
1080 4208 02 575V 60Hz CSA-UL 1080 4206 14 440V 60Hz IEC
With PT 1000s in 1080 4208 01 460V 60Hz CSA-UL
the windings 1080 4200 12 500V 50Hz IEC
1080 4200 30 380V 50Hz IEC 1080 4208 02 575V 60Hz CSA-UL
1080 4206 13 380V 60Hz IEC With Anti-condensation
1080 4200 11 400V 50Hz IEC heaters and With PT 1000s in
1080 4206 14 440V 60Hz IEC the windings and bearings
1080 4208 01 460V 60Hz CSA-UL 1080 4200 30 380V 50Hz IEC
1080 4200 12 500V 50Hz IEC 1080 4206 13 380V 60Hz IEC
1080 4208 02 575V 60Hz CSA-UL 1080 4200 11 400V 50Hz IEC
With PT 1000s in 1080 4206 14 440V 60Hz IEC
the windings and bearings 1080 4208 01 460V 60Hz CSA-UL
1080 4200 30 380V 50Hz IEC 1080 4200 12 500V 50Hz IEC
1080 4206 13 380V 60Hz IEC 1080 4208 02 575V 60Hz CSA-UL
1080 4200 11 400V 50Hz IEC Supports
1080 4206 14 440V 60Hz IEC 380V IEC
1080 4208 01 460V 60Hz CSA-UL 400V IEC
1080 4200 12 500V 50Hz IEC 440V IEC
1080 4208 02 575V 60Hz CSA-UL 500V IEC
With Anti-condensation 4005 1619 5318 02 2 Antivibration pad
heaters 4010 0147 1962 36 2 Bolt
1080 4200 30 380V 50Hz IEC 4015 0147 1400 03 4 Bolt
1080 4206 13 380V 60Hz IEC 4020 0301 2358 00 4 Washer
1080 4200 11 400V 50Hz IEC 4040 1621 2319 00 1 Support
1080 4206 14 440V 60Hz IEC 4045 0147 1400 03 4 Bolt
1080 4208 01 460V 60Hz CSA-UL 4050 0301 2358 00 4 Washer
1080 4200 12 500V 50Hz IEC 4055 1619 5318 01 1 Rubber buffer
1080 4208 02 575V 60Hz CSA-UL 4060 0147 1478 03 1 Bolt

2930 1519 00 103


Parts list

47

70915

104 2930 1519 00


Parts list

Drive arrangement - Arr. E


47

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

4065 0302 1274 04 1 Washer 4010 0147 1962 36 2 Bolt


4070 1621 2707 00 1 Plate 4015 0147 1400 03 4 Bolt
4075 1621 0048 07 1 Spacer 4020 0301 2358 00 4 Washer
4080 0147 1638 03 1 Bolt 4036 0211 1401 03 1 Cap screw
4085 0147 1400 03 2 Bolt 4037 1621 4498 00 1 Bracket
4086 0301 2358 00 2 Washer 4038 0301 2358 00 1 Washer
460V CSA-UL 4040 1621 2319 00 1 Support
575V CSA-UL 4041 0266 2112 00 1 Nut
4005 1619 5318 02 2 Antivibration pad 4045 0147 1400 03 4 Bolt
4010 0147 1962 36 2 Bolt 4050 0301 2358 00 4 Washer
4015 0147 1400 03 4 Bolt 4055 1619 5318 01 1 Rubber buffer
4020 0301 2358 00 4 Washer 4060 0147 1478 03 1 Bolt
4040 1621 2319 00 1 Support 4065 0302 1274 04 1 Washer
4045 0147 1400 03 4 Bolt 4070 1621 2707 00 1 Plate
4050 0301 2358 00 4 Washer 4075 1621 3022 00 1 Disc
4055 1619 5318 01 1 Rubber buffer 4080 0147 1638 03 1 Bolt
4060 0147 1478 03 1 Bolt 4082 1088 1301 03 1 Cable strip
4065 0302 1274 04 1 Washer 4085 0147 1400 03 2 Bolt
4070 1621 2707 00 1 Plate 4086 0301 2358 00 2 Washer
4075 1621 2316 00 1 Spacer 4090 1619 2766 00 6 Bolt
4080 0147 1638 03 1 Bolt Anchor pads
4085 0147 1400 03 2 Bolt 5020 1621 6580 00 4 Anchor pad
4086 0301 2358 00 2 Washer 5025 0147 1475 03 8 Bolt
Without main motor 5030 0226 9929 06 8 Wedge bolt
4005 1619 5318 02 2 Antivibration pad

2930 1519 00 105


Parts list

48

70916

106 2930 1519 00


Parts list

Drive arrangement - Arr. 1


48

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Coupling housing and half 3040 0301 2358 00 4 Washer


1015 1621 3449 00 2 Coupling guard 3090 1020 5072 00 2 Rubber buffer
1020 0147 1402 03 8 Bolt 3100 0147 1400 03 4 Bolt
1025 0301 2358 00 8 Washer 3110 0301 2358 00 4 Washer
1030 0147 1323 03 2 Bolt 3120 0147 1477 03 2 Bolt
1035 0266 2110 00 2 Hexagon nut 3140 0301 2378 00 2 Washer
1621 3446 00 1 Coupling half 3200 1621 4027 00 1 Frame
2010 1621 3446 01 1 Coupling half 3210 0147 1962 36 8 Bolt
2020 1621 0206 00 8 Coupl.element 3220 1619 2766 00 6 Bolt
Supports Anchor pads
3004 1619 5318 01 1 Rubber buffer 4020 1621 6580 00 4 Anchor pad
3008 1619 5318 02 1 Antivibration pad 4025 0147 1475 03 8 Bolt
3020 0147 1962 36 2 Bolt 4030 0226 9929 06 8 Wedge bolt
3030 0147 1400 03 4 Bolt

2930 1519 00 107


Parts list

49

70917

108 2930 1519 00


Parts list

Control module - Pack


49

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1001 1621 2602 00 1 Plate High ambient condition


1002 1619 2766 00 2 Bolt Outdoor version
1003 1621 2549 00 1 Clip 1001 1621 2602 00 1 Plate
1020 1089 9154 02 2 Key 1002 1619 2766 00 2 Bolt
1025 0160 6021 00 2 Slotted screw 1003 1621 2549 00 1 Clip
1026 0301 2309 00 2 Washer 1020 1089 9154 02 2 Key
1030 0160 6038 00 4 Screw 1030 0160 6038 00 4 Screw
1040 0301 2315 00 4 Washer 1040 0301 2315 00 4 Washer
1050 1621 2182 00 1 Wire harness 1050 1621 2182 00 1 Wire harness
1051 1088 1301 01 10 Cable strip 1051 1088 1301 01 10 Cable strip
1052 0348 0102 08 5 Cable tie 1052 0348 0102 08 5 Cable tie
1070 1619 6032 01 1 Nipple 1070 1619 6032 01 1 Nipple
1071 1619 6032 05 1 Nipple 1071 1619 6032 05 1 Nipple
1300 1089 0575 65 1 Pressure transducer 1300 1089 0575 65 1 Pressure transducer
1310 1089 0575 74 1 Pressure transducer 1310 1089 0575 74 1 Pressure transducer
1 312 1621 1247 80 1 Nipple 1 312 1621 1247 80 1 Nipple
1621 1247 00 1 Nipple 1621 1247 00 1 Nipple
1621 1248 00 1 Nipple 1621 1248 00 1 Nipple
1621 1249 00 1 Bushing 1621 1249 00 1 Bushing
1313 0661 1000 25 1 Seal washer 1313 0661 1000 25 1 Seal washer
1 314 1621 1247 80 1 Nipple 1 314 1621 1247 80 1 Nipple
1621 1247 00 1 Nipple 1621 1247 00 1 Nipple
1621 1248 00 1 Nipple 1621 1248 00 1 Nipple
1621 1249 00 1 Bushing 1621 1249 00 1 Bushing
1315 0661 1000 25 1 Seal washer 1315 0661 1000 25 1 Seal washer
1320 1089 0575 74 1 Pressure transducer 1320 1089 0575 74 1 Pressure transducer
1 331 1621 1247 80 1 Nipple 1 331 1621 1247 80 1 Nipple
1621 1247 00 1 Nipple 1621 1247 00 1 Nipple
1621 1248 00 1 Nipple 1621 1248 00 1 Nipple
1621 1249 00 1 Bushing 1621 1249 00 1 Bushing
1336 0661 1000 25 1 Seal washer 1336 0661 1000 25 1 Seal washer
1340 1089 0575 73 1 Pressure transducer 1340 1089 0575 73 1 Pressure transducer
1348 1619 2689 00 1 Filter plug 1349 1619 2689 00 1 Filter plug
1351 1621 0082 00 1 Muffler 1351 1621 0082 00 1 Muffler
1355 1621 6921 00 1 Screen 1355 1621 6921 00 1 Screen
1370 1614 6596 00 2 Knurled nut 1370 1614 6596 00 2 Knurled nut
1371 0223 4000 35 2 Shoulder screw 1371 0223 4000 35 2 Shoulder screw
1375 1079 9901 67 1 Label 1375 1079 9901 67 1 Label
1500 1619 2766 00 4 Bolt 1500 1619 2766 00 4 Bolt
1501 1089 0574 70 1 Temperature sensor 1501 1089 0574 70 1 Temperature sensor
1502 1089 0574 70 1 Temperature sensor 1502 1089 0574 70 1 Temperature sensor
1503 1089 0574 70 1 Temperature sensor 1503 1089 0574 70 1 Temperature sensor
1504 1089 0574 70 1 Temperature sensor 1504 1089 0574 70 1 Temperature sensor
1505 1089 0574 70 1 Temperature sensor 1505 1089 0574 70 1 Temperature sensor
1506 1089 0574 70 1 Temperature sensor 1506 1089 0574 70 1 Temperature sensor
1530 1619 2766 00 6 Bolt 1530 1619 2766 00 6 Bolt
1605 0147 1360 03 4 Bolt 1605 0147 1360 03 4 Bolt

2930 1519 00 109


Parts list

49

70917

110 2930 1519 00


Parts list

Control module - Pack


49

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Electrical system 7070 0663 2132 00 1 O-ring


Outdoor version 7080 0147 1252 03 2 Bolt
2005 1900 0710 71 1 Regulator 7090 0266 2108 00 2 Nut
With PT 1000s in 7100 0603 4100 44 2 Hex. Nipple
the windings 7110 1621 7443 00 1 Valve
With PT 1000s in 7120 0580 0013 32 1 Coupling
the bearings 7130 0661 1000 25 1 Seal washer
With PT 1000s in the 7135 2250 6353 11 1 Flexible
windings and bearings 7137 1621 3189 00 2 Bracket
2010 1900 0710 82 1 Regulator 7138 0147 1397 03 1 Bolt
3010 Cable 7139 0301 2358 00 1 Washer
1622 0661 03 AR L = 1100 mm 7140 0300 0274 17 1 Washer
1622 0661 02 AR L = 150 mm 7142 1613 0801 05 2 Clamp
MKIV Regulator 7143 0147 1247 03 2 Bolt
Normal display 7144 0291 1108 00 2 Locknut
4010 1900 0710 32 1 Regulator 7145 0605 8809 06 1 Bushing
High Resolution display 7147 0661 1000 26 1 Seal washer
4010 1900 0712 92 1 Regulator 7150 0580 0506 00 1 Male adapter
5010 1621 9216 00 1 Blow-down valve 7160 0661 1000 25 1 Seal washer
Winterisation 7170 0580 3404 00 1 Pipe coupling
6005 1900 0711 51 1 Regulator 7180 1621 7672 00 1 Support
With kit purge air during 7190 0147 1322 03 2 Bolt
standstill 7200 0211 1170 03 4 Hexagon socket screw
7010 1623 6353 10 1 Flexible Kit purge air during standstill
7020 0580 0013 32 1 Coupling 8010 1089 0640 44 1 Solenoid valve
7030 0661 1000 25 1 Seal washer 8015 1088 1301 01 15 Cable strip
7040 1621 1382 00 1 Flange 8020 1621 7910 00 1 Wiring
7050 1621 0735 00 1 Filter element 8025 0697 9809 02 1 Nut
7060 1621 1383 00 1 Flange

2930 1519 00 111


Parts list

50

70918

112 2930 1519 00


Parts list

Control module - Full Feature


50

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1001 1621 2602 00 1 Plate High ambient condition


1002 1619 2766 00 2 Bolt Outdoor version
1003 1621 2549 00 1 Clip 1001 1621 2602 00 1 Plate
1020 1089 9154 02 2 Key 1002 1619 2766 00 2 Bolt
1025 0160 6021 00 2 Slotted screw 1003 1621 2549 00 1 Clip
1026 0301 2309 00 2 Washer 1020 1089 9154 02 2 Key
1030 0160 6038 00 4 Screw 1030 0160 6038 00 4 Screw
1040 0301 2315 00 4 Washer 1040 0301 2315 00 4 Washer
1050 1621 2182 00 1 Wire harness 1050 1621 2182 00 1 Wire harness
1051 1088 1301 01 10 Cable strip 1051 1088 1301 01 10 Cable strip
1052 0348 0102 08 5 Cable tie 1052 0348 0102 08 5 Cable tie
1055 1619 2766 00 1 Bolt 1070 1619 6032 01 1 Nipple
1070 1619 6032 01 1 Nipple 1071 1619 6032 05 1 Nipple
1071 1619 6032 05 1 Nipple 1300 1089 0575 65 1 Pressure transducer
1300 1089 0575 65 1 Pressure transducer 1310 1089 0575 74 1 Pressure transducer
1310 1089 0575 74 1 Pressure transducer 1 312 1621 1247 80 1 Nipple
1 312 1621 1247 80 1 Nipple 1621 1247 00 1 Nipple
1621 1247 00 1 Nipple 1621 1248 00 1 Nipple
1621 1248 00 1 Nipple 1621 1249 00 1 Bushing
1621 1249 00 1 Bushing 1313 0661 1000 25 1 Seal washer
1313 0661 1000 25 1 Seal washer 1 314 1621 1247 80 1 Nipple
1 314 1621 1247 80 1 Nipple 1621 1247 00 1 Nipple
1621 1247 00 1 Nipple 1621 1248 00 1 Nipple
1621 1248 00 1 Nipple 1621 1249 00 1 Bushing
1621 1249 00 1 Bushing 1315 0661 1000 25 1 Seal washer
1315 0661 1000 25 1 Seal washer 1320 1089 0575 74 1 Pressure transducer
1320 1089 0575 74 1 Pressure transducer 1 331 1621 1247 80 1 Nipple
1 331 1621 1247 80 1 Nipple 1621 1247 00 1 Nipple
1621 1247 00 1 Nipple 1621 1248 00 1 Nipple
1621 1248 00 1 Nipple 1621 1249 00 1 Bushing
1621 1249 00 1 Bushing 1336 0661 1000 25 1 Seal washer
1336 0661 1000 25 1 Seal washer 1340 1089 0575 73 1 Pressure transducer
1340 1089 0575 73 1 Pressure transducer 1349 1619 2689 00 1 Filter plug
1348 1619 2689 00 1 Filter plug 1351 1621 0082 00 1 Muffler
1351 1621 0082 00 1 Muffler 1355 1621 6921 00 1 Screen
1355 1621 6921 00 1 Screen 1370 1614 6596 00 2 Knurled nut
1370 1614 6596 00 2 Knurled nut 1371 0223 4000 35 2 Shoulder screw
1371 0223 4000 35 2 Shoulder screw 1375 1079 9901 67 1 Label
1375 1079 9901 67 1 Label 1500 1619 2766 00 4 Bolt
1500 1619 2766 00 4 Bolt 1501 1089 0574 70 1 Temperature sensor
1501 1089 0574 70 1 Temperature sensor 1502 1089 0574 70 1 Temperature sensor
1502 1089 0574 70 1 Temperature sensor 1503 1089 0574 70 1 Temperature sensor
1503 1089 0574 70 1 Temperature sensor 1504 1089 0574 70 1 Temperature sensor
1504 1089 0574 70 1 Temperature sensor 1505 1089 0574 70 1 Temperature sensor
1505 1089 0574 70 1 Temperature sensor 1506 1089 0574 70 1 Temperature sensor
1506 1089 0574 70 1 Temperature sensor 1530 1619 2766 00 6 Bolt
1530 1619 2766 00 6 Bolt 1605 0147 1360 03 4 Bolt
1605 0147 1360 03 4 Bolt Full Feature
Full Feature 2010 1900 0710 82 1 Regulator
2010 1900 0710 82 1 Regulator 2050 1621 4432 00 1 Wiring
2050 1621 4432 00 1 Wiring 2051 1088 1301 01 5 Cable strip
2051 1088 1301 01 5 Cable strip 2053 0697 9809 02 1 Nut
2501 1089 0574 70 1 Temperature sensor 2501 1089 0574 70 1 Temperature sensor

2930 1519 00 113


Parts list

50

70918

114 2930 1519 00


Parts list

Control module - Full Feature


50

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Electrical system With kit purge air during


High ambient condition standstill
3005 1900 0710 71 1 Regulator 10 010 1623 6353 10 1 Flexible
With PT 1000s in 10 020 0580 0013 32 1 Coupling
the bearings 10 030 0661 1000 25 1 Seal washer
With PT 1000s in 10 040 1621 1382 00 1 Flange
the windings 10 050 1621 0735 00 1 Filter element
With PT 1000s in the 10 060 1621 1383 00 1 Flange
windings and bearings 10 070 0663 2132 00 1 O-ring
3010 1900 0710 82 1 Regulator 10 080 0147 1252 03 2 Bolt
4010 Cable 10 090 0266 2108 00 2 Nut
1622 0661 03 AR L = 1100 mm 10 100 0603 4100 44 2 Hex. Nipple
1622 0661 02 AR L = 150 mm 10 110 1621 7443 00 1 Valve
MKIV Regulator 10 120 0580 0013 32 1 Coupling
Normal display 10 130 0661 1000 25 1 Seal washer
5010 1900 0710 32 1 Regulator 10 135 2250 6353 11 1 Flexible
High Resolution display 10 137 1621 3189 00 2 Bracket
5010 1900 0712 92 1 Regulator 10 138 0147 1397 03 1 Bolt
6010 1621 9216 00 1 Blow-down valve 10 139 0301 2358 00 1 Washer
Low load compensator for IMD 10 140 0300 0274 17 1 Washer
PDp filter 10 142 1613 0801 05 2 Clamp
PDp filter Low load 10 143 0147 1247 03 2 Bolt
compensator for IMD 10 144 0291 1108 00 2 Locknut
PDp filter PDP sensor 10 145 0605 8809 06 1 Bushing
PDp filter PDP sensor Low 10 147 0661 1000 26 1 Seal washer
load compensator for IMD 10 150 0580 0506 00 1 Male adapter
7010 1900 0711 62 1 Module 10 160 0661 1000 25 1 Seal washer
PDp filter 10 170 0580 3404 00 1 Pipe coupling
PDp filter PDP sensor 10 180 1621 7672 00 1 Support
Low load compensator for IMD 10 190 0147 1322 03 2 Bolt
PDp filter 10 200 0211 1170 03 4 Hexagon socket screw
PDp filter PDP sensor Kit purge air during standstill
8001 1621 5098 01 1 Wire harness 11 010 1089 0640 44 1 Solenoid valve
8010 1088 1301 01 5 Cable strip 11 015 1088 1301 01 15 Cable strip
Winterisation 11 020 1621 7910 00 1 Wiring
9005 1900 0711 51 1 Regulator 11 025 0697 9809 02 1 Nut

