You are on page 1of 2

STRUCTURAL ANALYSIS & DESIGN

CODE AND SPECIFICATIONS:

The following structural codes and specifications shall be used in the structural analysis and design of the
reinforced concrete special moment resisting Single – Storey Residential with Two Basement.

1. National Structural Code of the Philippines 2015, NSCP2015, Volume 1 – Generally for the entire
Analysis and Design Requirements
2. Uniform Building Code 1997 Edition, UBC97 – For Building Seismic Analysis

DESIGN PARAMETERS

STORIES (LEVELS)
Storey
Levels Height (m)
Footing to
2nd Basement 3
nd
2 Basement to
1st Basement 3.2
1st Basement to
Ground Floor 3.2
Ground Floor to
Roof Beam 3.2

PROPERTIES
Beams Columns Slabs fc' fy
RC350X350 20.68
GB 200x300 RC 400x400 S100 Mpa 230 Mpa
2B1/3B2 250x350
2B5/3B5 300X450
2B4/3B4 200X300 (3000psi) (Grd30)
RB1 200X350
RB2 200X400
LOADS
Dead Load
1) Selfweight
Concrete unit weight = 24 kN/m3
2) Member Load
150mm CHB
100mm CHB

Floor Load Floors Roof


100mm slab 2.40 - kN/m2
roof framing - 0.30 kN/m2
roofing sheet - 0.10 kN/m2
Floor finish 1.10 - kN/m2
Ceiling 0.10 0.10 kN/m2
MEP 0.10 0.10 kN/m2
3.70 0.60

Live Load
1.9 kN/m2 0.60 kN/m2

Seismic
Parameters
UBC 97 / NSCP 2015
Zone = 4
Seismic Source Type = A
Importance Factor ( IV ) = 1.0 (Standard Occupancy)
R = 8.5 - Special Moment Frame
Structure is located 2.3 km from seismic source
Ct = 0.0731

Wind Parameters
Wind (ASCE 7-10 / NSCP 2015)
Vwind = 270 kph
I = 1.0
Exposure = B (typical residential structure)

You might also like