You are on page 1of 53

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws.

f you acquired this


document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 1 of 53




Vokswagen Securty, Remote Start, Keyess Entry &
Navgaton Wre Coors Verson 4.2









PLEASE NOTE

The information contained is accurate to the best of our knowledge. 12 Volt Resource LLC
makes no representation or warranty with respect to the information contained in this
document including its accuracy or completeness. 12 Volt Resource LLC disclaims all
liability or responsibility for errors or omissions therein or any decision made by the
recipient in reliance thereon.

nstallations should be attempted by experienced installers only. Proper installation
remains the responsibility of the installer. t is the installer's responsibility to test and verify
all circuitry with the proper test equipment prior to installation.


Additional nformation:

This information is sorted alphabetically by vehicle model. f there are multiple
years for a particular vehicle model, then the oldest year comes first.

The installation notes referenced below and the full installation guide are located
in the nstall nstructions & Notes folder on this CD-ROM.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 2 of 53

VoIkswagen BeetIe 1998-2004
FUNCTON COLOR LOCATON
Start: RED/BLACK (SMALL
GUAGE)
GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: LT. BROWN/RED GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BLACK/RED
Brake Light: RED/BLACK (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN/ORANGE OR GREEN/YELLOW AT COL
Parking Lights: GRAY/VOLET (+) AT SWTCH
Headlights:
Diesel Glow Plug: BLUE/GREEN PN #41 OF ECM ***
Clutch Bypass Wire: RED/GRAY (-) AT SWTCH ABOVE CLUTCH PEDAL

NOTES: * 2000 vehicle's may be equipped with a transponder immobilizer system. See
nstallation Note #144 - Bypassing Transponder Theft Systems. *** ECM s Located Below Left
Side Of Dash Panel. **** Unlocking The Doors With Either The Key Or Key Fob Will Turn On The
Dome Light, Doors And Dome Light Will Open And Come On Whenever The Alarm s Disarmed.
This can trigger aftermarket alarms. The only work around is to connect at each pin switch, using
diodes to isolate the pin switch from the vehicle.

VoIkswagen BeetIe 1998-2004

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS ***
OEM Alarm Disarm: DSARMS WTH
UNLOCK

Dome
Lights/Superv:
BROWN/YELLOW (-) N DRVER'S WNDSHELD PLLAR****
OEM Horn: BLUE/YELLOW (+) AT HORN
Power Lock: YELLOW/LT.BLUE (-) NSDE OF DRVER'S DOOR
Power Unlock: WHTE/LT. GREEN (-) NSDE OF DRVER'S DOOR ******
Trunk Release: BROWN/VOLET (-) AT TRUNK RELEASE RELAY
Alarm nput Wire: BROWN/YELLOW (-) N DRVER'S WNDSHELD PLLAR****

NOTES: ** Located in harness running to lock cylinder inside of driver's door. ****** Double Pulse
Required To Unlock Both Doors. See Note #201 Negative Trigger Door Locks.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 3 of 53

Make: Model: Year:
VoIkswagen Cabrio 1995-2002


FUNCTON COLOR LOCATON
Start: RED/BLACK (+) GNTON SWTCH HARNESS
gnition #1: BLACK (+) GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: BLACK/YELLOW GNTON SWTCH HARNESS
Brake Light: BLACK/RED AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLACK/RED AT COL
Parking Lights: DRVER - GRAY/BLACK PASSENGER - GRAY/RED(+) @ SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

VoIkswagen Cabrio 1995-2002

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (+) GNTON SWTCH HARNESS
OEM Alarm Disarm: SEE NOTE WLL DSARM WHEN DOORS ARE
UNLOCKED
Dome
Lights/Superv:
BROWN/WHTE (-) DRVER KCK PANEL
OEM Horn:
Power Lock: YELLOW DRVER'S KCK PANEL *
Power Unlock: RED DRVER'S KCK PANEL *
Trunk Release: GRAY (+) UNDER REAR SEAT-DRVER SDE
Alarm nput Wire: BROWN/WHTE (-) DRVER KCK PANEL