2930 1519 00 115


Parts list

51 Control module - Full Feature - Pdp Sensor set without DDp filter

70919

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

PDP sensor 2050 0603 4300 07 1 Hexagon nipple


1005 0663 2108 66 1 O-ring 2060 0070 6002 43 AR Tube
1010 1621 4330 00 1 Flange 1617 9655 80 1 Sensor housing
1020 0603 4102 03 1 Hexagon nipple 3010 0663 2129 00 1 O-ring
1030 0852 0010 45 1 Ball valve 3020 1617 9656 00 1 Filter element
1035 0661 1000 25 1 Seal washer 3030 1617 9654 00 1 Bolt sensor housing
1040 0586 1000 23 1 Union 3040 1617 9653 00 1 Sensor housing
1060 0147 1242 03 2 Hex. head screw Electrical system
1070 0301 2321 00 2 Washer PDP sensor
1080 1621 4331 00 1 Bracket 4010 1900 0711 62 1 Module
1090 0147 1322 03 2 Bolt 5010 Cable
1100 0301 2335 00 2 Washer 1622 0661 03 AR L = 1100 mm
1110 0989 4220 12 1 Grommet 1622 0661 02 AR L = 150 mm
1603 5700 99 1 Pdp sensor set PDP sensor
2010 1089 9481 51 1 Mitchell dewpoint transmittor 6001 1621 5098 01 1 Wire harness
2030 9090 1518 00 1 Coupl. elbow 6010 1088 1301 01 5 Cable strip
2040 8204 0941 09 1 Needle valve

116 2930 1519 00


Parts list

Control module - SPM monitoring


52

70920

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

SPM monitoring equipment 1621 7013 80 1 Support


1010 1621 2599 00 1 Wire harness 2005 1621 7013 00 1 Support
1020 1088 1301 01 8 Cable strip 2010 1621 7014 00 1 Plate
1031 0226 3343 86 4 Tapping screw 2015 0160 6059 00 2 Screw
1033 1089 0577 55 2 Adapter Electrical system
1040 1089 0457 77 1 Alarm unit 3010 Cable
1060 1089 0457 04 1 Shock transducer 1622 0661 03 AR L = 1100 mm
1070 1089 0457 06 1 Shock transducer 1622 0661 02 AR L = 150 mm
1080 1089 0457 04 5 Shock transducer

2930 1519 00 117


Parts list

53

71175

118 2930 1519 00


Parts list

Cubicle - IEC
53
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1 Control panel 1095 1088 0031 13 1 Connector


1900 3156 01 380V 50Hz 1100 1089 0612 25 2 Fuse
1900 3156 01 400V 50Hz 1105 1089 0612 01 2 Fuse Holder
1900 3156 01 440V 60Hz 1110 1089 9203 31 1 Circuit Breaker
1900 3156 01 500V 50Hz 1115 1089 9446 71 1 Relay
1900 3156 01 500V 50Hz Oversized motor 1120 1089 9621 06 1 Circuit Breaker
1010 1079 9906 09 1 Label 1125 1089 9621 07 2 Circuit Breaker
1015 9823 1901 01 1 Service diagram 1130 1089 9415 03 1 Contact Block
1020 1613 6639 00 1 Data Plate 1135 1089 9415 17 1 Contactor
1025 1088 0031 06 1 Connector 1140 1089 9415 04 1 Contact Block
1030 1088 0031 07 1 Connector 1145 1089 9415 59 2 Contactor
1035 1079 9901 68 1 Label 1150 1089 9415 09 3 Contact Block
1040 1089 0506 06 6 Terminal 1155 1089 9415 07 2 Contact Block
1045 1088 0037 31 1 Connector 1160 1089 9415 08 1 Contact Block
1050 1088 0037 33 2 Connector 1165 1089 9415 42 1 Contactor
1055 1088 0037 30 1 Connector 1170 1089 9438 04 2 Relay
1060 1088 0031 66 2 Connector 1175 1089 0362 51 1 Stop Button
1065 1089 0506 27 1 Terminal 1180 1089 0362 50 1 Contact Block
1070 1089 9398 30 3 Terminal 1185 1089 0362 58 1 Contact Block
1075 1089 9398 11 32 Terminal 1190 1089 9436 07 1 Transformer
1080 1088 0031 49 1 Connector 1195 1089 9436 11 1 Transformer
1085 1088 0031 29 1 Connector 1900 3156 04 440V 60Hz Oversized motor
1090 1088 0031 30 1 Connector 1010 1079 9906 09 1 Label
1095 1088 0031 13 1 Connector 1015 9823 1901 01 1 Service diagram
1100 1089 0612 25 2 Fuse 1020 1613 6639 00 1 Data Plate
1105 1089 0612 01 2 Fuse Holder 1025 1088 0031 06 1 Connector
1110 1089 9203 31 1 Circuit Breaker 1030 1088 0031 07 1 Connector
1115 1089 9446 71 1 Relay 1035 1079 9901 68 1 Label
1120 1089 9621 06 1 Circuit Breaker 1040 1089 0506 06 6 Terminal
1125 1089 9621 07 2 Circuit Breaker 1045 1088 0037 31 1 Connector
1130 1089 9415 03 1 Contact Block 1050 1088 0037 33 2 Connector
1135 1089 9415 17 1 Contactor 1055 1088 0037 30 1 Connector
1140 1089 9415 04 1 Contact Block 1060 1088 0031 66 2 Connector
1145 1089 9415 58 2 Contactor 1065 1089 0506 27 1 Terminal
1150 1089 9415 09 3 Contact Block 1070 1089 9398 30 3 Terminal
1155 1089 9415 07 2 Contact Block 1075 1089 9398 11 32 Terminal
1160 1089 9415 08 1 Contact Block 1080 1088 0031 49 1 Connector
1165 1089 9415 41 1 Contactor 1085 1088 0031 29 1 Connector
1170 1089 9438 04 2 Relay 1090 1088 0031 30 1 Connector
1175 1089 0362 51 1 Stop Button 1095 1088 0031 13 1 Connector
1180 1089 0362 50 1 Contact Block 1100 1089 0612 25 2 Fuse
1185 1089 0362 58 1 Contact Block 1105 1089 0612 01 2 Fuse Holder
1190 1089 9436 07 1 Transformer 1110 1089 9203 31 1 Circuit Breaker
1195 1089 9436 11 1 Transformer 1115 1089 9446 71 1 Relay
1900 3156 03 380V 60Hz 1120 1089 9621 06 1 Circuit Breaker
1900 3156 03 380V 50Hz Oversized motor 1125 1089 9621 07 2 Circuit Breaker
1900 3156 03 400V 50Hz Oversized motor 1130 1089 9415 03 1 Contact Block
1010 1079 9906 09 1 Label 1135 1089 9415 17 1 Contactor
1015 9823 1901 01 1 Service diagram 1140 1089 9415 04 1 Contact Block
1020 1613 6639 00 1 Data Plate 1145 1089 9415 60 2 Contactor
1025 1088 0031 06 1 Connector 1150 1089 9415 09 3 Contact Block
1030 1088 0031 07 1 Connector 1165 1089 9415 58 1 Contactor
1035 1079 9901 68 1 Label 1170 1089 9438 04 2 Relay
1040 1089 0506 06 6 Terminal 1175 1089 0362 51 1 Stop Button
1045 1088 0037 31 1 Connector 1180 1089 0362 50 1 Contact Block
1050 1088 0037 33 2 Connector 1185 1089 0362 58 1 Contact Block
1055 1088 0037 30 1 Connector 1190 1089 9436 07 1 Transformer
1060 1088 0031 66 2 Connector 1195 1089 9436 11 1 Transformer
1065 1089 0506 27 1 Terminal 1900 3156 05 380V 60Hz Oversized motor
1070 1089 9398 30 3 Terminal 1010 1079 9906 09 1 Label
1075 1089 9398 11 32 Terminal 1015 9823 1901 01 1 Service diagram
1080 1088 0031 49 1 Connector 1020 1613 6639 00 1 Data Plate
1085 1088 0031 29 1 Connector 1025 1088 0031 06 1 Connector
1090 1088 0031 30 1 Connector 1030 1088 0031 07 1 Connector

2930 1519 00 119


Parts list

53

71175

120 2930 1519 00


Parts list

Cubicle - IEC
53

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1035 1079 9901 68 1 Label 1900 3160 03 Option Anti-condensation


1040 1089 0506 06 6 Terminal heaters
1045 1088 0037 31 1 Connector 4010 1088 0037 30 1 Connector
1050 1088 0037 33 2 Connector Option IMD Dryer
1055 1088 0037 30 1 Connector 1900 3160 07 7.5bar(e)
1060 1088 0031 66 2 Connector 1900 3160 07 8.6bar(e)
1065 1089 0506 27 1 Terminal 1900 3160 07 10bar(e)
1070 1089 9398 30 3 Terminal 1900 3160 07 10.4bar(e)
1075 1089 9398 11 32 Terminal 5010 1088 0037 33 3 Connector
1080 1088 0031 49 1 Connector 5015 1088 0037 31 2 Connector
1085 1088 0031 29 1 Connector 5020 1088 0037 30 1 Connector
1090 1088 0031 30 1 Connector 5025 1089 9621 05 1 Circuit Breaker
1095 1088 0031 13 1 Connector 5030 1089 9407 06 1 Power Supply
1100 1089 0612 25 2 Fuse 1900 3160 32 Option Hot air variant
1105 1089 0612 01 2 Fuse Holder 6005 1088 0031 65 1 Connector
1110 1089 9203 31 1 Circuit Breaker 1900 3160 30 Option Fan
1115 1089 9446 72 1 Relay 7010 1088 0037 31 1 Connector
1120 1089 9621 06 1 Circuit Breaker 7015 1089 0506 27 2 Terminal
1125 1089 9621 07 2 Circuit Breaker 7020 1089 0612 28 3 Fuse
1130 1089 9415 03 1 Contact Block 7025 1089 0612 01 3 Fuse Holder
1135 1089 9415 17 1 Contactor 7030 1089 9446 55 2 Overload Relay
1140 1089 9415 04 1 Contact Block 7035 1089 9415 21 2 Contactor
1145 1089 9415 78 2 Contactor 1900 3160 29 Option Low load compensator
1150 1089 9415 09 3 Contact Block for IMD
1165 1089 9415 58 1 Contactor 8010 1088 0037 31 1 Connector
1170 1089 9438 04 2 Relay 8015 1088 0037 30 1 Connector
1175 1089 0362 51 1 Stop Button 8020 1089 0506 27 2 Terminal
1180 1089 0362 50 1 Contact Block 8025 1089 0612 28 3 Fuse
1185 1089 0362 58 1 Contact Block 8030 1089 0612 01 3 Fuse Holder
1190 1089 9436 07 1 Transformer 8035 1089 9446 55 1 Overload Relay
1195 1089 9436 11 1 Transformer 8040 1089 9415 22 1 Contactor
2005 1621 2232 00 1 Mounting panel 1900 3160 46 Option Purge dry air
Label 9010 1088 0037 31 1 Connector
No low load 1900 3160 02 Option PT 1000s in the
380V 50Hz windings and bearings
380V 60Hz 1900 3160 10 Option High ambient
400V 50Hz condition
440V 60Hz 1900 3160 10 Option Outdoor version
500V 50Hz 1900 3160 13 Option DDp filter
3010 1079 9923 58 1 Label 1900 3160 25 Option SPM Monitoring
Low load compensator for IMD 1900 3160 28 Option Pressure Dew Point
380V 50Hz 1900 3160 47 Option Winterisation
380V 60Hz Dryer by-pass
400V 50Hz
440V 60Hz
500V 50Hz
3010 1079 9923 33 1 Label

2930 1519 00 121


Parts list

54

70929

122 2930 1519 00


Parts list

Cubicle - IEC High ambient condition, Outdoor version


54
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1 Control panel 1105 1089 0612 01 2 Fuse Holder


1900 3156 31 380V 50 Hz 1110 1089 9446 71 1 Relay
1900 3156 31 400V 50Hz 1115 1089 9621 06 1 Circuit Breaker
1900 3156 31 400V 60Hz 1120 1089 9621 07 2 Circuit Breaker
1900 3156 31 500V 50Hz 1125 1089 9415 02 1 Contact Block
1900 3156 31 500V 50Hz Oversized motor 1130 1089 9415 17 1 Contactor
1010 1079 9906 09 1 Label 1140 1089 9415 59 2 Contactor
1015 9823 1901 11 1 Service diagram 1145 1089 9415 09 3 Contact Block
1020 1613 6639 00 1 Data Plate 1150 1089 9415 07 2 Contact Block
1025 1088 0031 06 1 Connector 1155 1089 9415 08 1 Contact Block
1030 1088 0031 07 1 Connector 1160 1089 9415 42 1 Contactor
1035 1079 9901 68 1 Label 1165 1089 9438 04 1 Relay
1040 1089 0506 06 6 Terminal 1170 1089 0362 51 1 Stop Button
1045 1088 0037 31 1 Connector 1175 1089 0362 58 2 Contact Block
1050 1088 0037 35 2 Connector 1180 1089 9436 08 1 Transformer
1055 1088 0037 30 1 Connector 1185 1089 9436 11 1 Transformer
1060 1089 0506 27 1 Terminal 1190 1089 9407 06 1 Power Supply
1065 1089 9398 30 3 Terminal 1900 3156 35 380V 60Hz Oversized motor
1070 1089 9398 11 38 Terminal 1010 1079 9906 09 1 Label
1075 1088 0031 49 1 Connector 1015 9823 1901 11 1 Service diagram
1080 1088 0031 29 1 Connector 1020 1613 6639 00 1 Data Plate
1085 1088 0031 30 1 Connector 1025 1088 0031 06 1 Connector
1090 1088 0031 13 1 Connector 1030 1088 0031 07 1 Connector
1095 1088 0031 12 1 Connector 1035 1079 9901 68 1 Label
1100 1089 0612 25 2 Fuse 1040 1089 0506 06 6 Terminal
1105 1089 0612 01 2 Fuse Holder 1045 1088 0037 31 1 Connector
1110 1089 9446 71 1 Relay 1050 1088 0037 35 2 Connector
1115 1089 9621 06 1 Circuit Breaker 1055 1088 0037 30 1 Connector
1120 1089 9621 07 2 Circuit Breaker 1060 1089 0506 27 1 Terminal
1125 1089 9415 02 1 Contact Block 1065 1089 9398 30 3 Terminal
1130 1089 9415 17 1 Contactor 1070 1089 9398 11 38 Terminal
1140 1089 9415 58 2 Contactor 1075 1088 0031 49 1 Connector
1145 1089 9415 09 3 Contact Block 1080 1088 0031 29 1 Connector
1150 1089 9415 07 2 Contact Block 1085 1088 0031 30 1 Connector
1155 1089 9415 08 1 Contact Block 1090 1088 0031 13 1 Connector
1160 1089 9415 41 1 Contactor 1095 1088 0031 12 1 Connector
1165 1089 9438 04 1 Relay 1100 1089 0612 25 2 Fuse
1170 1089 0362 51 1 Stop Button 1105 1089 0612 01 2 Fuse Holder
1175 1089 0362 58 2 Contact Block 1110 1089 9446 72 1 Relay
1180 1089 9436 08 1 Transformer 1115 1089 9621 06 1 Circuit Breaker
1185 1089 9436 11 1 Transformer 1120 1089 9621 07 2 Circuit Breaker
1190 1089 9407 06 1 Power Supply 1125 1089 9415 02 1 Contact Block
1900 3156 33 380V 60Hz 1130 1089 9415 17 1 Contactor
1900 3156 33 380V 50Hz Oversized motor 1140 1089 9415 78 2 Contactor
1900 3156 33 400V 50Hz Oversized motor 1145 1089 9415 09 3 Contact Block
1010 1079 9906 09 1 Label 1160 1089 9415 58 1 Contactor
1015 9823 1901 11 1 Service diagram 1165 1089 9438 04 1 Relay
1020 1613 6639 00 1 Data Plate 1170 1089 0362 51 1 Stop Button
1025 1088 0031 06 1 Connector 1175 1089 0362 58 2 Contact Block
1030 1088 0031 07 1 Connector 1180 1089 9436 08 1 Transformer
1035 1079 9901 68 1 Label 1185 1089 9436 11 1 Transformer
1040 1089 0506 06 6 Terminal 1190 1089 9407 06 1 Power Supply
1045 1088 0037 31 1 Connector 1900 3156 34 440V 60Hz Oversized motor
1050 1088 0037 35 2 Connector 1010 1079 9906 09 1 Label
1055 1088 0037 30 1 Connector 1015 9823 1901 11 1 Service diagram
1060 1089 0506 27 1 Terminal 1020 1613 6639 00 1 Data Plate
1065 1089 9398 30 3 Terminal 1025 1088 0031 06 1 Connector
1070 1089 9398 11 38 Terminal 1030 1088 0031 07 1 Connector
1075 1088 0031 49 1 Connector 1035 1079 9901 68 1 Label
1080 1088 0031 29 1 Connector 1040 1089 0506 06 6 Terminal
1085 1088 0031 30 1 Connector 1045 1088 0037 31 1 Connector
1090 1088 0031 13 1 Connector 1050 1088 0037 35 2 Connector
1095 1088 0031 12 1 Connector 1055 1088 0037 30 1 Connector
1100 1089 0612 25 2 Fuse 1060 1089 0506 27 1 Terminal

2930 1519 00 123


Parts list

54

70929

124 2930 1519 00


Parts list

Cubicle - IEC High ambient condition, Outdoor version


54

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1065 1089 9398 30 3 Terminal 5015 1088 0037 31 2 Connector


