Professional Documents
Culture Documents
com
CE-GATE-2015
Disclaimer This paper analysis and questions have been collated based on the memory of some students who
appeared in the paper and should be considered only as guidelines. GATEFORUM does not take any responsibility for
the correctness of the same.
1
Shared on QualifyGate.com
CE-GATE-2015
1. Find maximum ordinate of S-curve of the 4-hr unit hydrograph given below.
0 2 4 6 8 10 12 14 16 18 20 22 24
0 0.6 3.1 10 13 9 5 2 0.7 0.3 0.2 0.1 0
M25 Capacity
Fe415
300
4 12 x u max = 0.48d
200
3.
P = 100 kN
600
75
75
75 75
9
4. f (z) = which of the following is one of the residues of the given function
( z 1)( z + 2 )2
(A) -1 (B) 9/16 (C) 2 (D) 9
3 2 2
5. 4 4 6
2 3 3
Which one of the following are its smallest and largest eigen values?
(A) 1.5,2.5 (B) 0.5,2.5 (C) 1,3 (D) (1,2)
Disclaimer This paper analysis and questions have been collated based on the memory of some students who
appeared in the paper and should be considered only as guidelines. GATEFORUM does not take any responsibility for
the correctness of the same.
2
Shared on QualifyGate.com
CE-GATE-2015
6. For 2m wide rectangular channel n = 0.01, s = 1/10000, discharge 4m3/s in GVF profile,
dy
find rate of change of slope at y = 0.2 m.
dx
8. Find the value of x2+4x-4 = 0 by Newton Raphson method, after second approximation.
dv
10. = ( t 0 ) e t for slow vehicle, whose acceleration varies with this equation and V0
dt
dv dv
is initial velocity. = + v for vehicle that is overtaking. If = 2 at 3sec. =
dt dt
0.005, = 0.01 at t = 45s find distance
11.
If x=48 m is the distance where sign should be placed for 6/6 eyes, what would be x for
6/9 vision?
y y
12. Solve ( xdx + ydy ) cos = xy ( ydx xdy ) sin
x x
y
Key: xycos =c
x
13. SO2 - 30g/m3 at ambient pressure and temperature, Find its volume in ppm. If weight of
PR
SO2 = 64, and = 41.6 mol
T
Disclaimer This paper analysis and questions have been collated based on the memory of some students who
appeared in the paper and should be considered only as guidelines. GATEFORUM does not take any responsibility for
the correctness of the same.
3
Shared on QualifyGate.com
CE-GATE-2015
Sand
2m 15kN m3
= GWT
Silt
6m 18kN m3
Cc = 0.3 18kN m3
10m
e0 = 0.7 Clay
Dense
Find compression of clay layer if a load of 1500 kN is applied from top. Stress
distribution is of 2 vertical to 1 horizontal. Unit weight of water is 10.
16. 2
3
L
A, E, I
s
19. What is value of K in formula of development length for deformed bars as per
k bd
IS:456?
Disclaimer This paper analysis and questions have been collated based on the memory of some students who
appeared in the paper and should be considered only as guidelines. GATEFORUM does not take any responsibility for
the correctness of the same.
4
Shared on QualifyGate.com
CE-GATE-2015
20. Although the tamil version of _________ John Abraham starrer Madras Caf _________
cleared by the censor board with no cuts, film distributors ________ no takers for
releasing __________ this Friday
(Mr., was, found, on)
24. Extreme focus on syllabus and studying for test has become such a dominant concern of
Indian students that this has closed their minds to anything ________ to the requirements
of the exam
(A) related (B) extraneous (C) outside (D) useful
y
25.
x
L L 2 L
26. What is the relationship between seepage velocity and discharge velocity?
Key: (B)
V
Exp: VS = VS never be smaller than discharge velocity
n
27. Penetration of bitumen sample tested at 25C is 80. When heated to 60C, penetration is
measured as dmm d value cannot be lesser than ____ mm.
Key: 8
Disclaimer This paper analysis and questions have been collated based on the memory of some students who
appeared in the paper and should be considered only as guidelines. GATEFORUM does not take any responsibility for
the correctness of the same.
5
Shared on QualifyGate.com
CE-GATE-2015
28. A vehicle is moving in a circular curve and it has a super elevation of e when it does not
slide inwards. When friction factor is f
(A) e f (B) e f (C) e = f (D) Cannot be determined
Key: (A)
31. If velocity of flow is 1m/s, depth =0.8m, take g =10m/s2, find velocity post jump for wide
rectangular channel width B=2m.
Key: 2.73
V 1
Exp: F1 = =
gy 8
8F12 V2
F2 = 3
, = F2 .
1 + 1 + 8F2 gy 2
1
y2 1
= 1 + 1 + 8F12
y1 2
Solving using above formula V2 = 2.73 m / s
Disclaimer This paper analysis and questions have been collated based on the memory of some students who
appeared in the paper and should be considered only as guidelines. GATEFORUM does not take any responsibility for
the correctness of the same.
6
Shared on QualifyGate.com
CE-GATE-2015
33.