NOTES: * Requires Two Positive Pulses To Unlock Doors. Some CABRO Will Have Door Lock
Wires GREEN (Unlock) & GRAY (Lock). See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 4 of 53

Make: Model: Year:
VoIkswagen CabrioIet 1986-1993
FUNCTON COLOR LOCATON
Start: RED/BLACK GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN/RED GNTON SWTCH HARNESS
Brake Light: RED/BLACK (+) SWTCH ON MASTER CYLNDER
Tach Signal: RED/BLACK AT COL OR DASH TACHOMETER *
Parking Lights: GRAY/GREEN (+) AT LGHT SWTCH OR FUSE BOX
Headlights: WHTE/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Some (pre 91) Models Carburated.

VoIkswagen CabrioIet 1986-1993

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BROWN/WHTE (-) AT PN SWTCH
OEM Horn: BROWN/BLUE (-) HORN SWTCH OR RELAY
Power Lock: ADD ACTUATOR POWER DOOR LOCKS MUST BE ADDED *
Power Unlock: ADD ACTUATOR POWER DOOR LOCKS MUST BE ADDED *
Trunk Release: N/A
Alarm nput Wire: BROWN/WHTE (-) AT PN SWTCH

NOTES: * See Note #204- Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 5 of 53

Make: Model: Year:
VoIkswagen Corrado 1990-1991
FUNCTON COLOR LOCATON
Start: RED/BLACK GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN/RED GNTON SWTCH HARNESS
Brake Light: BLACK/RED (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: RED/BLACK AT COL OR DASH TACHOMETER
Parking Lights: DRVER - GRAY/BLACK PASSENGER - GRAY/RED (+) LGHT
SWTCH
Headlights: WHTE/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

VoIkswagen Corrado 1990-1991

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BROWN/WHTE (-) AT PN SWTCH
OEM Horn: BROWN/BLUE (-) STEERNG COLUMN HARNESS
Power Lock: RED/YELLOW DRVER KCK *
Power Unlock: RED/BLACK PANEL
Trunk Release: N/A
Alarm nput Wire: BROWN/WHTE (-) AT PN SWTCH

NOTES: * See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 6 of 53

Make: Model: Year:
VoIkswagen Corrado 1992


FUNCTON COLOR LOCATON
Start: RED/BLACK GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN/RED GNTON SWTCH HARNESS
Brake Light: BLACK/RED (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN AT COL (4 CYLNDER) *
Parking Lights: DRVER - GRAY/BLACK PASSENGER - GRAY/RED (+) LGHT
SWTCH
Headlights: WHTE/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * V-6 Enigne Has RPM Sensor On Lower Front Of Engine. On Engine Control Module
(ECM) This Wire s GREEN At Pin #68, Output To Tachometer s GREEN/ BLACK At Pin #22.
ECM Located On Center Of Plenum At Rear Of Engine Compartment.

VoIkswagen Corrado 1992

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BROWN/WHTE (-) AT PN SWTCH
OEM Horn: BROWN/BLUE (-) STEERNG COLUMN HARNESS
Power Lock: RED/YELLOW DRVER KCK PANEL *
Power Unlock: RED/BLACK DRVER KCK PANEL *
Trunk Release: N/A
Alarm nput Wire: BROWN/WHTE (-) AT PN SWTCH

NOTES: *See Note #202 - Positive Pulse Door Lock Diagram.


Make: Model: Year:

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 7 of 53
VoIkswagen Corrado 1993


FUNCTON COLOR LOCATON
Start: RED/BLACK GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN/RED GNTON SWTCH HARNESS
Brake Light: BLACK/RED (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN
ENGNE CONTROL MODULE OR DASH
TACH *
Parking Lights: GRAY/GREEN AT HEADLGHT SWTCH
Headlights: WHTE/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Engine Control Module Located On Center Of Plenum At rear Of Engine
Compartment.

