Professional Documents
Culture Documents
FOR
PLUMBING FIXTURE INSTALLATION
2.5.8.1 Connect the mixer to the angle valves for both hot and
cold water.
2.5.8.2 Apply Teflon tape to threaded fittings in reverse
direction of the tight. Do not over-tight.
2.5.8.3 Recheck the joints and tightness of all connections.
For Shower Tray:
Secure approved material request for shower tray.
Recheck the item for any damage, cracks, and dents upon delivery to the toilet.
Replace as if necessary.
Recheck the complete accessories of shower tray based on the manual.
Assemble the fixture and trim, fittings, faucets, and other components according the
manufacturer written instruction.
Locate the position of the fixture based on the approved shop drawing including point
of discharge to the trap.
Install the shower tray then level and plumb according to manufacturers' written
instructions and referenced standards.
Set shower tray in leveling bed of cement grout. Check from approved shop drawing
the required level of shower tray. Also set the shower tray leveled at 90º between floor
and wall at the centerline of the fixture outlet. Shower tray receptor outlet should be
on the same center of the waiting trap.
Recheck the alignment.
Install the accessories of shower tray and water connections for proper operation.
2.6.9.1 Recheck Connect the mixer to the angle valves for both
hot and cold water.
2.6.9.2 Apply Teflon tape to threaded fittings in reverse
direction of the tight.
2.6.9.3 Recheck the joints and tightness of all connections.
3. Verify that the installed fixtures are categories and types specified for locations
where installed. See approved shop drawing.
4. Check that fixtures are complete with trim, faucets, fittings and specified
components. See fixture manual.
5. Test installed fixtures after water system are pressurized and demonstrate
proper operation. Replace malfunctioning fixtures and components then retest.
6. If pretest is OK, prepare work inspection request.
7. Final test the fixtures installed with the presence of Inspection Engineer.
END