Professional Documents
Culture Documents
P U B L I C A T I O N T R A N S M I T T A L
This letter transmits Revision 1 to the subject service bulletin. Replace the original
issue with this Revision 1.
If you have complied with the previous issue of this bulletin, no additional work is
required.
The following list includes the original issue date and all revisions to this bulletin:
CUSTOMER SUPPORT
ROLLSROYCE
CHECK THAT ALL PREVIOUS TRANSMITTALS HAVE BEEN INCORPORATED if any have not been received please advise
RollsRoyce Corporation Publications Services, Indianapolis, Indiana, USA
EXPORT CONTROLLED SERVICE
BULLETIN
A. Effectivity
(1) Engines
All AE 3007A, AE 3007A1/1, AE3007A1/3, AE 3007A1, AE 3007A1E, AE 3007A1P, and
AE 3007A3 engines
All AE 3007C and AE 3007C1 engines.
NOTE: The engine serial numbers that are affected by this service bulletin have not been
established. This service bulletin will be revised when engine production records
for this modification are recorded, and engine serial number effectivity for in
service engines are established.
(2) Spares Not affected
B. Reason
This service bulletin releases a new radial drive quill shaft (P/N 23077207) to the AE 3007A
series and AE 3007C series engines. The changes from the preceding part numbers, P/N
23056789 and 23076810, include the addition of a center balance collar, new balance
procedure, tighter balance requirements, and thicker walls. All the changes are intended to
improve the dynamic response of the shaft and reduce the likelihood of the radial drive system
causing an operational event.
C. Description
This service bulletin gives you the procedure to remove the radial drive quill shaft (23056789 or
23076810) and install the new radial drive quill shaft (23077207).
D. Approval
Technical aspects are FAA approved.
E. Manpower
In Service Approximately 8.0 manhours are necessary to do this service bulletin.
Engine Removed Approximately 3.0 manhours are necessary to do this service bulletin.
Required labor will be reimbursed by Rolls-Royce when accomplished for eligible engines under
the stated effectivity and compliance and performed at a Rolls-Royce authorized maintenance
facility.
F. Compliance
Recommended. After the parts are available, you should do this bulletin at the next shop visit or
at the next convenient maintenance opportunity.
Page 1 of 4
EXPORT CONTROLLED RollsRoyce
SERVICE BULLETIN
H. Material Availability
Unit prices listed in this service bulletin are valid when the service bulletin is published. Unit
prices are subject to change. Contact your Account Representative at Rolls-Royce Supply
Services for current unit prices.
For AE 3007A Series engines:
A credit allowance will be provided for parts required when accomplished for eligible engines
under the stated effectivity and compliance. Contact your Account Representative at
Rolls-Royce Supply Services for parts availability as follows:
Telephone: 3172302016
FAX: 3172308899
For AE 3007C Series engines:
A credit allowance will be provided for parts required when accomplished for eligible engines
under the stated effectivity and compliance. Contact Citation Parts Distribution for parts
availability as follows:
L. References
(1) Advance Engineering Memorandum (AEM), CN113959.
NOTE: The document above is referenced for the internal use of Rolls-Royce only.
(2) AE 3007A Series Illustrated Parts Catalog (IPC), CSP33002.
(3) AE 3007C Series Illustrated Parts Catalog (IPC), CSP33001.
(4) AE 3007 Series Engine Manual (EM), CSP31010.
June 25, 2004
Revision 1 AE 3007A72299
July 19, 2004 AE 3007C72240
Page 2 of 4
EXPORT CONTROLLED RollsRoyce
SERVICE BULLETIN
(5) AE 3007A Maintenance Manual (MM), CSP34022.
(6) AE 3007C Maintenance Manual (MM), CSP34012.
(7) Service Bulletin AE 3007A72229, AE 3007A72230, and AE 3007A72242.
(8) Service Bulletin AE 3007C72189, AE 3007C72190, and AE 3007C72199.
M. Other Publications Affected
(1) AE 3007A Series Illustrated Parts Catalog (IPC), CSP33002.
(2) AE 3007C Series Illustrated Parts Catalog (IPC), CSP33001.
N. Prerequisites None
O. Corequisites None
2. ACCOMPLISHMENT INSTRUCTIONS
CAUTION: IN ORDER TO REDUCE THE POTENTIAL FOR MULTIPLEENGINE INFLIGHT
SHUTDOWN, POWER LOSS, OR OTHER ANOMALY DUE TO MAINTENANCE
ERROR, ROLLSROYCE RECOMMENDS THAT OPERATORS AVOID
PERFORMING MAINTENANCE ON MULTIPLE ENGINES INSTALLED ON THE
SAME AIRCRAFT AT THE SAME TIME. IF IT IS NOT POSSIBLE TO AVOID
MAINTENANCE ON MORE THAN ONE ENGINE AT THE SAME TIME,
ROLLSROYCE RECOMMENDS THAT ADDITIONAL CONTROLS ARE APPLIED IN
ORDER TO ENSURE THAT MAINTENANCE TASKS HAVE BEEN COMPLETED AS
DEFINED. MAINTENANCE GUIDELINES SHOULD BE REVISED, WHERE
POSSIBLE, TO PROMOTE THIS RECOMMENDATION.
A. Remove the accessory gearbox and quill shaft (Ref. 726310, MM).
B. Examine the removed radial quill shaft (Ref. 726310, MM).
NOTE: If any inspection findings on the radial quill shaft bearing journal (Diameter A in the
MM illustration) cause the radial quill shaft to be rejected, replace the midspan roller
bearing (Ref. 722535, MM).
C. Install new radial quill shaft (23077207) and the accessory gearbox (Ref. 726310400801,
MM).
D. Return the removed parts with the attached Parts Return Report to the following address:
For AE 3007A Series engines:
Rolls-Royce Corporation
C/O UPS SCS
Returns Processing Center
2840 Fortune Circle West Drive
Dock Door 16
Indianapolis, Indiana 46241
USA
For AE 3007C Series engines:
Citation Parts Distribution Center
7121 SW Boulevard
Wichita, Kansas 67215
USA
Page 3 of 4
EXPORT CONTROLLED RollsRoyce
SERVICE BULLETIN
E. Complete the Service Bulletin Compliance form and FAX it to:
AE Service Data
RollsRoyce Corporation
Attn: AE Service Data Manager
P.O. Box 420, Speed Code U17
Indianapolis, Indiana 462060420
USA
F. Record compliance with this service bulletin in the applicable section of the engine logbook.
3. MATERIAL INFORMATION
A. Configuration Chart
ROLLS-
ROYCE
QTY/ QTY/ INSTRUCTIONS/ INHOUSE
NEW P/N ENG NAME OLD P/N ENG DISPOSITION DISPOSITION
23077207 1 Shaft, Radial Drive Quill 23076810 1 1, 2 b1
23056789
INSTRUCTIONS/DISPOSITION NOTES
1. New item.
2. Return removed item.
3. Discard item.
4. Rework item to new configuration.
5. Change quantity.
CUSTOMER SUPPORT
ROLLS-ROYCE
Page 4 of 4
EXPORT CONTROLLED SERVICE
BULLETIN
Operator:
Fax:
Date: _______________________
Email cra.rel.data@rolls-royce.com
FAX 3172304010
Page 1 of 3
PARTS RETURN REPORT
Rolls-Royce Corporation
18882554766 or 3172306400
Date _____________________
Include a copy of this report with the shipment, and ship the part(s) to:
GT1133 (02/03)