Professional Documents
Culture Documents
ASSIGNMENT 2.5
Please note: Use the up and down cursor keys to move between fields in this form.
After answering the questions, save the file using the same name. Then use the upload facility to
return it for marking.
Each question has several answers, only one of which is correct. Select the answer you think is
correct by typing # in the appropriate box. Each question is worth 1 mark
1. In general, what is the modern term used to for what was previously referred to as testing?
# Verification
Proof load test
# Thorough examination
Inspection
2. In LOLER, what term is used for the process which checks whether lifting equipment is safe to use?
Testing
Visual inspection
# Thorough examination
Verification
4. What is the minimum standard of accuracy required by LEEA 044 for a tensile testing machine?
0.5%
1.0%
# 2.0%
5.0%
8. For fine measurement using a vernier, what is the maximum graduation increment needed?
0.001 mm
0.01 mm
# 0.1 mm
1 mm
9. The figure shows the reading on a vernier graduated in mm. What is the diameter of the bar?
8 mm
8.1 mm
8.2 mm
# 8.3 mm
8.4 mm
8.5 mm
8.6 mm
# 8.7 mm
8.8 mm
8.9 mm
10. What type of NDT would you use for simple crack detection on welds?
Eddy current
# Dye penetrate
Radiography
Ultrasonic
12. Which method of verification is specified in BS EN 13411-3 for each ferrule secured eye?
# Dimensional check
Proof load test
Sample tested to destruction
Hardness test on ferrule
14. What method of verification is appropriate for each mechanically assembled chain sling to BS EN
818-4?
# Visual examination
Proof load test to 2 x WLL
# Proof load test to 2.5 x WLL
Dimensional check
16. Which hardness test is most commonly used in the lifting equipment industry?
Vickers
# Brinell
Rockwell
Houndsfield
17. What is one important periodic check on a tape measure to ensure it is serviceable?
# Tape is marked in increments of 1 mm
Tape is marked in black on yellow for clarity
# Tape is legible
Tape can be locked in the extended position
19. Compared to a visual examination, what is one advantage of an electromagnetic wire rope
examination?
Measures the reduction wire section
Predicts rope life left
# Provides a continuous printout of the results
Estimates the current strength of the rope
20. For liquid penetration crack detection which statement below is true.
# Can be applied to ferrous and non-ferrous metal components
Will reveal the location of all cracks and defects
Will work only with ferromagnetic materials
Will only indicate the depth of surface cracks
Marking
Answers still shown in black were correct
Answers now shown in red were incorrect the correct answers are shown in blue
Result 75%