VoIkswagen Corrado 1993

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BROWN/WHTE (-) ETHER PN SWTCH OR NTEROR LGHT
OEM Horn: BROWN/BLUE HORN SWTCH OR RELAY (BOTH NEG (-))
Power Lock: RED/YELLOW ETHER KCK PANEL OR
Power Unlock: RED/BLACK AT PUMP ON PASSENGER SDE *
Trunk Release: N/A
Alarm nput Wire: BROWN/WHTE (-) ETHER PN SWTCH OR NTEROR LGHT

NOTES: * See Note #202 - Positive Pulse Door Lock Diagram.


Make: Model: Year:
VoIkswagen Corrado 1994-1995


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 8 of 53

FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: BLACK/YELLOW GNTON SWTCH HARNESS (HEAT/AC)
Brake Light: BLACK/RED (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN/BLACK AT ENGNE CONTROL MODULE *
Parking Lights: GRAY/GREEN (+) AT HEADLGHT SWTCH
Headlights: WHTE/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Engine Control Module Located On Center Of Firewall n Engine Compartment. **
BLACK/GRAY (+) Wire Changes To BLACK/BLUE (+).

VoIkswagen Corrado 1994-1995

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BROWN/WHTE (-) ETHER PN SW. OR AT NTEROR LGHT
OEM Horn: BROWN/BLUE (-) STEERNG COLUMN HARNESS
Power Lock: RED/YELLOW ETHER KCK PANEL OR AT PUMP
Power Unlock: RED/BLACK ON PASSENGER SDE OF TRUNK *
Trunk Release: N/A
Alarm nput Wire: BROWN/WHTE (-) ETHER PN SW. OR AT NTEROR LGHT

NOTES: *See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 9 of 53

Make: Model: Year:
VoIkswagen Corrado SLC 1992


FUNCTON COLOR LOCATON
Start: RED/BLACK GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3:
Accessory: BROWN/RED GNTON SWTCH HARNESS
Brake Light: BLACK/RED (+) SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLACK/RED AT COL
Parking Lights: GRAY/GREEN (+) AT LGHT SWTCH OR FUSE BOX
Headlights: WHTE/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

VoIkswagen Corrado SLC 1992

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BROWN/WHTE (-) AT PN SWTCH
OEM Horn: BROWN/BLUE (-) HORN SWTCH OR RELAY
Power Lock: RED/YELLOW ETHER KCK PANEL AT #202
Power Unlock: RED/BLACK PUMP N PASS. SDE TRUNK
Trunk Release: N/A
Alarm nput Wire: BROWN/WHTE (-) AT PN SWTCH

NOTES: See Note #202- See Positive Pulse Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 10 of 53

Make: Model: Year:
VoIkswagen Eurovan 1993


FUNCTON COLOR LOCATON
Start: RED/BLACK GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN/RED GNTON SWTCH HARNESS
Brake Light: BLACK/RED (+) SWTCH ON BRACKET ABOVE BRAKE
PEDAL
Tach Signal: GREEN/BLACK
AT COL OR GREEN AT DASH
TACHOMETER
Parking Lights: GRAY/GREEN (+) AT LGHT SWTCH
Headlights: WHTE/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: 5 Cylinder Engine.

VoIkswagen Eurovan 1993

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BROWN/WHTE (-) AT PN SWTCH
OEM Horn: BROWN/BLUE (-) HORN SWTCH OR RELAY
Power Lock: YELLOW 4 PN CONNECTOR N
Power Unlock: WHTE DRVER KCK PANEL**
Trunk Release: N/A
Alarm nput Wire: BROWN/WHTE (-) AT PN SWTCH

NOTES: **See Note #201 Negative Trigger Door Locks


Make: Model: Year:
VoIkswagen Eurovan 1994-1997

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 11 of 53


FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: BLACK/YELLOW GNTON SWTCH HARNESS (HEAT/AC)
Brake Light: BLACK/RED (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN/RED AT ENGNE CONTROL MODULE *
Parking Lights: GRAY/BLACK (DR) & GRAY/RED (PS) (+) AT HEADLGHT SW. **
Headlights: WHTE/BLACK (+) AT HEALDGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Engine Control Module Located On Driver Rear Of Engine Compartment. ** Split
Parking Light System, Use Two 6 Amp Diodes Or Two S.P.D.T. Relays To solate.

