Professional Documents
Culture Documents
6 CORPORATE PARKWAY
GOOSE CREEK , SC . 29445
www . quoizel . com
STYLE NUMBER: WV1720BN
M Diffuser 1 pc
H
M
I
PREPARATION
● Before beginning installation of product, make sure all parts are present. Compare parts with package contents
list and diagram above. If any part is missing or damaged, do not attempt to assemble, install or operate the
product. Contact customer service for replacement part.
● Estimated Assembly Time: 20 - 30 minutes
● Tool Required for Assembly (not included): Flathead screwdriver, Phillips screwdriver, Pliers, Electrical tape,
Wire cutter, Safety glasses and (4) 100W A19 medium base bulbs .
● Helpful Tools (not included): Wire strippers.
1 OF 3
INSTALLATION INSTRUCTIONS STYLE NUMBER: WV1720BN
STEP 1:
a. Screw one end of the Stem with Hex Nut into bottom
center of the Socket Cluster. Using pliers, thread the
Hex Nut against the Socket Cluster and hand-tighten
until snug.
Socket Cluster
STEP 2:
a. Lift the Shade over the Stem with Hex Nut, attach the
Tabs in it to the ends of the Side Arms. Thread the Lock
Screws into the end of the Side Arms and hand-tighten
until snug to secure the Shade. Side Arm
Lock
Screw
Shade
STEP 3:
a. Place the Diffuser and the Rubber Washer over the end
of the Stem. The Diffuser should attach to the Studs in
the bottom edge of the Shade. Secure by threading the
Finial onto the Stem. Hand-tighten until snug.
Shade
Stud
2 OF 3
INSTALLATION INSTRUCTIONS STYLE NUMBER: WV1720BN
STEP 4:
a. Screw the Mounting Screws into the Crossbar, place Mounting Screw
Crossbar
the Lock Washers over the Mounting Screws and
thread the Hex Nuts onto the Mounting Screws as Hex Nut
shown. Secure the position of the Mounting Screws by
tightening the Hex Nuts against the Crossbar.
b. Secure the Crossbar to the Outlet Box with Outlet Box
Screws.
Lock Washer
Outlet Box
Outlet Box Screw
STEP 5:
Use Wire Connectors (not supplied) to connect the
WHITE OR RIBBED WHITE OR RIBBED
wires.
a. Connect the House Ground Wire to the Fixture Ground FROM HOUSE FROM FIXTURE
Wire.
b. Connect the House White (or Ribbed) Wire to the
Fixture Supply Wire (Black or Smooth Side). BLACK (OR RED) WIRE BLACK OR SMOOTH
c. Connect the House Black (or Red) Wire to the Fixture FROM FIXTURE
FROM HOUSE
Supply Wire (Black or Smooth Side).
d. Wrap each connection with approved electrical tape
and carefully stuff all of the connected wires into the GROUND WIRE GROUND WIRE
Outlet Box.
FROM HOUSE FROM FIXTURE
STEP 6:
a. Place the Ceiling Canopy over the Mounting Screws Outlet Box
and secure with Mounting Balls. Hand-tighten until
snug . Mounting Screw
Ceiling Canopy
Mounting Ball
STEP 7:
a. Install correct bulbs referring to fixture markings and/or labels for maximum wattage.
Your installation is completed now. Restore electricity. Retain this sheet for future reference.
3 OF 3