1070 1089 9398 11 38 Terminal 5020 1088 0037 30 1 Connector
1075 1088 0031 49 1 Connector 5022 1088 0031 08 1 Connector
1080 1088 0031 29 1 Connector 5025 1089 9621 05 1 Circuit Breaker
1085 1088 0031 30 1 Connector 1900 3160 14 Option Outdoor version
1090 1088 0031 13 1 Connector 6010 1089 9621 03 1 Circuit Breaker
1095 1088 0031 12 1 Connector 1900 3160 15 Option Winterisation version
1100 1089 0612 25 2 Fuse 7010 1089 0506 27 1 Terminal
1105 1089 0612 01 2 Fuse Holder 7015 1089 9398 11 4 Terminal
1110 1089 9446 71 1 Relay 7020 1088 0031 06 1 Connector
1115 1089 9621 06 1 Circuit Breaker 1900 3160 32 Option Hot air variant
1120 1089 9621 07 2 Circuit Breaker 8005 1088 0031 65 1 Connector
1125 1089 9415 02 1 Contact Block 1900 3160 30 Option Fan
1130 1089 9415 17 1 Contactor 9010 1088 0037 31 1 Connector
1140 1089 9415 60 2 Contactor 9015 1089 0506 27 2 Terminal
1145 1089 9415 09 3 Contact Block 9020 1089 0612 28 3 Fuse
1160 1089 9415 58 1 Contactor 9025 1089 0612 01 3 Fuse Holder
1165 1089 9438 04 1 Relay 9030 1089 9446 55 2 Overload Relay
1170 1089 0362 51 1 Stop Button 9035 1089 9415 21 2 Contactor
1175 1089 0362 58 2 Contact Block 1900 3160 29 Option Low load compensator
1180 1089 9436 08 1 Transformer for IMD
1185 1089 9436 11 1 Transformer 10 010 1088 0037 31 1 Connector
1190 1089 9407 06 1 Power Supply 10 015 1088 0037 30 1 Connector
2005 1621 2232 00 1 Mounting panel 10 020 1089 0506 27 2 Terminal
Label 10 025 1089 0612 28 3 Fuse
No low load 10 030 1089 0612 01 3 Fuse Holder
380V 50Hz 10 035 1089 9446 55 1 Overload Relay
380V 60Hz 10 040 1089 9415 22 1 Contactor
400V 50Hz Option Connection kit
440V 60Hz Contactor Customer side
500V 50Hz High ambient condition
3010 1079 9923 58 1 Label Outdoor version
Low load compensator for IMD 1900 3160 43 380V 60Hz
380V 50Hz 11 010 3 Cu-phase Connection
380V 60Hz 1900 3160 46 Option Purge dry air
400V 50Hz 12 010 1088 0037 31 1 Connector
440V 60Hz 1900 3160 02 Option PT 1000s in the
500V 50Hz windings and bearings
3010 1079 9923 33 1 Label 1900 3160 10 Option High ambient
1900 3160 03 Option Anti-condensation condition
heaters 1900 3160 10 Option Outdoor version
4010 1088 0037 30 1 Connector 1900 3160 13 Option DDP-Filter
Option IMD Dryer 1900 3160 25 Option SPM Monitoring
1900 3160 17 High ambient condition 1900 3160 28 Option Pressure Dew Point
1900 3160 17 Outdoor version 1900 3160 47 Option Winterisation
5010 1088 0037 35 3 Connector Dryer by-pass

2930 1519 00 125


Parts list

55

71176

126 2930 1519 00


Parts list

Cubicle - CSA-UL
55

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1 Control panel 1100 1088 0031 30 1 Connector


1900 3157 02 460V 60Hz 1105 1088 0031 13 1 Connector
1900 3157 02 575V 60Hz Oversized motor 1110 1089 9168 26 2 Fuse
1010 1079 9906 09 1 Label 1115 1089 0612 01 2 Fuse Holder
1015 9823 1901 01 1 Service diagram 1120 1089 9203 31 1 Circuit Breaker
1020 1614 8949 23 1 Data Plate 1125 1089 9446 71 1 Relay
1025 1088 0031 06 1 Connector 1130 1089 9621 09 1 Circuit Breaker
1030 1088 0031 07 1 Connector 1135 1089 9621 07 2 Circuit Breaker
1035 1079 9901 68 1 Label 1140 1089 9415 03 1 Contact Block
1040 1079 9911 01 1 Label 1145 1089 9415 17 1 Contactor
1045 1079 9922 70 1 Fuselabel 1150 1089 9415 04 1 Contact Block
1050 1089 0506 06 6 Terminal 1155 1089 9415 63 2 Contactor
1055 1088 0037 31 1 Connector 1160 1089 9415 09 3 Contact Block
1060 1088 0037 33 2 Connector 1165 1089 9415 61 1 Contactor
1065 1088 0037 30 1 Connector 1170 1089 9438 01 2 Relay
1070 1088 0031 66 2 Connector 1175 1089 0362 51 1 Stop Button
1075 1089 0506 27 1 Terminal 1180 1089 0362 50 1 Contact Block
1080 1089 9398 30 3 Terminal 1185 1089 0362 58 1 Contact Block
1085 1089 9398 11 32 Terminal 1190 1089 9436 07 1 Transformer
1090 1088 0031 49 1 Connector 1195 1089 9436 11 1 Transformer
1095 1088 0031 29 1 Connector 1900 3157 01 575V 60Hz
1100 1088 0031 30 1 Connector 1010 1079 9906 09 1 Label
1105 1088 0031 13 1 Connector 1015 9823 1901 01 1 Service diagram
1110 1089 9168 26 2 Fuse 1020 1614 8949 23 1 Data Plate
1115 1089 0612 01 2 Fuse Holder 1025 1088 0031 06 1 Connector
1120 1089 9203 31 1 Circuit Breaker 1030 1088 0031 07 1 Connector
1125 1089 9446 71 1 Relay 1035 1079 9901 68 1 Label
1130 1089 9621 09 1 Circuit Breaker 1040 1079 9911 01 1 Label
1135 1089 9621 07 2 Circuit Breaker 1045 1079 9922 70 1 Fuselabel
1140 1089 9415 03 1 Contact Block 1050 1089 0506 06 6 Terminal
1145 1089 9415 17 1 Contactor 1055 1088 0037 31 1 Connector
1150 1089 9415 04 1 Contact Block 1060 1088 0037 33 2 Connector
1155 1089 9415 62 2 Contactor 1065 1088 0037 30 1 Connector
1160 1089 9415 09 3 Contact Block 1070 1088 0031 66 2 Connector
1165 1089 9415 61 1 Contactor 1075 1089 0506 27 1 Terminal
1170 1089 9438 01 2 Relay 1080 1089 9398 30 3 Terminal
1175 1089 0362 51 1 Stop Button 1085 1089 9398 11 32 Terminal
1180 1089 0362 50 1 Contact Block 1090 1088 0031 49 1 Connector
1185 1089 0362 58 1 Contact Block 1095 1088 0031 29 1 Connector
1190 1089 9436 07 1 Transformer 1100 1088 0031 30 1 Connector
1195 1089 9436 11 1 Transformer 1105 1088 0031 13 1 Connector
1900 3157 03 460V 60Hz Oversized motor 1110 1089 9168 26 2 Fuse
1010 1079 9906 09 1 Label 1115 1089 0612 01 2 Fuse Holder
1015 9823 1901 01 1 Service diagram 1120 1089 9203 31 1 Circuit Breaker
1020 1614 8949 23 1 Data Plate 1125 1089 9446 71 1 Relay
1025 1088 0031 06 1 Connector 1130 1089 9621 09 1 Circuit Breaker
1030 1088 0031 07 1 Connector 1135 1089 9621 07 2 Circuit Breaker
1035 1079 9901 68 1 Label 1140 1089 9415 03 1 Contact Block
1040 1079 9911 01 1 Label 1145 1089 9415 17 1 Contactor
1045 1079 9922 70 1 Fuselabel 1150 1089 9415 04 1 Contact Block
1050 1089 0506 06 6 Terminal 1155 1089 9415 61 3 Contactor
1055 1088 0037 31 1 Connector 1160 1089 9415 09 3 Contact Block
1060 1088 0037 33 2 Connector 1170 1089 9438 01 2 Relay
1065 1088 0037 30 1 Connector 1175 1089 0362 51 1 Stop Button
1070 1088 0031 66 2 Connector 1180 1089 0362 50 1 Contact Block
1075 1089 0506 27 1 Terminal 1185 1089 0362 58 1 Contact Block
1080 1089 9398 30 3 Terminal 1190 1089 9436 07 1 Transformer
1085 1089 9398 11 32 Terminal 1195 1089 9436 11 1 Transformer
1090 1088 0031 49 1 Connector 2005 1621 2232 00 1 Mounting panel
1095 1088 0031 29 1 Connector

2930 1519 00 127


Parts list

55

71176

128 2930 1519 00


Parts list

Cubicle - CSA-UL
55

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Label 7020 1089 0506 27 2 Terminal


No low load 7025 1089 9168 62 3 Fuse Link
460V 60Hz 7030 1089 0612 01 3 Fuse Holder
575V 60Hz 7035 1089 9446 55 2 Overload Relay
3010 1079 9923 58 1 Label 7040 1089 9415 24 2 Contactor
Low load compensator for IMD 1900 3160 79 Option Low load compensator
460V 60Hz for IMD
575V 60Hz 8010 1079 9924 36 1 Label
3010 1079 9923 33 1 Label 8015 1088 0037 31 1 Connector
1900 3160 03 Option Anti-condensation 8020 1088 0037 30 1 Connector
heaters 8025 1089 0506 27 2 Terminal
4010 1088 0037 30 1 Connector 8030 1089 9168 62 3 Fuse Link
Option IMD Dryer 8035 1089 0612 01 3 Fuse Holder
1900 3160 07 7.5bar(e) 8040 1089 9446 55 1 Overload Relay
1900 3160 07 8.6bar(e) 8045 1089 9415 25 1 Contactor
1900 3160 07 10bar(e) 1900 3160 46 Option Purge dry air
1900 3160 07 10.4bar(e) 9010 1088 0037 31 1 Connector
5010 1088 0037 33 3 Connector 1900 3160 02 Option PT 1000s in the
5015 1088 0037 31 2 Connector windings and bearings
5020 1088 0037 30 1 Connector 1900 3160 10 Option High ambient
5025 1089 9621 05 1 Circuit Breaker condition
5030 1089 9407 06 1 Power Supply 1900 3160 10 Option Outdoor version
1900 3160 32 Option Hot air variant 1900 3160 13 Option DDp filter
6005 1088 0031 65 1 Connector 1900 3160 25 Option SPM Monitoring
1900 3160 80 Option Fan 1900 3160 28 Option Pressure Dew Point
7010 1079 9923 60 1 Label 1900 3160 48 Option Winterisation
7015 1088 0037 31 1 Connector Dryer by-pass

2930 1519 00 129


Parts list

56

71177

130 2930 1519 00


Parts list

Cubicle - CSA-UL - High ambient condition, Outdoor version


56

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1 Control panel 1095 1088 0031 30 1 Connector


1900 3157 32 460V 60Hz 1100 1088 0031 13 1 Connector
1900 3157 32 575V 60Hz Oversized motor 1105 1088 0031 12 1 Connector
1010 1079 9906 09 1 Label 1110 1089 9168 27 2 Fuse
1015 9823 1901 11 1 Service diagram 1115 1089 0612 01 2 Fuse Holder
1020 1614 8949 23 1 Data Plate 1120 1089 9446 71 1 Relay
1025 1088 0031 06 1 Connector 1125 1089 9621 09 1 Circuit Breaker
1030 1088 0031 07 1 Connector 1130 1089 9621 07 2 Circuit Breaker
1035 1079 9901 68 1 Label 1135 1089 9415 02 1 Contact Block
1040 1079 9911 01 1 Label 1140 1089 9415 17 1 Contactor
1045 1079 9922 74 1 Fuselabel 1150 1089 9415 63 2 Contactor
1050 1089 0506 06 6 Terminal 1155 1089 9415 09 3 Contact Block
1055 1088 0037 31 1 Connector 1160 1089 9415 61 1 Contactor
1060 1088 0037 35 2 Connector 1165 1089 9438 01 1 Relay
1065 1088 0037 30 1 Connector 1170 1089 0362 51 1 Stop Button
1070 1089 0506 27 1 Terminal 1175 1089 0362 58 2 Contact Block
1075 1089 9398 30 3 Terminal 1180 1089 9436 08 1 Transformer
1080 1089 9398 11 38 Terminal 1185 1089 9436 11 1 Transformer
1085 1088 0031 49 1 Connector 1190 1089 9407 06 1 Power Supply
1090 1088 0031 29 1 Connector 1900 3157 31 575V 60Hz
1095 1088 0031 30 1 Connector 1010 1079 9906 09 1 Label
1100 1088 0031 13 1 Connector 1015 9823 1901 11 1 Service diagram
1105 1088 0031 12 1 Connector 1020 1614 8949 23 1 Data Plate
1110 1089 9168 27 2 Fuse 1025 1088 0031 06 1 Connector
1115 1089 0612 01 2 Fuse Holder 1030 1088 0031 07 1 Connector
1120 1089 9446 71 1 Relay 1035 1079 9901 68 1 Label
1125 1089 9621 09 1 Circuit Breaker 1040 1079 9911 01 1 Label
1130 1089 9621 07 2 Circuit Breaker 1045 1079 9922 74 1 Fuselabel
1135 1089 9415 02 1 Contact Block 1050 1089 0506 06 6 Terminal
1140 1089 9415 17 1 Contactor 1055 1088 0037 31 1 Connector
1150 1089 9415 62 2 Contactor 1060 1088 0037 35 2 Connector
1155 1089 9415 09 3 Contact Block 1065 1088 0037 30 1 Connector
1160 1089 9415 61 1 Contactor 1070 1089 0506 27 1 Terminal
1165 1089 9438 01 1 Relay 1075 1089 9398 30 3 Terminal
1170 1089 0362 51 1 Stop Button 1080 1089 9398 11 38 Terminal
1175 1089 0362 58 2 Contact Block 1085 1088 0031 49 1 Connector
1180 1089 9436 08 1 Transformer 1090 1088 0031 29 1 Connector
1185 1089 9436 11 1 Transformer 1095 1088 0031 30 1 Connector
1190 1089 9407 06 1 Power Supply 1100 1088 0031 13 1 Connector
1900 3157 33 460V 60Hz Oversized motor 1105 1088 0031 12 1 Connector
1010 1079 9906 09 1 Label 1110 1089 9168 27 2 Fuse
1015 9823 1901 11 1 Service diagram 1115 1089 0612 01 2 Fuse Holder
1020 1614 8949 23 1 Data Plate 1120 1089 9446 71 1 Relay
1025 1088 0031 06 1 Connector 1125 1089 9621 09 1 Circuit Breaker
1030 1088 0031 07 1 Connector 1130 1089 9621 07 2 Circuit Breaker
1035 1079 9901 68 1 Label 1135 1089 9415 02 1 Contact Block
1040 1079 9911 01 1 Label 1140 1089 9415 17 1 Contactor
1045 1079 9922 74 1 Fuselabel 1150 1089 9415 61 3 Contactor
1050 1089 0506 06 6 Terminal 1155 1089 9415 09 3 Contact Block
1055 1088 0037 31 1 Connector 1165 1089 9438 01 1 Relay
1060 1088 0037 35 2 Connector 1170 1089 0362 51 1 Stop Button
1065 1088 0037 30 1 Connector 1175 1089 0362 58 2 Contact Block
1070 1089 0506 27 1 Terminal 1180 1089 9436 08 1 Transformer
1075 1089 9398 30 3 Terminal 1185 1089 9436 11 1 Transformer
1080 1089 9398 11 38 Terminal 1190 1089 9407 06 1 Power Supply
1085 1088 0031 49 1 Connector 2005 1621 2232 00 1 Mounting panel
1090 1088 0031 29 1 Connector

2930 1519 00 131


Parts list

56

71177

132 2930 1519 00


Parts list

Cubicle - CSA-UL - High ambient condition, Outdoor version


56

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Label 9015 1088 0037 31 1 Connector


No low load 9020 1089 0506 27 2 Terminal
460V 60Hz 9025 1089 9168 62 3 Fuse Link
575V 60Hz 9030 1089 0612 01 3 Fuse Holder
3010 1079 9923 58 1 Label 9035 1089 9446 55 2 Overload Relay
Low load compensator for IMD 9040 1089 9415 24 2 Contactor
460V 60Hz 1900 3160 79 Option Low load compensator
575V 60Hz for IMD
3010 1079 9923 33 1 Label 10 010 1079 9924 36 1 Label
1900 3160 03 Option Anti-condensation 10 015 1088 0037 31 1 Connector
heaters 10 020 1088 0037 30 1 Connector
4010 1088 0037 30 1 Connector 10 025 1089 0506 27 2 Terminal
Option IMD Dryer 10 030 1089 9168 62 3 Fuse Link
1900 3160 17 High ambient condition 10 035 1089 0612 01 3 Fuse Holder
1900 3160 17 Outdoor version 10 040 1089 9446 55 1 Overload Relay
5010 1088 0037 35 3 Connector 10 045 1089 9415 25 1 Contactor
5015 1088 0037 31 2 Connector 1900 3160 46 Option Purge dry air
5020 1088 0037 30 1 Connector 11 010 1088 0037 31 1 Connector
5022 1088 0031 08 1 Connector 1900 3160 02 Option PT 1000s in the
5025 1089 9621 05 1 Circuit Breaker windings and bearings
1900 3160 14 Option Outdoor version 1900 3160 10 Option High ambient
6010 1089 9621 03 1 Circuit Breaker condition
1900 3160 15 Option Winterisation version 1900 3160 10 Option Outdoor version
7010 1089 0506 27 1 Terminal 1900 3160 13 Option DDp filter
7015 1089 9398 11 4 Terminal 1900 3160 25 Option SPM Monitoring
7020 1088 0031 06 1 Connector 1900 3160 28 Option Pressure Dew Point
1900 3160 32 Option Hot air variant 1900 3160 48 Option Winterisation
8005 1088 0031 65 1 Connector Dryer by-pass
1900 3160 80 Option Fan
9010 1079 9923 60 1 Label

2930 1519 00 133


Parts list

57

70932

134 2930 1519 00


Parts list

Cubicle - Without motor


57

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1 Control panel 1110 1089 9203 31 1 Circuit Breaker