VoIkswagen Eurovan 1994-1997

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BROWN/WHTE (-) AT ANY PN SWTCH
OEM Horn: BROWN/BLUE (-) STEERNG COLUMN HARNESS
Power Lock: YELLOW DRVER KCK ***
Power Unlock: WHTE PANEL
Trunk Release: N/A
Alarm nput Wire: BROWN/WHTE (-) AT ANY PN SWTCH

NOTES: ***See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 12 of 53

Make: Model: Year:
VoIkswagen Euronvan 1998-2000


FUNCTON COLOR LOCATON
Start: RED/BLACK GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: YELLOW GNTON SWTCH HARNESS
Brake Light: RED/BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN AT COL
Parking Lights: GRAY/BLACK & GRAY/RED (+) AT LGHT SWTCH *
Headlights: WHTE (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

VoIkswagen Euronvan 1998-2000

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BROWN/WHTE (-) AT PN SWTCH
OEM Horn: BROWN/BLACK (-) STEERNG COLUMN HARNESS
Power Lock: YELLOW (+) 4-PN PLUG N DRVER'S KCK PANEL
Power Unlock: WHTE (+) 4-PN PLUG N DRVER'S KCK PANEL*
Trunk Release: N/A
Alarm nput Wire: BROWN/WHTE (-) AT PN SWTCH

NOTES: * See Note #202 Positive Pulse Door Locks


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 13 of 53

Make: Model: Year:
VoIkswagen EuroVan 2001-2003


FUNCTON COLOR LOCATON
Start: Red/Black gnition Switch Harness
gnition #1: Black gnition Switch Harness
gnition #2: N/A
gnition #3: N/A
Accessory: Yellow gnition Switch Harness
Brake Light: Red/Black At Brake Switch
Tach Signal: Green At Coil
Parking Lights: See Notes See notes*
Headlights: No Color Available Please call with information
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES: *Parking light is split system type. Must use relays to individualy power and isolate the
driver and passenger circuits. Gray/Black=Driver. Gray/Red=Passenger. Wires are at headlight
switch.

VoIkswagen EuroVan 2001-2003

FUNCTON COLOR LOCATON
Constant +12 Volts: Red gnition Switch Harness
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
Brown/White (-) At passenger pin switch
OEM Horn: Brown/Black At Steering Column Harness
Power Lock: Yellow Driver Kick Panel*
Power Unlock: White Driver Kick Panel
Trunk Release: N/A
Alarm nput Wire: Brown/White (-) At passenger pin switch

NOTES: *Positive Pulse type lock/unlock system


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 14 of 53

Make: Model: Year:
VoIkswagen Fox 1987-1993


FUNCTON COLOR LOCATON
Start: RED/BLACK GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN/RED GNTON SWTCH HARNESS
Brake Light: RED/BLACK (+) AT STOP LGHT SWTCH
Tach Signal: RED/BLACK AT COL
Parking Lights: DRVER - GRAY/BLACK PASSENGER - GRAY/RED (+) LGHT
SWTCH
Headlights: WHTE (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * WARNNG!! This Car Comes With Manual Transmission Only. WARNNG! REMOTE
START *MUST* BE A MANUAL TRANSMSSON SPECFC UNT!

VoIkswagen Fox 1987-1993

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BROWN/WHTE (-) AT PN SWTCH
OEM Horn: BROWN/BLACK (-) AT HORN SWTCH OR RELAY
Power Lock: ADD ACTUATOR POWER DOOR LOCKS MUST BE ADDED
#204
Power Unlock: ADD ACTUATOR POWER DOOR LOCKS MUST BE ADDED
#204
Trunk Release: N/A
Alarm nput Wire: BROWN/WHTE (-) AT PN SWTCH

NOTES: See Note #204 - Adding Actuator Door Lock Diagram.