20 mm
2m
1.5 m
A 10 mm
30 kN
5
E = 210 MPa
Find deflection at point A(in mm)
34. In a survey work, three independent angles x,y,z were observed with weights Wx, Wy, Wz
respectively the weight of sum of angles x,y,z is
1 1 1 1
(B) (C) Wx+Wy+Wz (D) Wx2 + Wy2 + Wz2
Wx Wy Wz
(A) + +
1 1 1
+ +
Wx Wy Wz
35. A= N77o 50', magnetic bearing, binary magnetic declination 2o , Due to local attrition,
error in AO is free from local attrition OA, magnetic bearing S52o 20' W, AO=55o40,
Find true Bearing of A.
Key: N84o10o E
36. For what values of p the set of equations 2x + 3y = 5, 3x + py = 10 has no solution
q if x = 0
37. P.M.F of random variable x if P ( x,q ) = 1 q x =1
0 otherwise
If q=0.4, the variance of x is ________.
39. Which of these can not be used to describe free flow speed of traffic stream?
(A) Uf is speed when flow is negligible
(B) Uf is speed when density is negligible
(C) Affected by geometry and surface condition of road
(D) Flow is maximum and density is optimum
Disclaimer This paper analysis and questions have been collated based on the memory of some students who
appeared in the paper and should be considered only as guidelines. GATEFORUM does not take any responsibility for
the correctness of the same.
7
Shared on QualifyGate.com
CE-GATE-2015
100
42.
n
100
45
43. 60% of silt is fine-grained. The soil is semisolid at water content of 15% and 28% and
fluid like when water content when water content is greater than 40%. What is the
activity?
44. 20 m thick soil is between silty sand and gravel sand and found 30 mm settlement in 2
years
C V 0.003 cm 2 s, total settlement 50mm. What is the time required (in years) for final
settlement?
20 kN
45. M=?
3 1 1 3
(EI)
46. For steady incompressible flow through a closed conduit of uniform c/s the direction of
flow will always be
(A) Higher to lower elevation (B) Higher to lower Pressure
(C) Higher to lower Velocity (D) Higher to lower Piezometric head
47. In closed loop traverse of 1 km total length, the closing error in departure and latitude are
0.3 m and 0.4 m respectively. The relative precision of this traverse will be
(A) 1:5000 (B) 1:4000 (A) 1:3000 (A) 1:2000
Disclaimer This paper analysis and questions have been collated based on the memory of some students who
appeared in the paper and should be considered only as guidelines. GATEFORUM does not take any responsibility for
the correctness of the same.
8
Shared on QualifyGate.com
CE-GATE-2015
1
48. In an x-y plane, the velocity in x- direction is x2, and the fluid density is , then what is
x
the velocity in y-direction?
x
(A) (B) x / y (C) xy (D) xy
y
50. In a soil test, confined pressure is increased from-150 to 250 kPa, its pore pressure is
increased by 80 kPa, and its deviatory stress is increased by 25 kPa. Skemptons pore
pressure parameter B is ___________.
(A) 0.5 (B) 0.625 (C) 0.8 (D) 1
51. A circular pipe of 1 m diameter is laid on a bed slope 1 in 1000. Its Mannings coefficient
is 0.01 and the flow is upto its crest and the discharge is referred as Qfull. When is half full
the discharge is referred as Qhalf. Then find the ratio of Qfull/ Qhalf
(A) 1 (B) 2 (C) 2 (D) 4
Key: (A)
52. The below statements are related to air entrained concrete
(1) reduces water demand at given workability
(2) cyclic freezing and thawing at any environment
(A) 1 is correct (B) 2 is correct (C) Both are correct (D) None
P
53. EI, L
3EI 3EI
Ks =
2L3 2L3
EI, L
Disclaimer This paper analysis and questions have been collated based on the memory of some students who
appeared in the paper and should be considered only as guidelines. GATEFORUM does not take any responsibility for
the correctness of the same.
9
Shared on QualifyGate.com
CE-GATE-2015
Ps
Total Extension in spring =x= (1)
Ks
PL3 Ps L3 Ps L3 Ps
Also x = = (2)
3EI 3EI 3EI K s
solving (1) & (2)
P
Ps
Ps
Ps
Ps
Ps 1
=
P 4 Free body diagram
25%.
54.
P
0.85
Fdl = Fdr = 1.134 2
Fsi Fsr = 1.113
i = 0.444
Fq Fir = 0.2
FOS = 3
= 18 kN / m3
Find maximum eccentric load at net safe criteria.
Disclaimer This paper analysis and questions have been collated based on the memory of some students who
appeared in the paper and should be considered only as guidelines. GATEFORUM does not take any responsibility for
the correctness of the same.
10
Shared on QualifyGate.com
CE-GATE-2015
D
10
3m
C E
3m
B F
3m
A G
140 km
Construct
site
80 km 100 km
e
e
0.7y
0.164z
Disclaimer This paper analysis and questions have been collated based on the memory of some students who
appeared in the paper and should be considered only as guidelines. GATEFORUM does not take any responsibility for
the correctness of the same.
11