1900 3156 11 IEC 1120 1089 9621 09 1 Circuit Breaker
1010 1079 9906 09 1 Label 1125 1089 9621 07 2 Circuit Breaker
1015 9823 1901 02 1 Service diagram 1130 1089 9415 03 1 Contact Block
1020 1613 6639 00 1 Data Plate 1135 1089 9415 17 1 Contactor
1025 1088 0031 06 1 Connector 1137 1089 9415 02 1 Contact Block
1030 1088 0031 07 1 Connector 1140 1089 9415 04 1 Contact Block
1035 1079 9901 68 1 Label 1170 1089 9438 01 3 Relay
1040 1089 0506 06 6 Terminal 1175 1089 0362 51 1 Stop Button
1045 1088 0037 31 1 Connector 1180 1089 0362 50 1 Contact Block
1050 1088 0037 33 2 Connector 1185 1089 0362 58 1 Contact Block
1055 1088 0037 30 1 Connector 1190 1089 9436 08 1 Transformer
1060 1088 0031 66 2 Connector 1195 1089 9436 11 1 Transformer
1065 1089 0506 27 1 Terminal 2005 1621 2232 00 1 Mounting panel
1070 1089 9398 30 3 Terminal Label
1075 1089 9398 11 32 Terminal Without main motor
1080 1088 0031 49 1 Connector 3010 1079 9924 55 1 Label
1085 1088 0031 29 1 Connector Without main motor -
1090 1088 0031 30 1 Connector Japanese version
1095 1088 0031 13 1 Connector 3010 1079 9924 25 1 Label
1100 1089 0612 25 2 Fuse Low load compensator for IMD
1105 1089 0612 01 2 Fuse Holder Without main motor
1110 1089 9203 31 1 Circuit Breaker 3010 1079 9924 26 1 Label
1120 1089 9621 06 1 Circuit Breaker Without main motor -
1125 1089 9621 07 2 Circuit Breaker Japanese version
1130 1089 9415 03 1 Contact Block 3010 1079 9924 56 1 Label
1135 1089 9415 17 1 Contactor 1900 3160 03 Option Anti-condensation
1137 1089 9415 02 1 Contact Block heaters
1140 1089 9415 04 1 Contact Block 4010 1088 0037 30 1 Connector
1170 1089 9438 04 3 Relay Option IMD Dryer
1175 1089 0362 51 1 Stop Button 1900 3160 07 7.5bar(e)
1180 1089 0362 50 1 Contact Block 1900 3160 07 8.6bar(e)
1185 1089 0362 58 1 Contact Block 1900 3160 07 10bar(e)
1190 1089 9436 08 1 Transformer 1900 3160 07 10.4bar(e)
1195 1089 9436 11 1 Transformer 5010 1088 0037 33 3 Connector
1900 3157 11 CSA-UL 5015 1088 0037 31 2 Connector
1010 1079 9906 09 1 Label 5020 1088 0037 30 1 Connector
1015 9823 1901 02 1 Service diagram 5025 1089 9621 05 1 Circuit Breaker
1020 1614 8949 23 1 Data Plate 5030 1089 9407 06 1 Power Supply
1025 1088 0031 06 1 Connector 1900 3160 32 Option Hot air variant
1030 1088 0031 07 1 Connector 6005 1088 0031 65 1 Connector
1035 1079 9901 68 1 Label Option Fan
1037 1079 9911 01 1 Label 1900 3160 30 IEC
1038 1079 9922 74 1 Fuselabel 7015 1088 0037 31 1 Connector
1040 1089 0506 06 6 Terminal 7020 1089 0506 27 2 Terminal
1045 1088 0037 31 1 Connector 7025 1089 0612 28 3 Fuse
1050 1088 0037 33 2 Connector 7030 1089 0612 01 3 Fuse Holder
1055 1088 0037 30 1 Connector 7035 1089 9446 55 2 Overload Relay
1060 1088 0031 66 2 Connector 7040 1089 9415 21 2 Contactor
1065 1089 0506 27 1 Terminal 1900 3160 80 CSA-UL
1070 1089 9398 30 3 Terminal 7010 1079 9923 60 1 Label
1075 1089 9398 11 32 Terminal 7015 1088 0037 31 1 Connector
1080 1088 0031 49 1 Connector 7020 1089 0506 27 2 Terminal
1085 1088 0031 29 1 Connector 7025 1089 9168 62 3 Fuse Link
1090 1088 0031 30 1 Connector 7030 1089 0612 01 3 Fuse Holder
1095 1088 0031 13 1 Connector 7035 1089 9446 55 2 Overload Relay
1100 1089 9168 27 2 Fuse 7040 1089 9415 24 2 Contactor
1105 1089 0612 01 2 Fuse Holder

2930 1519 00 135


Parts list

57

70932

136 2930 1519 00


Parts list

Cubicle - Without motor


57

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Option Motorhood 9025 1089 0506 27 2 Terminal


1900 3160 33 380V 50Hz IEC 9030 1089 0612 28 3 Fuse
1900 3160 33 380V 60Hz IEC 9035 1089 0612 01 3 Fuse Holder
1900 3160 33 400V 50Hz IEC 9040 1089 9446 55 1 Overload Relay
1900 3160 33 440V 60Hz IEC 9045 1089 9415 22 1 Contactor
8015 1089 0506 27 1 Terminal 1900 3160 79 CSA-UL
8020 1089 0612 23 3 Fuse 9010 1079 9924 36 1 Label
8025 1089 0612 01 3 Fuse Holder 9015 1088 0037 31 1 Connector
8030 1089 9446 53 1 Relay 9020 1088 0037 30 1 Connector
8035 1089 9415 13 1 Contactor 9025 1089 0506 27 2 Terminal
1900 3160 31 500V 50Hz IEC 9030 1089 9168 62 3 Fuse Link
8015 1089 0506 27 1 Terminal 9035 1089 0612 01 3 Fuse Holder
8020 1089 0612 23 3 Fuse 9040 1089 9446 55 1 Overload Relay
8025 1089 0612 01 3 Fuse Holder 9045 1089 9415 25 1 Contactor
8030 1089 9446 52 1 Relay 1900 3160 46 Option Purge dry air
8035 1089 9415 13 1 Contactor 10 010 1088 0037 31 1 Connector
1900 3160 83 CSA-UL 1900 3160 02 Option PT 1000s in the
8010 1079 9923 61 1 Label windings and bearings
8015 1089 0506 27 1 Terminal 1900 3160 10 Option High ambient
8020 1089 9168 24 3 Fuse condition
8025 1089 0612 01 3 Fuse Holder 1900 3160 10 Option Outdoor version
8030 1089 9446 53 1 Relay 1900 3160 13 Option DDP-Filter
8035 1089 9415 16 1 Contactor 1900 3160 25 Option SPM Monitoring
Option Low load compensator 1900 3160 28 Option Pressure Dew Point
for IMD Option Winterisation
1900 3160 29 IEC Dryer by-pass
9015 1088 0037 31 1 Connector 1900 3160 47 IEC
9020 1088 0037 30 1 Connector 1900 3160 48 CSA-UL

2930 1519 00 137


Parts list

58

70933

138 2930 1519 00


Parts list

Cubicle - Without main motor - High ambient condition, Outdoor version


58

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1 Control panel 1120 1089 9621 09 1 Circuit Breaker


1900 3156 41 IEC - High ambient condition 1125 1089 9621 07 2 Circuit Breaker
1900 3156 41 IEC - Outdoor version 1130 1089 9415 02 1 Contact Block
1010 1079 9906 09 1 Label 1135 1089 9415 17 1 Contactor
1015 9823 1901 12 1 Service diagram 1140 2 Relay
1020 1613 6639 00 1 Data Plate 1145 1089 9415 06 1 Contact Block
1025 1088 0031 06 1 Connector 1150 1089 9438 01 2 Relay
1030 1088 0031 07 1 Connector 1155 1089 0362 51 1 Stop Button
1035 1079 9901 68 1 Label 1160 1089 0362 58 2 Contact Block
1050 1089 0506 06 6 Terminal 1165 1089 9436 09 1 Transformer
1055 1088 0037 31 1 Connector 1170 1089 9436 11 1 Transformer
1060 1088 0037 35 2 Connector 1175 1089 9407 06 1 Power Supply
1065 1088 0037 30 1 Connector 2005 1621 2232 00 1 Mounting panel
1070 1089 0506 27 1 Terminal Label
1075 1089 9398 30 3 Terminal Without main motor
1080 1089 9398 11 38 Terminal 3010 1079 9924 55 1 Label
1085 1088 0031 49 1 Connector Without main motor -
1090 1088 0031 29 1 Connector Japanese version
1095 1088 0031 30 1 Connector 3010 1079 9924 25 1 Label
1100 1088 0031 13 1 Connector Low load compensator for IMD
1105 1088 0031 12 1 Connector Without main motor
1110 1089 0612 25 2 Fuse 3010 1079 9924 26 1 Label
1115 1089 0612 01 2 Fuse Holder Without main motor -
1120 1089 9621 07 1 Circuit Breaker Japanese version
1125 1089 9621 07 2 Circuit Breaker 3010 1079 9924 56 1 Label
1130 1089 9415 02 1 Contact Block 1900 3160 03 Option Anti-condensation
1135 1089 9415 17 1 Contactor heaters
1140 2 Relay 4010 1088 0037 30 1 Connector
1145 1089 9415 06 1 Contact Block Option IMD Dryer
1150 1089 9438 04 2 Relay 1900 3160 17 High ambient condition
1155 1089 0362 51 1 Stop Button 1900 3160 17 Outdoor version
1160 1089 0362 58 2 Contact Block 5010 1088 0037 35 3 Connector
1165 1089 9436 09 1 Transformer 5015 1088 0037 31 2 Connector
1170 1089 9436 11 1 Transformer 5020 1088 0037 30 1 Connector
1175 1089 9407 06 1 Logo Power Supply 5022 1088 0031 08 1 Connector
1900 3157 41 CSA-UL - High ambient 5025 1089 9621 05 1 Circuit Breaker
condition 1900 3160 14 Option Outdoor version
1900 3157 41 CSA-UL - Outdoor version 6010 1089 9621 03 1 Circuit Breaker
1010 1079 9906 09 1 Label 1900 3160 15 Option Winterisation version
1015 9823 1901 12 1 Service diagram 7010 1089 0506 27 1 Terminal
1020 1614 8949 23 1 Data Plate 7015 1089 9398 11 4 Terminal
1025 1088 0031 06 1 Connector 7020 1088 0031 06 1 Connector
1030 1088 0031 07 1 Connector 1900 3160 32 Option Hot air variant
1035 1079 9901 68 1 Label 8005 1088 0031 65 1 Connector
1040 1079 9911 01 1 Label Option Fan
1045 1079 9922 74 1 Fuselabel 1900 3160 30 IEC
1050 1089 0506 06 6 Terminal 9015 1088 0037 31 1 Connector
1055 1088 0037 31 1 Connector 9020 1089 0506 27 2 Terminal
1060 1088 0037 35 2 Connector 9025 1089 0612 28 3 Fuse
1065 1088 0037 30 1 Connector 9030 1089 0612 01 3 Fuse Holder
1070 1089 0506 27 1 Terminal 9035 1089 9446 55 2 Overload Relay
1075 1089 9398 30 3 Terminal 9040 1089 9415 21 2 Contactor
1080 1089 9398 11 38 Terminal 1900 3160 80 CSA-UL
1085 1088 0031 49 1 Connector 9010 1079 9923 60 1 Label
1090 1088 0031 29 1 Connector 9015 1088 0037 31 1 Connector
1095 1088 0031 30 1 Connector 9020 1089 0506 27 2 Terminal
1100 1088 0031 13 1 Connector 9025 1089 9168 62 3 Fuse
1105 1088 0031 12 1 Connector 9030 1089 0612 01 3 Fuse Holder
1110 1089 9168 27 2 Fuse 9035 1089 9446 55 2 Overload Relay
1115 1089 0612 01 2 Fuse Holder 9040 1089 9415 24 2 Contactor

2930 1519 00 139


Parts list

58

70933

140 2930 1519 00


Parts list

Cubicle - Without main motor - High ambient condition, Outdoor version


58

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Option Motorhood 11 025 1089 0506 27 2 Terminal


1900 3160 33 380V 50Hz IEC 11 030 1089 0612 28 3 Fuse
1900 3160 33 380V 60Hz IEC 11 035 1089 0612 01 3 Fuse Holder
1900 3160 33 400V 50Hz IEC 11 040 1089 9446 55 1 Overload Relay
1900 3160 33 440V 60Hz IEC 11 045 1089 9415 22 1 Contactor
10 015 1089 0506 27 1 Terminal 1900 3160 79 CSA-UL
10 020 1089 0612 23 3 Fuse 11 010 1079 9924 36 1 Label
10 025 1089 0612 01 3 Fuse Holder 11 015 1088 0037 31 1 Connector
10 030 1089 9446 53 1 Relay 11 020 1088 0037 30 1 Connector
10 035 1089 9415 13 1 Contactor 11 025 1089 0506 27 2 Terminal
1900 3160 31 500V 50Hz IEC 11 030 1089 9168 62 3 Fuse
10 015 1089 0506 27 1 Terminal 11 035 1089 0612 01 3 Fuse Holder
10 020 1089 0612 23 3 Fuse 11 040 1089 9446 55 1 Overload Relay
10 025 1089 0612 01 3 Fuse Holder 11 045 1089 9415 25 1 Contactor
10 030 1089 9446 52 1 Relay 1900 3160 46 Option Purge dry air
10 035 1089 9415 13 1 Contactor 12 010 1088 0037 31 1 Connector
1900 3160 83 CSA-UL 1900 3160 02 Option PT 1000s in the
10 010 1079 9923 61 1 Label windings and bearings
10 015 1089 0506 27 1 Terminal 1900 3160 10 Option High ambient
10 020 1089 9168 24 3 Fuse condition
10 025 1089 0612 01 3 Fuse Holder 1900 3160 10 Option Outdoor version
10 030 1089 9446 53 1 Relay 1900 3160 13 Option DDP-Filter
10 035 1089 9415 16 1 Contactor 1900 3160 25 Option SPM Monitoring
Option Low load compensator 1900 3160 28 Option Pressure Dew Point
for IMD Option Winterisation
1900 3160 29 IEC Dryer by-pass
11 015 1088 0037 31 1 Connector 1900 3160 47 IEC
11 020 1088 0037 30 1 Connector 1900 3160 48 CSA-UL

2930 1519 00 141


Parts list

59

70934

142 2930 1519 00


Parts list

Bodywork - Cubicle Box


59

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Cubicle box 1090 0160 6105 00 4 Screw


380V 1100 1202 6584 00 AR Seal
400V 1170 0697 9810 24 4 Plug
440V 1180 0697 9809 19 4 Nut
460V 1190 0266 2110 00 2 Hexagon nut
500V 1200 0301 2335 00 4 Washer
575V 1621 4951 80 1 Door assembly
Without main motor - 2005 1 Door
Japanese version 2010 1621 2596 00 1 Handgrip
1621 5815 80 1 Cubicle assembly 2020 0989 4220 07 2 Grommet
1010 1 Cubicle 2030 0111 1313 00 2 Split pin
1040 1621 2547 00 3 Hinge 2040 1619 7704 00 3 Lock
1050 0216 1204 00 6 Screw IEC
1070 1621 0607 00 3 Hinge 3010 1621 1235 00 1 Cable box
1071 0335 3106 00 3 Retaining ring 3020 0697 9810 40 4 Plug
1080 1621 2538 00 2 Hinge 3040 1614 6567 00 1 Seal
1090 0160 6105 00 4 Screw 3050 0147 1322 03 6 Bolt
1100 1202 6584 00 AR Seal 3060 0301 2335 00 6 Washer
1130 0266 2110 00 2 Hexagon nut 3080 1621 1309 00 1 Plate
1140 0301 2335 00 4 Washer 3090 0147 1320 03 2 Bolt
1621 4951 80 1 Door assembly 3100 0301 2335 00 2 Washer
2005 1 Door 3110 1614 6562 00 4 Clamp
2010 1621 2596 00 1 Handgrip 3120 1614 6563 00 4 Clamp
2020 0989 4220 07 2 Grommet 3150 0147 1961 27 8 Bolt
2030 0111 1313 00 2 Split pin 3160 0301 2321 00 8 Washer
2040 1619 7704 00 3 Lock 3170 0266 2108 00 8 Nut
Without main motor CSA-UL
High ambient condition 4010 1614 7146 00 1 Flange
380V 4020 1614 7145 00 1 Gasket
400V 4030 0147 1323 03 6 Bolt
440V 4040 0301 2335 00 12 Washer
460V 4050 0266 2110 00 6 Hexagon nut
500V Fan + Filter
575V Without main motor
Without main motor - 5020 1089 0598 03 2 Filter
Japanese version Without main motor -
Outdoor version Japanese version
380V 5020 1089 0598 06 2 Filter
400V High ambient condition
440V Outdoor version
460V IEC
500V 5010 1089 0598 01 1 Fan
575V 5020 1089 0598 03 1 Filter
1621 5863 80 1 Cubicle assembly CSA-UL
1010 1 Cubicle 5010 1089 0598 02 1 Fan
1040 1621 2547 00 3 Hinge 5020 1089 0598 03 1 Filter
1050 0216 1204 00 6 Screw CSA-UL
1070 1621 0607 00 3 Hinge 6020 1613 5330 10 1 Listing mark
1071 0335 3106 00 3 Retaining ring 6030 1613 3431 00 1 Label
1080 1621 2538 00 2 Hinge

2930 1519 00 143


Parts list

60

70935

144 2930 1519 00


Parts list

Bodywork - Cubicle Box - NEMA


60

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

NEMA4 NEMA4X
1020 1089 0362 28 1 Protect. collar 1020 1089 0362 28 1 Protect. collar
1030 1610 9196 00 1 Gasket 1030 1610 9196 00 1 Gasket
1040 1614 7146 00 1 Flange 1040 1623 0959 00 1 Flange
1050 1614 7145 00 1 Gasket 1050 1614 7145 00 1 Gasket
1060 0147 1323 03 6 Bolt 1060 0147 1323 02 6 Bolt
1070 0301 2335 00 12 Washer 1070 0301 2135 01 12 Washer
1090 1623 0278 00 1 Gasket 1090 1623 0278 00 1 Gasket
1100 0147 1962 65 10 Bolt 1100 0147 1962 65 10 Bolt
1621 5887 80 1 Cubicle 1621 7915 80 1 Cubicle
2010 1 Cubicle 2010 1 Cubicle
2030 1621 0607 00 3 Hinge 2030 1606 4777 00 3 Pin
2040 0335 3106 00 3 Retaining ring 2040 0335 3106 00 3 Retaining ring
1621 5998 80 1 Bodywork door 1621 7916 80 1 Cubicle door
3010 1 Door 3010 1 Door
3020 1610 8900 00 8 Lock 3020 1623 1178 00 8 Lock
3030 1610 8910 00 AR Seal 3030 1610 8910 00 AR Seal
1621 7700 80 1 Assembly 1621 7700 80 1 Assembly
4010 1 Cover 4010 1 Cover
4020 1622 2167 00 AR Seal 4020 1622 2167 00 AR Seal
4030 1606 4754 00 1 Lock 4030 1606 4754 00 1 Lock
4040 1622 2168 00 AR Seal 4040 1622 2168 00 AR Seal
4050 1621 7882 00 1 Screen 4050 1621 7882 00 1 Screen
4060 1621 7883 00 10 Washer 4060 1621 7883 00 10 Washer
4070 0301 2318 00 10 Washer 4070 0301 2318 00 10 Washer
4080 0266 2107 00 10 Nut 4080 0266 2107 00 10 Nut

2930 1519 00 145


Parts list

61

70936

146 2930 1519 00


Parts list

Bodywork - Inlet silencer without Pre-Filter kit


61

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

380V 440V
400V 460V
440V 500V
460V 575V
500V Without main motor
575V Japanese version
Without main motor 1015 0147 1322 03 10 Bolt
Japanese version 1016 0301 2335 00 10 Washer
1015 0147 1322 03 10 Bolt 1017 1621 5384 00 2 Plate
1016 0301 2335 00 10 Washer 1018 1079 1472 05 2 Bolt
1017 1621 5384 00 2 Plate 1020 1619 2766 00 6 Bolt
1018 1079 1472 05 2 Bolt 1023 1619 2766 00 2 Bolt
1020 1619 2766 00 6 Bolt 1026 0300 8019 00 2 Washer
1023 1619 2766 00 2 Bolt 1055 1079 1472 09 4 Bolt
1026 0300 8019 00 2 Washer 1621 6989 80 1 Silencer assembly 1)2)
1055 1079 1472 09 4 Bolt 2010 1 Silencer
1621 6989 80 1 Silencer assembly 1)2) 2040 1621 7022 00 1 Holder
2010 1 Silencer 2060 1621 2554 00 1 Bracket
2040 1621 7022 00 1 Holder 2065 0147 1249 03 2 Bolt
2060 1621 2554 00 1 Bracket 2070 0291 1128 15 2 Nut
2065 0147 1249 03 2 Bolt 2075 0296 1110 03 2 Wing-nut
2070 0291 1128 15 2 Nut 2080 0333 3227 00 2 Lock washer
2075 0296 1110 03 2 Wing-nut 1621 5925 80 1 Roof assembly 1)2)
2080 0333 3227 00 2 Lock washer 3010 1 Roof
1621 5904 80 1 Roof assembly 1)2)
3010 1 Roof 1-2) Lined with / Bekleed met / Bekldd med / Ausgekleidet
3045 1621 5906 00 1 Plate mit /Garnir de / Rivestido de / Allineato con /
3050 1619 2766 00 4 Bolt Foret med / Revestido com / Kledd med / Vuorattu :
Outdoor version 1) Foam: 0395 6001 68(AR) 40 x 2040 x 1650
380V 2) Foam: 0395 6001 69(AR) 50 x 2040 x 1650
400V