VoIkswagen GoIf 1985


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 15 of 53

FUNCTON COLOR LOCATON
Start: BLACK/RED GNTON SWTCH HARNESS
gnition #1: YELLOW GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory:
Brake Light: BLACK/RED (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREN/BLUE AT COL
Parking Lights: GRAY (+) AT LGHT SWTCH
Headlights: WHTE/BLACK AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

VoIkswagen GoIf 1985

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BROWN/WHTE (-) AT PN SWTCH
OEM Horn: BLACK/YELLOW (-) STEERNG COLUMN HARNESS
Power Lock: ADD ACTUATOR POWER DOOR LOCKS MUST BE ADDED
#204
Power Unlock: ADD ACTUATOR POWER DOOR LOCKS MUST BE ADDED
#204
Trunk Release:
Alarm nput Wire: BROWN/WHTE (-) AT PN SWTCH

NOTES: See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 16 of 53

Make: Model: Year:
VoIkswagen GoIf 1986


FUNCTON COLOR LOCATON
Start: BLACK/RED GNTON SWTCH HARNESS
gnition #1: YELLOW GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3:
Accessory:
Brake Light: BLACK/RED(+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN/BLUE AT COL OR DASH TACHOMETER *
Parking Lights: GRAY (+) AT LGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * 1988-89 Models Only.

VoIkswagen GoIf 1986

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BROWN/WHTE (-) AT PN SWTCH
OEM Horn:
Power Lock: ADD ACTUATOR ACTUATOR NEEDED N DRVER DOOR
#204
Power Unlock: ADD ACTUATOR ACTUATOR NEEDED N DRVER DOOR
#204
Trunk Release:
Alarm nput Wire: BROWN/WHTE (-) AT PN SWTCH

NOTES: See Note #204 - Adding Actuator Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 17 of 53

GOLF 1987 -1992



KEY T-HARNESS MMOBLZER
N/A N/A N/A

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER RED/BLACK (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLACK/YELLOW (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + )
GRAY/BLACK (+) and
GRAY/RED (+) Use both, See
NOTE *1
@ HEADLGHT SWTCH,
POWER LOCK
ADD ACTUATORS, See NOTE
*2
TO DRVERS DOOR ONLY,
POWER UNLOCK
ADD ACTUATORS, See NOTE
*2
TO DRVERS DOOR ONLY,
DOOR TRGGER BROWN/WHTE (-)
@ DRVERS DOOR PN
SWTCH
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 18 of 53

HORN N/A
TACH GREEN @ GNTON COL
WAT TO START LGHT N/A
BRAKE BLACK/RED (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT N/A

EXTRA NFORMATON
NOTE *1 this vehicle has (2) PARKNG LGHT WRES that will require (2) EXTRA RELAYS,
FUNCTON #775 to connect, . NOTE *2 the POWER DOOR LOCKNG SYSTEM on this vehicle,
uses aCENTRAL DOOR LOCKNG SYSTEM and that requires a DOOR LOCK ACTUATOR
FUNCTON #742 to be placed inside the DRVERS DOOR to operate as a KEYLESS ENTRY
SYSTEM, to connect, .





This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 19 of 53

GOLF III 1993 -1998



KEY T-HARNESS MMOBLZER
N/A N/A N/A

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) (10 Gauge wire)
GNTON SWTCH HARNESS,
See NOTE *1
STARTER
RED/BLACK (+) (10 Gauge
wire)
GNTON SWTCH HARNESS,
See NOTE *1
STARTER 2 N/A
GNTON 1 BLACK (+) (16 Gauge wire)
GNTON SWTCH HARNESS,
See NOTE *1
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLACK/YELLOW (+) (12 Gauge
wire)
GNTON SWTCH HARNESS,
See NOTE *1
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + )
GRAY/BLACK (+) and
GRAY/RED (+) Use both, See
NOTE *1
@ HEADLGHT SWTCH,
POWER LOCK
YELLOW/RED or GRAY (TYPE
A)
N DRVERS KCK PANEL, at
DOOR HARNESS
POWER UNLOCK
RED/BLACK or GREEN (TYPE
A) (Requires Double Pulse)
N DRVERS KCK PANEL, at
DOOR HARNESS
DOOR TRGGER BROWN/WHTE (-)
N DRVERS KCK PANEL or @
ALARM MODULE, See NOTE
*4
DOMELGHT SUPERVSON USE DOOR TRGGER N DRVERS KCK PANEL