2930 1519 00 147


Parts list

62

70937

148 2930 1519 00


Parts list

Bodywork - Inlet silencer for separate air inlet (with Pre-Filter Kit)
62

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Silencer Without main motor


Foot mounted motor Japanese version
Without main motor 1015 0147 1322 03 10 Bolt
1015 0147 1322 03 10 Bolt 1016 0301 2335 00 10 Washer
1016 0301 2335 00 10 Washer 1017 1621 5384 00 2 Plate
1017 1621 5384 00 2 Plate 1018 1079 1472 05 2 Bolt
1018 1079 1472 05 2 Bolt 1020 1619 2766 00 2 Bolt
1020 1619 2766 00 2 Bolt 1030 1621 5858 00 1 Bracket
1030 1621 5858 00 1 Bracket 1035 1619 2766 00 2 Bolt
1035 1619 2766 00 2 Bolt 1040 1079 1472 05 2 Bolt
1040 1079 1472 05 2 Bolt 1055 1079 1472 09 8 Bolt
1055 1079 1472 09 8 Bolt 1070 1621 2589 00 1 Plate
1621 7081 80 1 Silencer assembly 1075 1619 2766 00 6 Bolt
2010 1 Silencer 1621 7081 80 1 Silencer assembly
2060 1621 7140 00 1 Holder 2010 1 Silencer
2080 1621 2554 00 1 Bracket 2060 1621 7140 00 1 Holder
2085 0147 1249 03 2 Bolt 2080 1621 2554 00 1 Bracket
2090 0291 1128 15 2 Nut 2085 0147 1249 03 2 Bolt
2095 0296 1110 03 2 Wing-nut 2090 0291 1128 15 2 Nut
1621 5903 80 1 Roof assembly 2095 0296 1110 03 2 Wing-nut
3010 1 Roof 1621 5903 80 1 Roof assembly
3045 1621 5906 00 1 Plate 3010 1 Roof
3050 1619 2766 00 4 Bolt 3025 1621 4454 00 1 Insulation
Flanged motor Without 3030 1621 4456 00 1 Insulation
main motor 3035 1621 4457 00 1 Insulation
1015 0147 1322 03 10 Bolt 3045 1621 5906 00 1 Plate
1016 0301 2335 00 10 Washer 3050 1619 2766 00 4 Bolt
1017 1621 5384 00 2 Plate Prefilter kit
1018 1079 1472 05 2 Bolt 4010 1621 2593 00 1 Plate
1020 1619 2766 00 2 Bolt 4015 1619 2766 02 8 Bolt
1030 1621 5858 00 1 Bracket 4030 1621 2592 00 2 Bracket
1035 1619 2766 00 2 Bolt 4035 1619 2766 00 8 Bolt
1040 1079 1472 05 2 Bolt 4052 1621 5384 00 4 Plate
1055 1079 1472 09 8 Bolt 4055 0147 1322 03 20 Bolt
1621 7081 80 1 Silencer assembly 1)2) 4060 0301 2335 00 20 Washer
2010 1 Silencer 5030 1621 2244 00 1 Hose
2060 1621 7140 00 1 Holder 5035 0347 6122 00 1 Hose clip
2080 1621 2554 00 1 Bracket 5040 0347 6124 00 2 Hose clip
2085 0147 1249 03 2 Bolt 5045 1621 2696 00 1 Pipe
2090 0291 1128 15 2 Nut 5050 1621 2699 00 1 Pipe
2095 0296 1110 03 2 Wing-nut 1621 5387 81 1 Filter
1621 5903 80 1 Roof assembly 1)2) 6010 1621 1389 00 1 Filter element
3010 1 Roof 6015 1621 2245 00 2 Clamp
3025 1621 4454 00 1 Insulation 1621 5387 80 1 Housing
3030 1621 4456 00 1 Insulation 7005 1621 4883 00 1 Ring
3035 1621 4457 00 1 Insulation 7010 1621 5386 00 1 Manifold
3045 1621 5906 00 1 Plate 7015 1 Housing
3050 1619 2766 00 4 Bolt 7020 1621 5388 00 1 Outlet
380V
400V 1-2) Lined with / Bekleed met / Bekldd med / Ausgekleidet
440V mit /Garnir de / Rivestido de / Allineato con /
460V Foret med / Revestido com / Kledd med / Vuorattu :
500V 1) Foam: 0395 6001 68(AR) 40 x 2040 x 1650
575V 2) Foam: 0395 6001 69(AR) 50 x 2040 x 1650

2930 1519 00 149


Parts list

63

70938

150 2930 1519 00


Parts list

Bodywork - Baffles
63
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

With aftercooler 1060 1079 1472 05 6 Bolt


1 005 1621 2450 80 1 Baffle 1) 1070 1619 2766 00 1 Bolt
1 015 1621 2449 80 1 Baffle 1) 1075 1621 2431 00 1 Support
1 025 1621 2448 80 1 Baffle 1) 1080 1079 1472 05 1 Bolt
1035 1621 2451 00 1 Baffle 1 100 1621 2850 80 1 Baffle 2)
1040 1619 2766 00 4 Bolt 1105 1619 2766 00 1 Bolt
1045 1079 1472 05 6 Bolt 1110 1619 2766 00 3 Bolt
1050 1621 4487 00 1 Plate 1120 1619 2766 00 5 Bolt
1055 1619 2766 00 4 Bolt 1125 1619 2766 00 1 Bolt
1060 1079 1472 05 6 Bolt 1130 1619 2766 00 4 Bolt
1070 1619 2766 00 1 Bolt 1132 1619 5337 01 3 Bolt
1 100 1621 4678 80 1 Baffle 3) 1133 0300 0274 94 3 Plain washer
1105 1619 2766 00 1 Bolt 1135 1621 4318 00 1 Plate
1110 1619 2766 00 3 Bolt 1140 1619 2766 00 2 Bolt
1120 1619 2766 00 5 Bolt 1141 1079 1472 06 2 Bolt
1125 1619 2766 00 1 Bolt 1145 1621 4299 00 2 Profile
1130 1619 2766 00 4 Bolt 1148 1619 2766 00 5 Bolt
1132 1619 5337 01 3 Bolt 1 160 1621 2506 80 1 Profile
1133 0300 0274 94 3 Plain washer 1621 1019 00 AR Seal
1135 1621 4318 00 1 Plate 1165 1079 1472 05 3 Bolt
1140 1619 2766 00 2 Bolt 1 170 1621 2505 80 1 Profile
1141 1079 1472 06 2 Bolt 1619 2473 00 AR Seal
1145 1621 4299 00 2 Profile 1175 1079 1472 05 3 Bolt
1147 1619 5337 01 4 Bolt 1 180 1621 4732 80 4 Panel
1148 1619 2766 00 1 Bolt 1621 1019 00 AR Seal
1 160 1621 2506 80 1 Profile 1185 1619 2766 00 24 Bolt
1621 1019 00 AR Seal 1 190 1621 5320 80 1 Panel
1165 1079 1472 05 3 Bolt 1619 2473 00 AR Seal
1 170 1621 2505 80 1 Profile 0698 0153 00 6 Rubber ring
1619 2473 00 AR Seal 1088 0803 26 1 Grommet
1175 1079 1472 05 3 Bolt 1195 1619 2766 00 6 Bolt
1 180 1621 4732 80 4 Panel 1200 1621 4301 00 1 Plate
1621 1019 00 AR Seal 1205 1619 2766 00 8 Bolt
1185 1619 2766 00 24 Bolt 1210 1621 2446 00 1 Plate
1 190 1621 5320 80 1 Panel 1214 1619 2766 00 3 Bolt
1619 2473 00 AR Seal 1 220 1621 4157 80 1 Baffle 3)
0698 0153 00 6 Rubber ring 1615 7884 00 6 Clip
1088 0803 26 1 Grommet 1225 1619 2766 00 1 Bolt
1195 1619 2766 00 6 Bolt 1 230 1621 2395 80 4 Baffle 2)
1200 1621 4301 00 1 Plate 1615 7884 00 6 Clip
1205 1619 2766 00 8 Bolt 1235 1619 2766 00 4 Bolt
1210 1621 2446 00 1 Plate 1240 1619 2766 00 4 Bolt
1214 1619 2766 00 3 Bolt 1621 2812 80 1 Baffle 2)
1 220 1621 4157 80 1 Baffle 3) 2005 1 Baffle
1615 7884 00 6 Clip 2020 1621 2600 00 1 Plate
1225 1619 2766 00 1 Bolt 2025 1621 2815 00 1 Bracket
1 230 1621 2395 80 4 Baffle 2) 2030 1079 1472 05 6 Bolt
1615 7884 00 6 Clip Tropicalised integrated dryer
1235 1619 2766 00 4 Bolt With aftercooler
1240 1619 2766 00 4 Bolt 1 005 1621 2450 80 1 Baffle 1)
1621 2812 80 1 Baffle 2) 1 015 1621 2449 80 1 Baffle 1)
2005 1 Baffle 1 025 1621 2448 80 1 Baffle 1)
2020 1621 2600 00 1 Plate 1035 1621 2451 00 1 Baffle
2025 1621 2815 00 1 Bracket 1040 1619 2766 00 4 Bolt
2030 1079 1472 05 6 Bolt 1045 1079 1472 05 6 Bolt
Hot air variant 1050 1621 4487 00 1 Plate
1 005 1621 2450 80 1 Baffle 1) 1055 1619 2766 00 4 Bolt
1 015 1621 2449 80 1 Baffle 1) 1060 1079 1472 05 6 Bolt
1 025 1621 2448 80 1 Baffle 1) 1070 1619 2766 00 1 Bolt
1035 1621 2451 00 1 Baffle 1 100 1621 4678 80 1 Baffle 3)
1040 1619 2766 00 4 Bolt 1105 1619 2766 00 1 Bolt
1045 1079 1472 05 6 Bolt 1110 1619 2766 00 3 Bolt
1050 1621 4487 00 1 Plate 1120 1619 2766 00 5 Bolt
1055 1619 2766 00 4 Bolt 1125 1619 2766 00 1 Bolt

2930 1519 00 151


Parts list

63

70938

152 2930 1519 00


Parts list

Bodywork - Baffles
63
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1130 1619 2766 00 4 Bolt 1 160 1621 2506 80 1 Profile


1132 1619 5337 01 3 Bolt 1621 1019 00 AR Seal
1133 0300 0274 94 3 Plain washer 1165 1079 1472 05 3 Bolt
1135 1621 4318 00 1 Plate 1 170 1621 2505 80 1 Profile
1140 1619 2766 00 2 Bolt 1619 2473 00 AR Seal
1141 1079 1472 06 2 Bolt 1175 1079 1472 05 3 Bolt
1145 1621 4299 00 2 Profile 1186 1621 4217 00 2 Plate
1147 1619 5337 01 4 Bolt 1187 1079 1472 05 2 Bolt
1148 1619 2766 00 1 Bolt 1188 0989 4220 10 5 Grommet
1 160 1621 2506 80 1 Profile 1 190 1621 5320 80 1 Panel
1621 1019 00 AR Seal 1619 2473 00 AR Seal
1165 1079 1472 05 3 Bolt 0698 0153 00 6 Rubber ring
1 170 1621 2505 80 1 Profile 1088 0803 26 1 Grommet
010 1619 2473 00 AR Seal 1191 1621 7698 00 1 Plate
1175 1079 1472 05 3 Bolt 1192 1079 1472 05 2 Bolt
1 180 1621 4732 80 4 Panel 1193 1621 7699 00 1 Plate
1621 1019 00 AR Seal 1194 1079 1472 05 2 Bolt
1185 1619 2766 00 24 Bolt 1195 1619 2766 00 4 Bolt
1 190 1621 5320 80 1 Panel 1196 0147 1323 03 2 Bolt
1619 2473 00 AR Seal 1197 0261 2110 00 2 Hexagon nut
0698 0153 00 6 Rubber ring 1198 0301 2335 00 4 Washer
1088 0803 26 1 Grommet 1200 1621 4301 00 1 Plate
1195 1619 2766 00 6 Bolt 1205 1619 2766 00 8 Bolt
1200 1621 4368 00 1 Plate 1210 1621 2446 00 1 Plate
1205 1619 2766 00 8 Bolt 1214 1619 2766 00 3 Bolt
1210 1621 2446 00 1 Plate 1 220 1621 4157 80 1 Baffle 3)
1214 1619 2766 00 3 Bolt 1615 7884 00 6 Clip
1 220 1621 4157 80 1 Baffle 3) 1225 1619 2766 00 1 Bolt
1225 1619 2766 00 1 Bolt 1621 2812 80 1 Baffle 2)
1 230 1621 2395 80 4 Baffle 2) 2005 1 Baffle
1615 7884 00 6 Clip 2020 1621 2600 00 1 Plate
1235 1619 2766 00 4 Bolt 2025 1621 2815 00 1 Bracket
1240 1619 2766 00 4 Bolt 2030 1079 1472 05 6 Bolt
1621 2812 80 1 Baffle 2) Pack Hot air variant
2005 1 Baffle 1 005 1621 2450 80 1 Baffle 1)
2020 1621 2600 00 1 Plate 1 015 1621 2449 80 1 Baffle 1)
2025 1621 2815 00 1 Bracket 1 025 1621 2448 80 1 Baffle 1)
2030 1079 1472 05 6 Bolt 1035 1621 2451 00 1 Baffle
Outdoor version 1040 1619 2766 00 4 Bolt
With aftercooler 1045 1079 1472 05 6 Bolt
1 005 1621 2450 80 1 Baffle 1) 1050 1621 4487 00 1 Plate
1 015 1621 2449 80 1 Baffle 1) 1055 1619 2766 00 4 Bolt
1 025 1621 2448 80 1 Baffle 1) 1060 1079 1472 05 6 Bolt
1035 1621 2451 00 1 Baffle 1070 1619 2766 00 1 Bolt
1040 1619 2766 00 4 Bolt 1 100 1621 2850 80 1 Baffle 2)
1045 1079 1472 05 6 Bolt 1105 1619 2766 00 1 Bolt
1050 1621 4487 00 1 Plate 1110 1619 2766 00 3 Bolt
1055 1619 2766 00 4 Bolt 1120 1619 2766 00 5 Bolt
1060 1079 1472 05 6 Bolt 1125 1619 2766 00 1 Bolt
1070 1619 2766 00 1 Bolt 1130 1619 2766 00 4 Bolt
1 100 1621 4678 80 1 Baffle 3) 1132 1619 5337 01 3 Bolt
1105 1619 2766 00 1 Bolt 1133 0300 0274 94 3 Plain washer
1110 1619 2766 00 3 Bolt 1135 1621 4318 00 1 Plate
1120 1619 2766 00 5 Bolt 1140 1619 2766 00 2 Bolt
1125 1619 2766 00 1 Bolt 1141 1079 1472 06 2 Bolt
1130 1619 2766 00 4 Bolt 1145 1621 4299 00 2 Profile
1132 1619 5337 01 3 Bolt 1147 1619 5337 01 4 Bolt
1133 0300 0274 94 3 Plain washer 1148 1619 2766 00 1 Bolt
1135 1621 4318 00 1 Plate 1 160 1621 2506 80 1 Profile
1140 1619 2766 00 2 Bolt 1621 1019 00 AR Seal
1141 1079 1472 06 2 Bolt 1165 1079 1472 05 3 Bolt
1145 1621 4299 00 2 Profile 1 170 1621 2505 80 1 Profile
1147 1619 5337 01 4 Bolt 1619 2473 00 AR Seal
1148 1619 2766 00 1 Bolt 1175 1079 1472 05 3 Bolt

2930 1519 00 153


Parts list

63

70938

154 2930 1519 00


Parts list

Bodywork - Baffles
63
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1186 1621 4217 00 2 Plate 1186 1621 4217 00 2 Plate


1187 1079 1472 05 2 Bolt 1187 1079 1472 05 2 Bolt
1188 0989 4220 10 2 Grommet 1188 0989 4220 10 2 Grommet
1189 1088 0803 08 3 Grommet 1189 1088 0803 08 3 Grommet
1 190 1621 5320 80 1 Panel 1 190 1621 7695 80 1 Panel
1619 2473 00 AR Seal 1621 1019 00 AR Seal
0698 0153 00 6 Rubber ring 1088 0803 26 2 Grommet
1088 0803 26 1 Grommet 1191 1621 7698 00 1 Plate
1191 1621 7698 00 1 Plate 1192 1079 1472 05 2 Bolt
1192 1079 1472 05 2 Bolt 1193 1621 7699 00 1 Plate
1193 1621 7699 00 1 Plate 1194 1079 1472 05 2 Bolt
1194 1079 1472 05 2 Bolt 1195 1619 2766 00 4 Bolt
1195 1619 2766 00 4 Bolt 1196 0147 1323 03 2 Bolt
1196 0147 1323 03 2 Bolt 1197 0261 2110 00 2 Hexagon nut
1197 0261 2110 00 2 Hexagon nut 1198 0301 2335 00 4 Washer
1198 0301 2335 00 4 Washer 1200 1621 4301 00 1 Plate
1200 1621 4301 00 1 Plate 1205 1619 2766 00 8 Bolt
1205 1619 2766 00 8 Bolt 1210 1621 2446 00 1 Plate
1210 1621 2446 00 1 Plate 1214 1619 2766 00 3 Bolt
1214 1619 2766 00 3 Bolt 1 220 1621 4157 80 1 Baffle 3)
1 220 1621 4157 80 1 Baffle 3) 1615 7884 00 6 Clip
1615 7884 00 6 Clip 1225 1619 2766 00 1 Bolt
1225 1619 2766 00 1 Bolt 1621 2812 80 1 Baffle 2)
1621 2812 80 1 Baffle 2) 2005 1 Baffle
2005 1 Baffle 2020 1621 2600 00 1 Plate
2020 1621 2600 00 1 Plate 2025 1621 2815 00 1 Bracket
2025 1621 2815 00 1 Bracket 2030 1079 1472 05 6 Bolt
2030 1079 1472 05 6 Bolt Full Feature with aftercooler
Winterisation Outdoor 1 005 1621 2450 80 1 Baffle 1)
version 1 015 1621 2449 80 1 Baffle 1)
Pack with aftercooler 1 025 1621 2448 80 1 Baffle 1)
1 005 1621 2450 80 1 Baffle 1) 1035 1621 2451 00 1 Baffle
1 015 1621 2449 80 1 Baffle 1) 1040 1619 2766 00 4 Bolt
1 025 1621 2448 80 1 Baffle 1) 1045 1079 1472 05 6 Bolt
1035 1621 2451 00 1 Baffle 1050 1621 4487 00 1 Plate
1040 1619 2766 00 4 Bolt 1055 1619 2766 00 4 Bolt
1045 1079 1472 05 6 Bolt 1060 1079 1472 05 6 Bolt
1050 1621 4487 00 1 Plate 1070 1619 2766 00 1 Bolt
1055 1619 2766 00 4 Bolt 1 100 1621 4678 80 1 Baffle 3)
1060 1079 1472 05 6 Bolt 1102 0989 4220 10 2 Grommet
1070 1619 2766 00 1 Bolt 1105 1619 2766 00 1 Bolt
1 100 1621 4678 80 1 Baffle 3) 1110 1619 2766 00 3 Bolt
1102 0989 4220 10 2 Grommet 1120 1619 2766 00 5 Bolt
1105 1619 2766 00 1 Bolt 1125 1619 2766 00 1 Bolt
1110 1619 2766 00 3 Bolt 1130 1619 2766 00 4 Bolt
1120 1619 2766 00 5 Bolt 1132 1619 5337 01 3 Bolt
1125 1619 2766 00 1 Bolt 1133 0300 0274 94 3 Plain washer
1130 1619 2766 00 4 Bolt 1135 1621 4318 00 1 Plate
1132 1619 5337 01 3 Bolt 1140 1619 2766 00 2 Bolt
1133 0300 0274 94 3 Plain washer 1141 1079 1472 06 2 Bolt
1135 1621 4318 00 1 Plate 1145 1621 4299 00 2 Profile
1140 1619 2766 00 2 Bolt 1147 1619 5337 01 4 Bolt
1141 1079 1472 06 2 Bolt 1148 1619 2766 00 1 Bolt
1145 1621 4299 00 2 Profile 1 160 1621 2506 80 1 Profile
1147 1619 5337 01 4 Bolt 1621 1019 00 AR Seal
1148 1619 2766 00 1 Bolt 1165 1079 1472 05 3 Bolt
1 160 1621 2506 80 1 Profile 1 170 1621 2505 80 1 Profile
1621 1019 00 AR Seal 1619 2473 00 AR Seal
1165 1079 1472 05 3 Bolt 1175 1079 1472 05 3 Bolt
1 170 1621 2505 80 1 Profile 1186 1621 4217 00 2 Plate
1619 2473 00 AR Seal 1187 1079 1472 05 2 Bolt
1175 1079 1472 05 3 Bolt 1188 0989 4220 10 5 Grommet

2930 1519 00 155


Parts list

63

70938

156 2930 1519 00


Parts list

Bodywork - Baffles
63

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1 190 1621 7695 80 1 Panel 1623 0271 80 1 Baffle


1621 1019 00 AR Seal 2005 1 Baffle
1088 0803 26 2 Grommet 2010 1623 0283 00 AR Insulation
1191 1621 7698 00 1 Plate 2015 1623 0284 00 AR Insulation
1192 1079 1472 05 2 Bolt 2020 1621 2600 00 1 Plate
1193 1621 7699 00 1 Plate 2025 1621 2815 00 1 Bracket
1194 1079 1472 05 2 Bolt 2030 1079 1472 05 6 Bolt
1195 1619 2766 00 4 Bolt 2040 1623 0303 00 1 Plate
1196 0147 1323 03 2 Bolt 2045 1079 1472 05 4 Bolt
1197 0261 2110 00 2 Hexagon nut 2050 0160 6065 00 4 Screw
1198 0301 2335 00 4 Washer
1200 1621 4301 00 1 Plate 1-2) Lined with / Bekleed met / Bekldd med / Ausgekleidet
1205 1619 2766 00 8 Bolt mit / Garnir de / Rivestido de / Allineato con /
1210 1621 2446 00 1 Plate Foret med / Revestido com / Kledd med / Vuorattu :
1214 1619 2766 00 3 Bolt 1) Foam: 0395 6001 67(AR) 30 x 2040 x 1650
1 220 1621 4157 80 1 Baffle 3) 2) Foam: 0395 6001 69(AR) 50 x 2040 x 1650
1615 7884 00 6 Clip 3) Foam: 0395 6001 68(AR) 40 x 2040 x 1650
1225 1619 2766 00 1 Bolt

2930 1519 00 157


Parts list

64

70939

158 2930 1519 00


Parts list

Bodywork - Baffles - Arr. E


64
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

IEC 1035 1619 2766 00 2 Bolt


1005 1621 5829 00 1 Plate 1 040 1621 2819 80 1 Panel
1010 1619 2766 00 6 Bolt 1045 1619 2766 00 2 Bolt
1 015 1621 2463 80 1 Panel 1) 1050 1079 1472 05 2 Bolt
1623 0320 00 AR Insulation 1 055 1621 2540 80 1 Baffle
1619 2473 00 AR Seal 1619 2473 00 AR Seal
1020 1619 2766 00 3 Bolt 1619 2665 00 AR Seal
1 025 1621 2462 80 1 Panel 1) 1057 1079 1472 05 6 Bolt
1030 1079 1472 05 5 Bolt 1059 0300 0274 94 6 Plain washer
1035 1619 2766 00 2 Bolt 1065 0147 1552 03 8 Bolt
1 040 1621 2819 80 1 Panel 1) 1070 0266 2116 00 8 Nut
1045 1619 2766 00 2 Bolt 1085 1621 2431 00 1 Support
1050 1079 1472 05 2 Bolt 1090 1079 1472 05 1 Bolt
1 055 1621 2539 80 1 Baffle 1 095 1621 4319 80 1 Baffle
1619 2473 00 AR Seal 1100 1619 2766 00 1 Bolt
1619 2665 00 AR Seal 1110 1079 1472 05 1 Bolt
1057 1079 1472 05 6 Bolt 1115 1088 1001 04 1 Warning mark
1059 0300 0274 94 6 Plain washer CSA-UL High ambient
1065 0147 1554 03 8 Bolt condition
1070 0266 2116 00 8 Nut Oversized motor CSA-UL
1085 1621 2431 00 1 Support 1005 1621 5829 00 1 Plate
1090 1079 1472 05 1 Bolt 1010 1619 2766 00 6 Bolt
1 095 1621 4319 80 1 Baffle 1) 1 015 1621 2463 80 1 Panel
1100 1619 2766 00 1 Bolt 1623 0320 00 AR Insulation
1110 1079 1472 05 1 Bolt 1619 2473 00 AR Seal
1115 1088 1001 04 1 Warning mark 1020 1619 2766 00 3 Bolt
IEC High ambient condition 1 025 1621 2462 80 1 Panel 1)
Oversized motor IEC 1030 1079 1472 05 5 Bolt
1005 1621 5829 00 1 Plate 1035 1619 2766 00 2 Bolt
1010 1619 2766 00 6 Bolt 1045 1619 2766 00 2 Bolt
1 015 1621 2463 80 1 Panel 1) 1050 1079 1472 05 7 Bolt
1623 0320 00 AR Insulation 1085 1621 2431 00 1 Support
1619 2473 00 AR Seal 1090 1079 1472 05 1 Bolt
1020 1619 2766 00 3 Bolt 1 095 1621 4319 80 1 Baffle
1 025 1621 2462 80 1 Panel 1) 1100 1619 2766 00 1 Bolt
1030 1079 1472 05 5 Bolt 1110 1079 1472 05 1 Bolt
1035 1619 2766 00 2 Bolt 1115 1088 1001 04 1 Warning mark
1045 1619 2766 00 2 Bolt 1623 0080 80 1 Baffle
1050 1079 1472 05 7 Bolt 2005 1 Baffle
1055 0147 1554 03 8 Bolt 2015 1619 2473 00 AR Seal
1060 0266 2116 00 8 Nut 2020 1621 2661 00 1 Plate
1085 1621 2431 00 1 Support 2025 1615 5664 00 4 Hex. head screw
1090 1079 1472 05 1 Bolt Japanese version
1 095 1621 4319 80 1 Baffle 1) 1005 1621 5829 00 1 Plate
1100 1619 2766 00 1 Bolt 1010 1619 2766 00 6 Bolt
1110 1079 1472 05 1 Bolt 1 015 1621 2463 80 1 Panel 1)
1115 1088 1001 04 1 Warning mark 1623 0320 00 1 Insulation
1623 0079 80 1 Baffle 1) 1619 2473 00 18 Seal
2005 1 Baffle 1020 1619 2766 00 3 Bolt
2015 1619 2473 00 AR Seal 1 025 1621 2462 80 1 Panel 1)
2020 1621 4853 00 1 Plate 1030 1079 1472 05 5 Bolt
2025 1615 5664 00 4 Hex. head screw 1035 1619 2766 00 2 Bolt
CSA-UL 1 040 1621 2819 80 1 Panel 1)
1005 1621 5829 00 1 Plate 1045 1619 2766 00 2 Bolt
1007 1619 2473 00 AR Seal 1050 1079 1472 05 5 Bolt
1010 1619 2766 00 6 Bolt 1 055 1621 2501 80 1 Baffle
1 015 1621 2463 80 1 Panel 1619 2473 00 AR Seal
1623 0320 00 AR Insulation 1619 2665 00 AR Seal
1619 2473 00 AR Seal 1060 1079 1472 05 6 Bolt
1020 1619 2766 00 3 Bolt 1062 0300 0274 94 6 Plain washer
1 025 1621 2462 80 1 Panel 1065 0147 1477 03 8 Bolt
1030 1079 1472 05 5 Bolt 1085 1621 2431 00 1 Support

2930 1519 00 159


Parts list

64

70939

160 2930 1519 00


Parts list

Bodywork - Baffles - Arr. E


64

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1090 1079 1472 05 1 Bolt CSA-UL


1 095 1621 4319 80 1 Baffle 1) 1005 1621 5829 00 1 Plate
1100 1619 2766 00 1 Bolt 1010 1619 2766 00 6 Bolt
1110 1079 1472 05 1 Bolt 1 015 1621 2463 80 1 Panel 1)
Outdoor version 1623 0320 00 AR Insulation
IEC 1619 2473 00 AR Seal
1005 1621 5829 00 1 Plate 1020 1619 2766 00 3 Bolt
1010 1619 2766 00 6 Bolt 1 025 1621 2462 81 1 Panel 1)
1 015 1621 2463 80 1 Panel 1) 1619 2473 00 AR Seal
1623 0320 00 AR Insulation 1619 5188 00 AR Seal
1619 2473 00 AR Seal 1030 1079 1472 05 5 Bolt
1020 1619 2766 00 3 Bolt 1035 1619 2766 00 2 Bolt
1 025 1621 2462 81 1 Panel 1) 1045 1619 2766 00 2 Bolt
1619 2473 00 AR Seal 1050 1079 1472 05 7 Bolt
1619 5188 00 AR Seal 1055 0147 1552 03 8 Bolt
1030 1079 1472 05 5 Bolt 1060 0266 2116 00 8 Nut
1035 1619 2766 00 2 Bolt 1115 1088 1001 04 1 Warning mark
1045 1619 2766 00 2 Bolt 1120 1621 5852 00 2 Profile
1055 0147 1554 03 8 Bolt 1125 1619 2766 00 2 Bolt
1060 0266 2116 00 8 Nut 1623 0080 80 1 Baffle 1)
1115 1088 1001 04 1 Warning mark 2005 1 Baffle
1120 1621 5852 00 2 Profile 2015 1619 2473 00 AR Seal
1125 1619 2766 00 2 Bolt 2020 1621 2661 00 1 Plate
1623 0079 80 1 Baffle 1) 2025 1615 5664 00 4 Hex. head screw
2005 1 Baffle
2015 1619 2473 00 AR Seal 1) Lined with / Bekleed met / Bekldd med / Ausgekleidet
2020 1621 4853 00 1 Plate mit /Garnir de / Rivestido de / Allineato con /
2025 1615 5664 00 4 Hex. head screw Foret med / Revestido com / Kledd med / Vuorattu :
1) Foam: 0395 6001 69(AR) 50 x 2040 x 1650

2930 1519 00 161


Parts list

65

70940

162 2930 1519 00


Parts list

Bodywork - Baffles - With motorhood without motor


65

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1005 1621 4338 00 1 Grating 1130 1621 5134 00 2 Profile


1010 1619 2766 00 2 Bolt 1135 1619 2766 00 4 Bolt
1011 1619 2766 00 4 Bolt 1140 1619 2766 00 2 Bolt
1015 1621 2836 00 1 Panel 1145 1621 2835 00 1 Panel
1020 1619 2766 00 3 Bolt 1150 1619 2766 00 2 Bolt
1025 1621 2837 00 1 Panel Fan
1031 1079 1472 05 5 Bolt 50Hz
1035 1621 2838 00 1 Panel 2010 1619 5294 00 1 Fan
1040 1619 2766 00 3 Bolt 2020 0147 1323 03 1 Bolt
1045 1619 2766 00 3 Bolt 2030 0300 0274 94 1 Plain washer
1050 1621 4343 00 1 Panel 2060 0697 9809 02 1 Nut
1055 1619 2766 00 3 Bolt 60Hz
1060 1619 2766 00 2 Bolt 2010 1619 5295 00 1 Fan
1065 1621 3450 00 1 Support 2020 0147 1323 03 1 Bolt
1070 0147 1247 03 4 Bolt 2030 0300 0274 94 1 Plain washer
1075 0301 2321 00 4 Washer 2060 0697 9809 02 1 Nut
1080 0266 2108 00 1 Nut Fan motor
1085 2252 1360 00 2 Bracket 3137 1 Motor
1090 0147 1323 03 4 Bolt 1080 2662 11 380V 50Hz IEC
1095 0301 2335 00 4 Washer 1080 2663 20 380V 60Hz IEC
1100 0266 2110 00 4 Hexagon nut 1080 2662 11 400V 50Hz IEC
1105 1619 2766 00 4 Bolt 1080 2663 19 440V 60Hz IEC
1 1201621 4720 80 1 Duct 1080 2663 19 460V 60Hz CSA-UL
1621 2549 00 1 Clip 1080 2662 14 500V 50Hz IEC
1125 1619 2766 00 4 Bolt 1080 2663 18 575V 60Hz CSA-UL
1127 1619 2766 00 2 Bolt

2930 1519 00 163


Parts list

66

71178

164 2930 1519 00


Parts list

Bodywork - Doors and stays


66
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Frame 2 240 1621 2515 80 1 Stay


1005 1621 1392 00 1 Frame 1621 2549 00 8 Clip
Panels and stays 2245 1619 2766 00 2 Bolt
2005 1621 2473 00 3 Stay 2 250 1621 2516 80 1 Stay
2006 1621 2473 00 1 Stay 1621 2549 00 8 Clip
2010 1621 2538 00 4 Hinge 2255 1619 2766 00 2 Bolt
2015 0147 1320 03 8 Bolt 1621 2470 80 1 Panel
2020 1619 2766 00 8 Bolt 3005 1 Panel
2025 1621 2868 00 2 Stay 3007 0301 2335 00 8 Washer
2026 1621 2868 00 2 Stay 3010 1621 2538 00 4 Hinge
2027 1621 2701 00 2 Plate 3015 0147 1320 03 8 Bolt
2029 0301 2335 00 8 Washer 1621 2472 80 1 Panel
2030 1621 2538 00 4 Hinge 4005 1 Panel
2035 0147 1320 03 8 Bolt 4007 0301 2335 00 8 Washer
2040 1619 2766 00 8 Bolt 4010 1621 2538 00 4 Hinge
2047 1621 2702 00 1 Plate 4015 0147 1320 03 8 Bolt
2050 0301 2358 00 2 Washer 1621 5317 80 1 Panel
2055 0147 1400 03 2 Bolt 5010 1 Panel
2065 0301 2358 00 2 Washer 5020 1621 2550 00 4 Pin
2070 0147 1400 03 2 Bolt 5030 0581 0000 86 6 Pipe coupling
2 075 1621 2477 80 1 Stay Outdoor version
1621 2549 00 8 Clip 2005 1621 2473 00 3 Stay
2080 1621 2538 00 2 Hinge 2006 1621 2473 00 1 Stay
2085 0147 1320 03 4 Bolt 2010 1621 2538 00 4 Hinge
2090 1619 2766 00 2 Bolt 2015 0147 1320 03 8 Bolt
2 095 1621 2478 80 1 Stay 2020 1619 2766 00 8 Bolt
1621 2549 00 8 Clip 2025 1621 2868 00 2 Stay
2100 1621 2538 00 2 Hinge 2026 1621 2868 00 2 Stay
2105 0147 1320 03 4 Bolt 2027 1621 2701 00 2 Plate
2110 1619 2766 00 2 Bolt 2040 1619 2766 00 8 Bolt
2115 1621 4472 00 1 Panel 2047 1621 2702 00 1 Plate
2120 1619 2766 00 4 Bolt 2050 0301 2358 00 2 Washer
2125 1621 2513 00 4 Beam 2055 0147 1400 03 2 Bolt
2127 1621 2632 00 2 Plate 2065 0301 2358 00 2 Washer
2129 1619 2766 00 4 Bolt 2070 0147 1400 03 2 Bolt
2130 1621 2514 00 2 Beam 2 075 1621 2477 80 1 Stay
2135 1619 2766 00 25 Bolt 1621 2549 00 8 Clip
2138 1079 1472 05 1 Bolt 2080 1621 2538 00 2 Hinge
2 145 1621 2519 80 1 Panel 1) 2085 0147 1320 03 4 Bolt
1621 2550 00 4 Pin 2090 1619 2766 00 2 Bolt
2 150 1621 2520 80 1 Panel 2 095 1621 2478 80 1 Stay
1621 2550 00 4 Pin 1621 2549 00 8 Clip
2 155 1621 2522 80 1 Panel 1) 2100 1621 2538 00 2 Hinge
1621 2550 00 4 Pin 2105 0147 1320 03 4 Bolt
2 160 1621 2475 80 1 Panel 1) 2110 1619 2766 00 2 Bolt
1621 2550 00 6 Pin 2115 1621 4472 00 1 Panel
2 165 1621 2465 80 2 End panel 2) 2120 1619 2766 00 4 Bolt
1621 2550 00 4 Pin 2123 1621 2513 00 2 Beam
2 170 1621 2476 80 1 Panel 2) 2125 1621 7686 00 2 Profile
1621 2550 00 4 Pin 2126 1621 2387 00 2 Silencing foam
2 175 1621 2517 80 2 Panel 2) 2127 1621 2632 00 2 Plate
2178 1619 2766 00 8 Bolt 2129 1619 2766 00 4 Bolt
2 180 1621 2469 80 1 Roof 3) 2130 1621 2514 00 2 Beam
2185 1619 2766 02 4 Bolt 2135 1619 2766 00 25 Bolt
2 190 1621 2512 80 1 Roof 3) 2138 1079 1472 05 1 Bolt
2195 1619 2766 02 4 Bolt 2 140 1621 5619 80 1 Panel
2 200 1621 2468 80 1 Roof 3) 0581 0000 86 1 Pipe coupling
2205 1619 2766 02 4 Bolt 2141 1619 2766 00 4 Bolt
2 210 1621 2474 80 1 Panel 2) 2145 1621 5726 00 2 Panel
2215 1619 2766 02 6 Bolt 2146 1619 2766 00 8 Bolt
2217 1621 5747 00 4 Profile 2 175 1621 2517 80 2 Panel 1)
2220 1621 5748 00 4 Profile 2178 1619 2766 00 8 Bolt
2225 1621 2544 00 8 Profile 2 180 1621 2469 80 1 Roof 3)
2235 0226 0300 16 24 Tapping screw 1615 7884 00 1 Clip