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 20 of 53

TRUNK RELEASE GRAY (+) See NOTE *3


@ TRUNK RELEASE SWTCH,
See DAGRAM
SLDNG POWER DOOR N/A
HORN BLACK/YELLOW (+) BEHND FUSE BOX
TACH BLACK/RED @ GNTON COL
WAT TO START LGHT N/A
BRAKE RED/BLACK (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM
DSARMS WTH UNLOCK,
Single Pulse Disarms

ANT-THEFT N/A

EXTRA NFORMATON
NOTE *1 the GNTON HARNESS is a BG LOOP at THE BACK of the FUSE BOX. NOTE *2 the
HDDEN RELEASE TAB for the HEADLGHT SWTCH, is on the UPPER LEFT SDE of the SWTCH.
You MUST CUT both of the PARKNG LGHT WRES and SOLATE the SWTCH SDE of the wires
with a RELAY FUNCTON #775 so that the switch does not see (+) 12 volts. You can also use the
HAZARD WRES, the BLACK/WHTE and BLACK/GREEN these are (+) POSTVE WRE and are
located at the STEERNG COLUMN. NOTE *3 the GRAY wire is GROUNDED by the HATCH
RELEASE SWTCH at rest, cut this wire in half and use a EXTRA RELAY, FUNCTON #775 to
isolate the switch side of the trunk release wire from seeing (+) 12volts. to connect, . NOTE *4 the
ALARM MODULE is located BEHND the HEADLGHT Switch.




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 21 of 53

GOLF with Power Windows 1999 -2001



KEY
T-
HARNES
S
MMOBLZER
N/A N/A
VOLKSWAGEN'S TRANSPONDER ANT-THEFT System, Requires Module and Extra
gnition Key

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER RED/GRAY (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLACK/RED (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + )
GRAY/BLACK (+) and
GRAY/RED (+) Use both, See
NOTE *1
N DRVERS KCK PANEL,
POWER LOCK YELLOW/ BLUE (TYPE B)
@ DRVERS DOOR MODULE,
See NOTE *2
POWER UNLOCK
GREEN/RED (TYPE B)
(Requires Double Pulse)
@ DRVERS DOOR MODULE,
See NOTE *2
DOOR TRGGER BLUE/GRAY (-)
@ COMFORT Module, See
NOTE *3
DOMELGHT SUPERVSON USE DOOR TRGGER

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 22 of 53

TRUNK RELEASE BROWN/BLACK (-)


@ COMFORT Module, See
NOTE *3
SLDNG POWER DOOR N/A
HORN BLACK/YELLOW (+)
@ COMFORT Module, See
NOTE *3
TACH See NOTE *4 @ GNTON COL
WAT TO START LGHT N/A
BRAKE RED/BLACK (+) N DRVERS KCK PANEL
FACTORY ALARM DSARM
DSARMS WTH UNLOCK,
Single Pulse Disarms

ANT-THEFT
TRANSPONDER ANT-THEFT
SYSTEM, REQURES BYPASS
MODULE AND EXTRA
GNTON KEY
@ GNTON SWTCH
TUMBLER

EXTRA NFORMATON
NOTE *1 this vehicle has 2 PARKNG LGHT WRES that will require (2) EXTRA RELAYS,
FUNCTON #775, to connect, . NOTE *2 the DRVERS DOOR MODULE is located in the DRVERS
DOOR. NOTE *3 the COMFORT Module is located UNDER the DRVERS SDE of the DASH, this is
the MAN MODULE. NOTE *4 on the 4-CYLNDER ENGNE, use the GREEN/STRPE wire, and on
the 6-CYLNDER ENGNE, use the PURPLE/STRPE or BLACK/STRPE wire.