2930 1519 00 165


Parts list

66

71178

166 2930 1519 00


Parts list

Bodywork - Doors and stays


66
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

2185 1619 2766 02 4 Bolt 2 150 1621 4363 80 1 Panel


2 190 1621 2512 80 1 Roof 3) 1621 2550 00 4 Pin
2195 1619 2766 02 4 Bolt 2 155 1621 2522 80 1 Panel 1)
2 200 1621 2468 80 1 Roof 3) 1621 2550 00 4 Pin
2205 1619 2766 02 4 Bolt 2 160 1621 2475 80 1 Panel 1)
2 210 1621 5844 80 1 Panel 2) 1621 2550 00 6 Pin
2215 1619 2766 02 6 Bolt 2 165 1621 2465 80 2 End panel 2)
2 240 1621 2515 80 1 Stay 1621 2550 00 4 Pin
1621 2549 00 8 Clip 2 170 1621 2476 80 1 Panel 2)
2245 1619 2766 00 2 Bolt 1621 2550 00 4 Pin
2 250 1621 2516 80 1 Stay 2 175 1621 2517 80 2 Panel 2)
1621 2549 00 8 Clip 2178 1619 2766 00 8 Bolt
2255 1619 2766 00 2 Bolt 2 180 1621 2469 80 1 Roof 3)
2315 1621 5618 00 2 Plate 1615 7884 00 1 Clip
2317 1619 2766 00 16 Bolt 2185 1619 2766 02 4 Bolt
2320 1621 5314 00 1 Profile 2 190 1621 2512 80 1 Roof 3)
2325 1619 2766 00 2 Bolt 2195 1619 2766 02 4 Bolt
1621 2470 81 1 Panel 2 200 1621 2468 80 1 Roof 3)
3005 1 Panel 2205 1619 2766 02 4 Bolt
3010 1621 2538 00 2 Hinge 2 210 1621 2474 80 1 Panel 2)
3015 0147 1320 03 4 Bolt 2215 1619 2766 02 6 Bolt
1621 2472 81 1 Panel 2217 1621 5747 00 4 Profile
4005 1 Panel 2220 1621 5748 00 4 Profile
4010 1621 2538 00 2 Hinge 2225 1621 2544 00 8 Profile
4015 0147 1320 03 4 Bolt 2 240 1621 2515 80 1 Stay
With Tropicalised 1621 2549 00 8 Clip
integrated dryer 2245 1619 2766 00 2 Bolt
2005 1621 2473 00 4 Stay 2 250 1621 2516 80 1 Stay
2010 1621 2538 00 4 Hinge 1621 2549 00 8 Clip
2015 0147 1320 03 8 Bolt 2255 1619 2766 00 2 Bolt
2020 1619 2766 00 8 Bolt 1621 2470 80 1 Panel
2025 1621 2868 00 2 Stay 3005 1 Panel
2026 1621 2868 00 2 Stay 3007 0301 2335 00 8 Washer
2027 1621 2701 00 2 Plate 3010 1621 2538 00 4 Hinge
2029 0301 2335 00 8 Washer 3015 0147 1320 03 8 Bolt
2030 1621 2538 00 4 Hinge 1621 2472 80 1 Panel
2035 0147 1320 03 8 Bolt 4005 1 Panel
2040 1619 2766 00 8 Bolt 4007 0301 2335 00 8 Washer
2047 1621 2702 00 1 Plate 4010 1621 2538 00 4 Hinge
2050 0301 2358 00 2 Washer 4015 0147 1320 03 8 Bolt
2055 0147 1400 03 2 Bolt 1621 5317 80 1 Panel
2065 0301 2358 00 2 Washer 5010 1 Panel
2070 0147 1400 03 2 Bolt 5020 1621 2550 00 4 Pin
2 075 1621 2477 80 1 Stay 5030 0581 0000 86 6 Pipe coupling
1621 2549 00 8 Clip Doors
2080 1621 2538 00 2 Hinge 6 005 1621 4656 81 5 Door 3)
2085 0147 1320 03 4 Bolt 2252 7237 00 2 Doorlock
2090 1619 2766 00 2 Bolt 6 010 1621 4317 80 2 Door 3)
2 095 1621 2478 80 1 Stay 2252 7237 00 2 Doorlock
1621 2549 00 8 Clip 6 015 1621 4656 80 4 Door 3)
2100 1621 2538 00 2 Hinge 2252 7237 00 2 Doorlock
2105 0147 1320 03 4 Bolt 6020 1621 0607 00 22 Hinge
2110 1619 2766 00 2 Bolt 6030 1089 9068 01 2 Key
2115 1621 4472 00 1 Panel Outdoor version
2120 1619 2766 00 4 Bolt 6 005 1621 4656 81 5 Door 3)
2125 1621 2513 00 4 Beam 2252 7237 00 2 Doorlock
2126 1621 2387 00 2 Silencing foam 6 010 1621 4317 80 2 Door 3)
2127 1621 2632 00 2 Plate 2252 7237 00 2 Doorlock
2129 1619 2766 00 4 Bolt 6 015 1623 0452 80 4 Door 3)
2130 1621 2514 00 2 Beam 1619 2665 00 AR Seal
2135 1619 2766 00 25 Bolt 6017 1619 2766 02 24 Bolt
2138 1079 1472 05 1 Bolt 6020 1621 0607 00 14 Hinge
2 145 1621 2519 80 1 Panel 1) 6030 1089 9068 01 1 Key
1621 2550 00 4 Pin

2930 1519 00 167


Parts list

66

71178

168 2930 1519 00


Parts list

Bodywork - Doors and stays


66

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Markings 7075 1088 1001 04 1 Warning mark


Pack 7120 1621 0478 00 1 Label
7010 1621 2590 08 2 Label Full Feature Tropicalised
7020 0690 1140 01 2 House mark integrated dryer
7030 1079 9901 29 5 Label 7110 1619 7377 00 1 Inlet sticker
7040 1079 9923 88 6 Label 7120 1619 7379 00 1 Outlet sticker
7050 1079 9922 35 1 Decal 8220 1 Data plate
7060 1079 9922 36 1 Decal 1614 8057 05 ASME
7070 1079 9923 72 2 Label 1614 8057 08 CE
7075 1088 1001 04 1 Warning mark 1614 8057 05 CHINA
7120 1621 0478 00 1 Label 1614 8057 05 DIR
Full Feature 1614 8057 05 Japan
7010 1621 2590 11 2 Label 1614 8057 05 Lloyds
7020 0690 1140 01 2 House mark 8230 0244 4184 00 4 Drive screw
7030 1079 9901 29 5 Label
7040 1079 9923 88 6 Label 1-3) Lined with / Bekleed met / Bekldd med / Ausgekleidet
7050 1079 9922 35 1 Decal mit /Garnir de / Rivestido de / Allineato con /
7060 1079 9922 36 1 Decal Foret med / Revestido com / Kledd med / Vuorattu :
7063 1079 9923 56 2 Label 1) Foam: 0395 6001 67(AR) 30 x 2040 x 1650
7065 1079 9910 97 1 Label 2) Foam: 0395 6001 68(AR) 40 x 2040 x 1650
7070 1079 9923 72 2 Label 3) Foam: 0395 6001 69(AR) 50 x 2040 x 1650

2930 1519 00 169


Parts list

67

71179

170 2930 1519 00


Parts list

Bodywork - Container box outside


67

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Container 1160 1621 5660 00 1 Collector


Winterisation Outdoor 1161 1623 0676 00 1 Plate
version 1162 1619 2766 00 4 Bolt
1621 5150 83 1 Container 1163 1619 2758 00 AR Seal
1010 1621 5150 03 1 Container 1180 1623 0428 00 1 Plate
1020 1621 5847 00 1 Plate 1182 0147 1171 03 2 Bolt
1022 1619 2766 00 7 Bolt 1184 0147 1244 03 7 Bolt
1024 1619 5188 00 AR Seal 1185 1623 0427 00 1 Plate
1026 1202 6584 00 AR Seal 1187 1202 6584 00 AR Seal
1030 1621 6918 00 1 Plate 1190 1623 0578 00 2 Plate
1032 1623 0583 00 AR Seal 1192 0147 1171 03 4 Bolt
1034 1619 2766 00 3 Bolt 1194 0147 1244 03 14 Bolt
1040 1621 6919 00 2 Plate 1195 1623 0577 00 2 Plate
1042 1623 0583 00 AR Seal 1197 1202 6584 00 AR Seal
1044 1619 2766 00 6 Bolt 1200 1089 0712 02 5 Actuator
1050 1621 5865 00 2 Plate 1305 1623 0745 00 1 Lock
1052 1623 0583 00 AR Seal 1310 1623 0750 00 2 Bracket
1054 1619 2766 00 8 Bolt 1312 0147 1325 03 2 Bolt
1060 1621 6923 00 2 Plate 1319 0017 2071 40 AR Cable
1062 1623 0583 00 AR Seal 1321 0694 5281 26 2 Cable lug
1064 1619 2766 00 8 Bolt 1322 0694 5281 29 2 Cable lug
1070 1621 5892 00 1 Louvre 1324 0147 1476 03 1 Bolt
1071 1619 3843 01 AR Seal 1325 1088 0019 04 1 Contact washer
1072 0147 1327 03 8 Bolt 1327 0147 1402 03 1 Bolt
1074 1623 0583 00 AR Seal 1328 0266 2112 00 1 Nut
1076 1623 0584 00 AR Seal 1329 1088 0019 03 2 Contact washer
1080 1623 0645 00 1 Louver Outdoor version
1082 0147 1360 03 4 Bolt 1621 5150 81 1 Container
1084 1619 5188 00 AR Seal 1010 1621 5150 01 1 Container
1090 1621 7918 00 1 Louver 1020 1623 0759 00 1 Plate
1092 0147 1360 03 4 Bolt 1022 1619 2766 00 7 Bolt
1094 1619 5188 00 AR Seal 1024 1619 5188 00 AR Seal
1100 1621 5889 00 3 Louvre 1026 1202 6584 00 AR Seal
1102 0147 1360 03 12 Bolt 1030 1621 6918 00 1 Plate
1104 1623 0602 00 3 Plate 1032 1623 0583 00 AR Seal
1106 1619 2766 00 6 Bolt 1034 1619 2766 00 3 Bolt
1110 1621 5682 00 2 Plate 1040 1621 6919 00 2 Plate
1112 1619 2766 00 4 Bolt 1042 1623 0583 00 AR Seal
1114 1202 6584 00 AR Seal 1044 1619 2766 00 6 Bolt
1120 1623 0074 00 1 Plate 1050 1621 5865 00 2 Plate
1122 0147 1323 02 4 Bolt 1052 1623 0583 00 AR Seal
1130 1623 0513 00 1 Plate 1054 1619 2766 00 8 Bolt
1132 0147 1323 02 4 Bolt 1060 1621 6923 00 2 Plate
1135 1623 0674 00 1 Plate 1062 1623 0583 00 AR Seal
1136 1619 5188 00 AR Seal 1064 1619 2766 00 8 Bolt
1137 1619 2766 00 4 Bolt 1070 1621 7972 00 1 Plate
1140 1623 0062 00 1 Panel 1071 1619 5188 00 AR Seal
1142 1619 2766 00 12 Bolt 1072 1619 2766 00 8 Bolt
1144 1202 6584 00 AR Seal 1110 1621 5682 00 2 Plate
1146 0371 1100 13 1 Lifting eye 1112 1619 2766 00 4 Bolt
1148 1088 1301 04 1 Cable strip 1114 1202 6584 00 AR Seal
1150 1623 0058 00 2 Support 1120 1623 0074 00 1 Plate
1152 0147 1476 03 6 Bolt 1122 0147 1323 02 4 Bolt
1154 0147 1482 03 4 Bolt 1130 1623 0513 00 1 Plate
1156 0301 2378 00 10 Washer 1132 0147 1323 02 4 Bolt

2930 1519 00 171


Parts list

67

71179

172 2930 1519 00


Parts list

Bodywork - Container box outside


67

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

1140 1623 0062 00 1 Panel 1322 0694 5281 29 2 Cable lug


1142 1619 2766 00 12 Bolt 1324 0147 1476 03 1 Bolt
1144 1202 6584 00 AR Seal 1325 1088 0019 04 1 Contact washer
1146 0371 1100 13 1 Lifting eye 1327 0147 1402 03 1 Bolt
1148 1088 1301 04 1 Cable strip 1328 0266 2112 00 1 Nut
1150 1623 0058 00 2 Support 1329 1088 0019 03 2 Contact washer
1152 0147 1476 03 6 Bolt Markings
1154 0147 1482 03 4 Bolt Pack Outdoor version
1156 0301 2378 00 10 Washer 2005 0690 1101 29 2 Label
1160 1621 5660 00 1 Collector 2010 1623 0040 22 2 Decal
1161 1623 0676 00 1 Plate 2015 1079 9901 29 7 Label
1162 1619 2766 00 4 Bolt 2020 1079 9915 98 1 Label
1163 1619 2758 00 AR Seal Full Feature Outdoor version
1305 1623 0745 00 1 Lock 2005 0690 1101 29 2 Label
1310 1623 0750 00 2 Bracket 2010 1623 0040 25 2 Decal
1312 0147 1325 03 2 Bolt 2015 1079 9901 29 7 Label
1319 0017 2071 40 AR Cable 2020 1079 9915 98 1 Label
1321 0694 5281 26 2 Cable lug

2930 1519 00 173


Parts list

68

71172

174 2930 1519 00


Parts list

Electrical system - Cubicle - Winterisation


68
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Full Feature IEC Full Feature CSA-UL


1100 1623 0139 00 1 Support 1100 1623 0139 00 1 Support
1105 1619 2766 00 3 Bolt 1105 1619 2766 00 3 Bolt
1110 1619 2766 00 1 Bolt 1110 1619 2766 00 4 Bolt
1900 3165 48 1 Electr. system 1900 3165 49 1 Electr. system
2005 1623 0567 00 1 Cubicle 2005 1623 0567 00 1 Cubicle
2010 1623 0145 00 2 Support 2010 1623 0145 00 2 Support
2015 0147 1323 03 4 Bolt 2015 0147 1323 03 4 Bolt
2020 0291 1110 00 4 Locknut 2020 0291 1110 00 4 Locknut
2025 0301 2335 00 8 Washer 2025 0301 2335 00 8 Washer
2030 1089 9489 13 1 Contactor 2030 1089 9489 28 1 Contactor
2035 1089 9489 11 1 Contactor 2035 1089 9489 30 1 Contatcor
2040 1089 9551 72 1 Circuit breaker 2040 1089 9551 72 1 Circuit breaker
2045 1089 9551 72 1 Circuit breaker 2045 1089 9551 72 1 Circuit breaker
2050 1089 9551 69 1 Circuit breaker 2050 1089 9551 69 1 Circuit breaker
2055 1089 9514 30 1 Transformer 2055 1089 9514 30 1 Transformer
2060 1089 9604 09 1 Circuit breaker 2060 1089 9604 12 1 Circuit breaker
2065 1089 9398 40 3 Terminal block 2065 1089 9398 40 3 Terminal block
2070 1089 9398 39 3 End section 2070 1089 9398 39 3 End section
2075 1089 9398 41 1 Terminal block 2075 1089 9398 41 1 Terminal block
2080 1089 9398 22 16 Terminal block 2080 1089 9398 22 16 Terminal block
2085 1089 9398 23 8 Terminal block 2085 1089 9398 23 8 Terminal block
2090 1089 9366 04 1 Fuse holder 2090 1089 9366 04 1 Fuse holder
2095 0981 4000 02 1 Fuse 2095 0981 4000 02 1 Fuse
2100 1089 9366 04 1 Fuse holder 2100 1089 9366 04 1 Fuse holder
2105 0981 4000 02 1 Fuse 2105 0981 4000 03 1 Fuse
2110 1089 9366 04 1 Fuse holder 2110 1089 9366 04 1 Fuse holder
2115 0981 4000 02 1 Fuse 2115 0981 4000 03 1 Fuse
2120 1089 9366 04 1 Fuse holder 2120 1089 9366 04 1 Fuse holder
2125 0981 4000 02 1 Fuse 2125 0981 4000 03 1 Fuse
2130 1089 9366 04 1 Fuse holder 2130 1089 9366 04 1 Fuse holder
2135 0981 4000 02 1 Fuse 2135 0981 4000 03 1 Fuse
2140 1089 9398 09 1 End section 2140 1089 9398 09 1 End section
2150 1089 9604 01 1 Circuit breaker 2150 1089 9604 02 1 Circuit breaker
2500 1088 1001 04 1 Warning mark 2500 1088 1001 04 1 Warning mark
1900 3165 50 1 Electr. system 4005 1089 0504 15 1 Heater
3005 1089 9551 68 1 Circuit breaker 4020 1089 0612 01 1 Fuse holder
3010 1089 9514 18 1 Transformer 4025 1089 9168 26 1 Fuse link
3015 1089 9604 08 1 Circuit breaker 4035 1089 9398 11 1 Terminal
3020 1089 9398 22 6 Terminal block 4040 1089 9398 11 1 Terminal
3025 1089 9398 23 3 Terminal block 4055 1089 0504 15 1 Heater
3030 1089 9366 04 1 Fuse holder 4070 1089 0612 01 1 Fuse holder
3035 0981 4000 05 1 Fuse 4075 1089 9168 26 1 Fuse link
3045 1089 9366 04 1 Fuse holder 4105 1089 0504 11 1 Temp. switch
3050 0981 4000 02 1 Fuse 4115 1089 9398 11 1 Terminal
3055 1089 9366 04 1 Fuse holder 4135 1089 9398 11 1 Terminal
3060 0981 4000 02 1 Fuse 4145 1089 9438 01 1 Relay
3065 1089 9366 04 1 Fuse holder 4155 1089 0506 27 1 Terminal
3070 0981 4000 02 1 Fuse Pack IEC
4005 1089 0504 07 1 Heater 1100 1623 0139 00 1 Support
4020 1089 0612 01 1 Fuse holder 1105 1619 2766 00 3 Bolt
4025 1089 0612 23 1 Fuse 1110 1619 2766 00 4 Bolt
4035 1089 9398 11 1 Terminal 1900 3165 46 1 Electr. system
4040 1089 9398 11 1 Terminal 2005 1623 0567 00 1 Cubicle
4055 1089 0504 07 1 Heater 2010 1623 0145 00 2 Support
4070 1089 0612 01 1 Fuse holder 2015 0147 1323 03 4 Bolt
4075 1089 0612 23 1 Fuse 2020 0291 1110 00 4 Locknut
4105 1089 0504 11 1 Temp. switch 2025 0301 2335 00 8 Washer
4115 1089 9398 11 1 Terminal 2030 1089 9489 13 1 Contactor
4135 1089 9398 11 1 Terminal 2035 1089 9489 11 1 Contactor
4145 1089 9438 04 1 Relay 2040 1089 9551 72 1 Circuit breaker
4155 1089 0506 27 1 Terminal

2930 1519 00 175


Parts list

68

71172

176 2930 1519 00


Parts list

Electrical system - Cubicle - Winterisation


68

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

2045 1089 9551 72 1 Circuit breaker 2015 0147 1323 03 4 Bolt


2050 1089 9551 68 1 Circuit breaker 2020 0291 1110 00 4 Locknut
2055 1089 9514 18 1 Transformer 2025 0301 2335 00 8 Washer
2060 1089 9604 07 1 Circuit breaker 2030 1089 9489 28 1 Contactor
2065 1089 9398 40 3 Terminal block 2035 1089 9489 30 1 Contatcor
2070 1089 9398 39 3 End section 2040 1089 9551 72 1 Circuit breaker
2075 1089 9398 41 1 Terminal block 2045 1089 9551 72 1 Circuit breaker
2080 1089 9398 22 16 Terminal block 2050 1089 9551 68 1 Circuit breaker
2085 1089 9398 23 8 Terminal block 2055 1089 9514 18 1 Transformer
2090 1089 9366 04 1 Fuse holder 2060 1089 9604 10 1 Circuit breaker
2095 0981 4000 01 1 Fuse 2065 1089 9398 40 3 Terminal block
2100 1089 9366 04 1 Fuse holder 2070 1089 9398 39 3 End section
2105 0981 4000 02 1 Fuse 2075 1089 9398 41 1 Terminal block
2110 1089 9366 04 1 Fuse holder 2080 1089 9398 22 16 Terminal block
2115 0981 4000 02 1 Fuse 2085 1089 9398 23 8 Terminal block
2140 1089 9398 09 1 End section 2090 1089 9366 04 1 Fuse holder
2150 1089 9604 01 1 Circuit breaker 2095 0981 4000 02 1 Fuse
2500 1088 1001 04 1 Warning mark 2100 1089 9366 04 1 Fuse holder
4005 1089 0504 07 1 Heater 2105 0981 4000 03 1 Fuse
4020 1089 0612 01 1 Fuse holder 2110 1089 9366 04 1 Fuse holder
4025 1089 0612 23 1 Fuse 2115 0981 4000 03 1 Fuse
4035 1089 9398 11 1 Terminal 2140 1089 9398 09 1 End section
4040 1089 9398 11 1 Terminal 2150 1089 9604 02 1 Circuit breaker
4055 1089 0504 07 1 Heater 2500 1088 1001 04 1 Warning mark
4070 1089 0612 01 1 Fuse holder 4005 1089 0504 15 1 Heater
4075 1089 0612 23 1 Fuse 4020 1089 0612 01 1 Fuse holder
4105 1089 0504 11 1 Temp. switch 4025 1089 9168 26 1 Fuse link
4115 1089 9398 11 1 Terminal 4035 1089 9398 11 1 Terminal
4135 1089 9398 11 1 Terminal 4040 1089 9398 11 1 Terminal
4145 1089 9438 04 1 Relay 4055 1089 0504 15 1 Heater
4155 1089 0506 27 1 Terminal 4070 1089 0612 01 1 Fuse holder
Pack CSA-UL 4075 1089 9168 26 1 Fuse link
1100 1623 0139 00 1 Support 4105 1089 0504 11 1 Temp. switch
1105 1619 2766 00 3 Bolt 4115 1089 9398 11 1 Terminal
1110 1619 2766 00 4 Bolt 4135 1089 9398 11 1 Terminal
1900 3165 47 1 Electr. system 4145 1089 9438 01 1 Relay
2005 1623 0567 00 1 Cubicle 4155 1089 0506 27 1 Terminal
2010 1623 0145 00 2 Support

2930 1519 00 177


Parts list

69

71173

178 2930 1519 00


Parts list

Electrical system - Options


69

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

IEC Winterisation CSA-UL With aftercooler


1005 1623 0032 00 1 Heater High ambient condition
1015 1623 0032 00 1 Heater CSA-UL With aftercooler
CSA-UL Winterisation Outdoor version
1005 1623 0031 00 1 Heater 4005 1621 6931 01 1 Wiring
1015 1623 0031 00 1 Heater 4015 1089 0659 54 1 Switch
Winterisation 4016 0147 1320 03 1 Bolt
2005 1088 0031 04 1 Connector 4020 0661 1000 25 1 Seal washer
2010 1621 7333 00 1 Wiring 4025 1089 0659 54 1 Switch
2025 1623 0111 00 1 Support 4026 0147 1244 03 1 Bolt
2030 1619 2766 00 1 Bolt 4030 0661 1000 25 1 Seal washer
2035 0623 2100 15 1 Back nut 4035 1089 9439 24 1 Valve
2040 0301 2378 00 1 Washer 4040 1088 1001 01 1 Warning mark
2045 0333 3244 00 1 Lock washer 4045 1089 9439 22 1 Valve
2050 1089 0574 49 1 Temp.sensor 4050 1088 1001 01 1 Warning mark
3005 1089 0699 01 1 Box CSA-UL With aftercooler
3010 3214 0636 00 1 Mounting rail Winterisation
3015 1089 0577 09 5 Terminal 4005 1623 0435 00 1 Wiring
3020 1089 0577 98 5 Connector 4015 1089 0659 54 1 Switch
3025 1089 0310 35 2 Resistor 4016 0147 1244 03 1 Bolt
3030 1089 0310 35 3 Resistor 4020 0661 1000 25 1 Seal washer
IEC With aftercooler 4025 1089 0659 54 1 Switch
High ambient condition 4026 0147 1244 03 1 Bolt
IEC With aftercooler 4030 0661 1000 25 1 Seal washer
Outdoor version 4035 1089 9439 24 1 Valve
4005 1621 6931 01 1 Wiring 4040 1088 1001 01 1 Warning mark
4015 1089 0659 54 1 Switch 4045 1089 9439 22 1 Valve
4016 0147 1320 03 1 Bolt 4050 1088 1001 01 1 Warning mark
4020 0661 1000 25 1 Seal washer IEC Hot air variant High
4025 1089 0659 54 1 Switch ambient condition
4026 0147 1244 03 1 Bolt IEC Hot air variant
4030 0661 1000 25 1 Seal washer Outdoor version
4035 1089 9439 23 1 Valve 4005 1621 6930 01 1 Wiring
440 1088 1001 01 1 Warning mark 4015 1089 0659 54 1 Switch
4045 1089 9439 21 1 Valve 4016 0147 1320 03 1 Bolt
4050 1088 1001 01 1 Warning mark 4020 0661 1000 25 1 Seal washer
IEC With aftercooler 4035 1089 9439 23 1 Valve
Winterisation 4040 1088 1001 01 1 Warning mark
4005 1623 0435 00 1 Wiring CSA-UL Hot air variant
4015 1089 0659 54 1 Switch High ambient condition
4016 0147 1244 03 1 Bolt CSA-UL Hot air variant
4020 0661 1000 25 1 Seal washer Outdoor version
4025 1089 0659 54 1 Switch 4005 1621 6930 01 1 Wiring
4026 0147 1244 03 1 Bolt 4015 1089 0659 54 1 Switch
4030 0661 1000 25 1 Seal washer 4016 0147 1320 03 1 Bolt
4035 1089 9439 23 1 Valve 4020 0661 1000 25 1 Seal washer
4040 1088 1001 01 1 Warning mark 4035 1089 9439 24 1 Valve
4045 1089 9439 21 1 Valve 4040 1088 1001 01 1 Warning mark
4050 1088 1001 01 1 Warning mark

2930 1519 00 179


Parts list

69

71173

180 2930 1519 00


Parts list

Electrical system - Options


69

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

Full Feature IEC 380V 50Hz Winterisation


Winterisation 400V 50Hz Winterisation
5005 1089 9439 21 3 Valve 380V 60Hz Winterisation
Full Feature CSA-UL 440V 60Hz Winterisation
Winterisation 460V 60Hz Winterisation
5005 1089 9439 22 3 Valve 8012 1079 9902 55 1 Label
Outdoor version 8022 1079 9902 55 1 Label
6005 1089 0699 02 1 Box 8030 1089 0504 11 1 Temp. switch
6010 1089 9513 01 1 Button 9005 1089 0703 03 1 Air heater
6015 1089 9513 02 1 Contact block 10 005 1089 0703 03 1 Air heater
6020 1089 9513 04 1 Contact block 12 005 1089 0699 03 1 Box
6025 1089 9513 02 1 Contact block 12 010 1089 0715 01 1 Temp. switch
6030 1089 9125 05 1 Label 500V 50Hz Winterisation
6037 1088 1501 03 AR Shrinking hose 575V 60Hz Winterisation
6038 1088 1501 03 AR Shrinking hose 8012 1079 9902 55 1 Label
IEC Outdoor version 8022 1079 9902 55 1 Label
7005 1623 0802 00 1 Switch 8030 1089 0504 11 1 Temp. switch
7010 1623 0630 00 1 Lamp 9005 1089 0703 04 1 Air heater
7015 1623 0630 00 1 Lamp 10 005 1089 0703 04 1 Air heater
12 005 1089 0699 03 1 Box
12 010 1089 0715 01 1 Temp. switch

2930 1519 00 181


Parts list

70 Service kits

Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

2906 0726 00 1 LP Compressor element 0663 2107 94 1 O-ring


exchange kit 1614 7368 00 1 Check valve
0663 2103 22 1 O-ring 1621 3014 00 1 Spring
0663 2107 33 1 O-ring 1621 3466 00 1 Valve seat
0663 2107 33 2 O-ring
0663 2107 81 1 O-ring 2906 0375 00 1 Inlet valve service kit
0663 2107 89 1 O-ring 1613 4036 00 1 Membrane
0663 2107 90 3 O-ring 1613 5723 00 1 Gasket
0663 2107 91 1 O-ring 1621 0078 00 1 Diaphragm
1202 9621 03 1 Gasket
9125 6303 00 1 Seal washer 2906 0497 00 1 Inlet valve bearing block kit
0301 2144 01 1 Washer
2906 0727 00 1 HP Compressor element 1621 0074 00 1 Bearing block
exchange kit 1621 0075 00 1 Ring
0634 1000 25 2 Ring for clp 0634 1001 06 1621 3758 00 1 Shaft
0650 0101 09 1 Gasket IMD300 1621 3759 00 1 Lock nut
0663 2103 19 1 O-ring
0663 2107 33 2 O-ring 2906 0498 00 1 Inlet valve overhaul kit
0663 2107 81 2 O-ring 0261 1099 11 2 Nut
0663 2107 89 1 O-ring 0335 1122 00 1 Circlip
0663 2107 90 3 O-ring 0500 4510 10 2 Bushing shaft
0663 2107 91 1 O-ring 0500 4510 22 2 Bushing pivot
0663 2107 92 2 O-ring 0663 2107 91 1 O-ring
0663 2107 94 1 O-ring 1202 9621 03 1 Gasket
9125 6303 00 1 Seal washer 1621 0076 00 2 Pivot pin
1621 0081 00 2 Washer
2906 0403 00 1 Gear casing seal kit 2102 0802 00 1 Spring
0661 1000 25 1 Seal washer 2906 0375 00 1 Inlet valve service kit
0661 1000 29 1 Seal washer 2906 0497 00 1 Inlet valve bearing block kit
0661 1000 31 4 Seal washer
0663 2104 37 4 O-ring 2906 0730 00 1 Air/oil filter kit
0663 2107 81 6 O-ring 0661 1000 25 1 Washer (ZR110-145)
0663 2107 88 1 O-ring 0661 1000 30 1 Seal Washer
0663 2107 90 2 O-ring 0661 1000 31 1 Seal Washer
1621 3297 00 1 Plug 0663 2107 84 1 O-Ring
9125 6303 00 1 Seal washer 1614 8673 01 1 Filter Element
1614 8747 99 1 Oil filter element
2906 0373 00 1 Oil pump kit for 50 Hz units 1619 2689 00 1 Filter Plug
0101 1951 36 1 Pin 1621 1389 99 1 Filter element
0102 0244 00 1 Pin 2906 6255 01 1 Gearcase breather filter elem.
0337 0009 24 1 Parallel key
0663 2106 16 1 O-ring 2906 0425 00 1 LP discharge silencer kit
1616 5439 00 1 Distance ring 0663 2107 33 3 O-Ring
1616 6126 00 1 Eccentric ring 0663 2107 49 1 O-Ring
1616 6127 00 1 Pump element 0663 2107 50 3 O-Ring (+1 For Old ZT/ZR)
1616 6294 00 1 Key 1621 3925 00 1 Glass Wool
1621 4101 00 1 Insert
2906 0178 00 1 Oil pump kit for 60 Hz units
0101 1951 36 1 Pin 2906 0405 00 1 HP discharge silencer kit
0661 1000 29 2 Seal ring (Z 65/90) 0663 2106 14 1 O-ring (old ZT)
0661 1000 30 2 Washer (ZE 45-185) 0663 2107 15 2 O-ring
0663 2106 16 1 O-ring 0663 2107 91 1 O-ring (old ZT)
0663 7126 00 1 O-ring (Z 65/90) 0663 2107 92 2 O-ring (+1 old units)
1616 5436 00 1 Oil pump 0663 2107 93 1 O-ring
1616 5439 00 1 Ring (ZE 45-185) 1621 3924 00 1 Glass fibre
1616 5533 00 1 Eccentric ring 1621 4108 00 1 Insert
1616 6125 00 1 Ring
1616 6294 00 1 Key 2906 0746 00 1 Cooler service kit
0634 1000 24 2 Rubber ring for
2906 0374 00 1 Check valve kit cpl 0634 1000 22
0500 4510 11 1 Bush 0634 1000 25 1 Rubber ring for
0663 2107 15 2 O-ring cpl 0634 1000 19
0663 2107 16 1 O-ring 0663 2107 13 2 O-Ring
0663 2107 92 1 O-ring 0663 2107 33 8 O-Ring
0663 2107 93 1 O-ring

182 2930 1519 00


Parts list

Service kits
70
Ref. Part number Qty Name Remarks Ref. Part number Qty Name Remarks

0663 2107 93 4 O-Ring 0663 9307 00 1 O-Ring


1621 2309 00 1 Seal 1614 7606 00 1 Seal Ring
1621 2254 05 1 Seal
2906 0413 00 1 Drive shaft bearing kit
0335 1147 00 1 Circlip 2906 0302 00 1 Air valve kit
0335 2169 00 1 Circlip 0650 0101 11 1 Gasket (old type valve)
0502 1090 86 1 Bearing 0663 2104 03 1 O-ring
0508 1100 50 1 Bearing 0663 2112 26 1 O-ring
0661 1000 42 4 Washer 1614 7631 00 1 Seal (old units)
0663 2107 87 1 O-ring 1617 5109 00 1 Nut
1617 5110 00 1 Valve
2906 0418 00 1 Drive shaft seal ring kit
0661 1000 42 4 Washer 2906 0738 00 1 Overhaul kit for gearbox
0663 2107 87 1 O-ring 0335 2217 00 1 Circlip
1616 6120 00 1 Seal 0500 4510 35 1 Bearing
0663 7135 00 1 O-ring
2906 0432 00 1 Seal washer kit 0663 9228 00 1 O-ring
0653 1041 00 6 Flat Gasket 1202 2152 00 2 Washer
0653 1062 00 8 Flat Gasket 1202 2153 00 1 Spring
0653 1100 00 3 Flat Gasket 1617 5321 00 1 Seal
0653 1124 00 6 Flat Gasket 1617 5688 00 1 Seal ring
0653 1128 00 2 Flat Gasket 1619 2875 00 1 Saddle ring
0653 1165 00 4 Flat Gasket 1619 2876 00 3 Hook ring
0653 1174 00 2 Flat Gasket 1619 2877 00 1 Counter ring
0653 1189 00 2 Flat Gasket
0653 1227 00 2 Flat Gasket 2906 0735 00 1 Check valve kit
0653 1254 00 4 Flat Gasket 1621 2642 00 2 Hinge/stop pin
0653 1293 00 5 Flat Gasket 1621 2644 00 4 Bearing
0661 1000 24 4 Seal washer 1621 2663 00 2 Spring sleeve bearing
0661 1000 25 15 Seal washer 1621 9213 00 1 Spring
0661 1000 26 8 Seal washer 1621 9215 00 2 Spring sleeve
0661 1000 27 12 Seal washer
0661 1000 29 4 Seal washer 2906 0739 00 1 A-maintenance kit
0661 1000 30 5 Seal washer 0661 1000 30 1 Seal washer
0661 1000 31 5 Seal washer 0663 2107 84 1 O-ring
0661 1000 32 2 Seal washer 1614 8673 01 1 Safety filter element
0661 1000 33 3 Seal washer 1614 8747 99 1 Oil filter element
2906 6255 01 1 Gear case breather
2906 0691 00 1 Blow down valve filter element
PN 1621 9216 00 on 8204 0940 34 1 Intercooler drain check valve
intercooler
0586 1000 32 1 Union coupling 2906 0741 00 1 B-maintenance kit
0603 4106 03 1 Nipple 2901 0673 00 2 Drain valve kit ZT
0603 4200 16 1 Hex. Nipple G 1 2906 0375 00 1 Inlet valve service kit
0603 4200 23 1 Nipple 2906 0497 00 1 Inlet valve bearing block kit
0661 1000 30 3 Seal washer 2906 0730 00 1 Air/oil filter kit
0661 1000 31 2 Seal washer 0663 2107 15 2 O-ring check valve
0663 2107 25 1 O-ring 0663 2107 16 1 O-ring check valve
0686 3716 09 1 Plug 0663 2107 92 1 O-ring check valve
0803 5012 13 1 Silencer 0663 2107 93 1 O-ring check valve
1621 9216 00 1 Blow Off valve 0663 2107 94 1 O-ring check valve
1621 9698 00 1 Cover 1621 3014 00 1 Spring check valve
8204 0940 34 1 Intercooler drain check valve
2906 0748 00 1 Connection kit used when
sliding the IMD out of 2906 0828 00 1 B-maintenance kit
the ZT unit for IMD 300
0634 1000 25 1 Rubber seal for 2901 0633 00 1 Drain valve kit
cpl 0634 1000 19 2901 0673 00 2 Drain valve kit
0650 0101 10 2 Gasket 2906 0737 00 1 Rotor inspection kit
1621 2309 00 1 Seal 0663 9307 00 1 O-ring
1614 7605 10 1 Demister
2906 0737 00 1 Rotor inspection / rotor 1614 7663 00 1 Strainer
exchange kit
0650 0101 09 1 Gasket
0663 2104 03 2 O-Ring pn 1617 5806 00

2930 1519 00 183


Parts list

Notes:

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

184 2930 1519 00


Parts list

Notes:

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

2930 1519 00 185


Parts list

Notes:

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

..........................................................................................................................................................................................................

186 2930 1519 00


Atlas Copco Stationary Air Compressors
ZT 110

Parts list
What sets Atlas Copco apart as a company is our convic-
tion that we can only excel in what we do if we provide the best
possible know-how and technology to really help our customers
produce, grow and succeed.
There is a unique way of achieving that - we simply call it
the Atlas Copco way. It builds on interaction, on long-term
relationships and involvement in the customers process, needs
and objectives. It means having the
flexibility to adapt to the diverse demands of the people
we cater for.
Its the commitment to our customers business that drives
our effort towards increasing their productivity through better
solutions. It starts with fully supporting existing products and
continuously doing things better, but it goes much further,
creating advances in technology through innovation. Not for the
sake of technology, but for the sake of our customers bottom
line and peace-of-mind.
That is how Atlas Copco will strive to remain the first
choice, to succeed in attracting new business and to maintain
our position as the industry leader.
No. 2930 1519 00 / DC 2008.06

*2930151900*

You might also like