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 23 of 53

GOLF with Power Windows 2002



KEY
T-
HARNES
S
MMOBLZER
N/A N/A
VOLKSWAGEN'S TRANSPONDER ANT-THEFT System, Requires Module and Extra
gnition Key

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER RED/GRAY (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLACK/RED (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + )
GRAY/BLACK (+) and
GRAY/RED (+) Use both, See
NOTE *1
N DRVERS KCK PANEL,
POWER LOCK YELLOW/ BLUE (TYPE B)
@ DRVERS DOOR MODULE,
See NOTE *2
POWER UNLOCK
GREEN/RED or
YELLOW/GREEN (TYPE B)
(Requires Double Pulse)
@ DRVERS DOOR MODULE,
See NOTE *2
DOOR TRGGER BLUE/GRAY (-)
@ COMFORT Module, See
NOTE *3
DOMELGHT SUPERVSON USE DOOR TRGGER

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 24 of 53

TRUNK RELEASE BROWN/BLACK (-)


@ COMFORT Module, See
NOTE *3
SLDNG POWER DOOR N/A
HORN BLACK/YELLOW (+)
@ COMFORT Module, See
NOTE *3
TACH
Any wire NOT BLACK/PURPLE
or BROWN
@ ANY GNTON COL
WAT TO START LGHT N/A
BRAKE RED/BLACK (+) N DRVERS KCK PANEL
FACTORY ALARM DSARM
DSARMS WTH UNLOCK,
Single Pulse Disarms

ANT-THEFT
TRANSPONDER ANT-THEFT
SYSTEM, REQURES BYPASS
MODULE AND EXTRA
GNTON KEY
TRANSPONDER @ GNTON
SWTCH TUMBLER

EXTRA NFORMATON
NOTE *1 this vehicle has (2) PARKNG LGHT wires that will require (2) EXTRA RELAY, FUNCTON
#775, to connect, . NOTE *2 the DRVERS DOOR MODULE is located NSDE the DRVERS DOOR.
NOTE *3 the COMFORT MODULE is located UNDER the DRVERS SDE of the DASH, this is the
MAN MODULE.





This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 25 of 53

GOLF with Power Windows 2003 -2004



KEY
T-
HARNES
S
MMOBLZER
N/A N/A
VOLKSWAGEN'S TRANSPONDER ANT-THEFT System, Requires Module and Extra
gnition Key

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER
RED/BLACK (+) or RED/GRAY
(+)
GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLACK/RED (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + )
GRAY/BROWN (+) and
GRAY/PURPLE (+) Use both,
See NOTE *1
@ HEADLGHT SWTCH,
POWER LOCK YELLOW/ BLUE (TYPE B)
@ DRVERS DOOR MODULE,
See NOTE *2
POWER UNLOCK
GREEN/RED or
YELLOW/GREEN (TYPE B)
(Requires Double Pulse)
@ DRVERS DOOR MODULE,
See NOTE *2
DOOR TRGGER BROWN/YELLOW (-)
@ COMFORT Module, 23-Pin
Plug, Pin 1, See NOTE *3

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 26 of 53

DOMELGHT SUPERVSON BLUE/GRAY (-)


@ COMFORT Module, 23-Pin
Plug, Pin 21, See NOTE *3
TRUNK RELEASE
BROWN/GREEN to
GREEN/BROWN (-)
@ COMFORT Module, 23-Pin
Plug, Pin 2, See NOTE *3
SLDNG POWER DOOR N/A
HORN BLACK/YELLOW (+)
@ HORN RELAY, UNDER
DRVERS DASH
TACH
Any wire NOT RED/PURPLE or
BROWN
@ ANY FUEL-NJECTOR
WAT TO START LGHT N/A
BRAKE RED/BLACK (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM
DSARMS WTH UNLOCK,
Single Pulse Disarms

ANT-THEFT
TRANSPONDER ANT-THEFT
SYSTEM, REQURES BYPASS
MODULE AND EXTRA
GNTON KEY
TRANSPONDER @ GNTON
SWTCH TUMBLER

EXTRA NFORMATON
NOTE *1 this vehicle has (2) PARKNG LGHT wires that will require (2) EXTRA RELAYS,
FUNCTON #775, to connect, . NOTE *2 the DRVERS DOOR MODULE is located NSDE the
DRVERS DOOR. NOTE *3 the COMFORT MODULE is located UNDER the DRVERS SDE of the
DASH, this is the MAN MODULE.





This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 27 of 53

GTI 1995 -1998



KEY T-HARNESS MMOBLZER
N/A N/A N/A

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) (10 Gauge wire) GNTON SWTCH HARNESS
STARTER
RED/BLACK (+) (10 Gauge
wire)
GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK (+) (16 Gauge wire) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLACK/YELLOW (+) (12 Gauge
wire)
GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + )
GRAY/BLACK (+) and
GRAY/RED (+) Use both, See
NOTE *1
@ HEADLGHT SWTCH,
POWER LOCK
YELLOW/RED or GRAY (TYPE
A)
N DRVERS KCK PANEL, at
DOOR HARNESS
POWER UNLOCK
RED/BLACK or GREEN (TYPE
A) (Requires Double Pulse)
N DRVERS KCK PANEL, at
DOOR HARNESS
DOOR TRGGER BROWN/WHTE (-)
N DRVERS KCK PANEL or at
ALARM MODULE, See NOTE
*3
DOMELGHT SUPERVSON BROWN/BLACK (-)
N DRVERS KCK PANEL or
ALARM MODULE, See NOTE
*3

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 28 of 53

TRUNK RELEASE See NOTE *2 @ TRUNK RELEASE SWTCH,


SLDNG POWER DOOR N/A
HORN BLACK/YELLOW (+) BEHND FUSE BOX
TACH BLACK/PURPLE @ COL PACK
WAT TO START LGHT N/A
BRAKE RED/BLACK (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM
DSARMS WTH UNLOCK,
Single Pulse Disarms

ANT-THEFT N/A

EXTRA NFORMATON
NOTE *1 the HDDEN RELEASE TAB for the HEADLGHT SWTCH is on the Upper LEFT SDE of
the switch. You MUST CUT both of the Parking Light wires and SOLATE the Switch side of the wires
with a relay so that the switch does not see (+) 12 volts. You can also use the Hazard wires the
BLACK/WHTE and BLACK/GREEN these are (+) Positive wires and are located at the Steering
Column. . NOTE *2 the GRAY wire is grounded by the Switch at rest, cut this wire in half and use a
relay Part #775 to isolate the switch side of the trunk release wire from seeing (+) 12volts. NOTE *3
the ALARM MODULE is located BEHND the HEADLGHT SWTCH.





This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 29 of 53

GTI with Power Windows 1999 -2002



KEY
T-
HARNES
S
MMOBLZER
N/A N/A
VOLKSWAGEN'S TRANSPONDER ANT-THEFT System, Requires Module and Extra
gnition Key

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER RED/GRAY (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLACK/RED (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + )
GRAY/BLACK (+) and
GRAY/RED (Right) (+) Use
both, See NOTE *1
N DRVERS KCK PANEL,
POWER LOCK YELLOW/ BLUE (TYPE B)
@ DRVERS DOOR MODULE,
See NOTE *2
POWER UNLOCK
GREEN/RED (TYPE B)
(Requires Double Pulse)
@ DRVERS DOOR MODULE,
See NOTE *2
DOOR TRGGER BLUE/GRAY (-)
@ COMFORT Module, See
NOTE *3
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE BROWN/BLACK (-)
@ COMFORT Module, See
NOTE *3

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 30 of 53

SLDNG POWER DOOR N/A


HORN BLACK/YELLOW (+)
@ COMFORT Module, See
NOTE *3
TACH
Any wire NOT BLACK/PURPLE
or BROWN
@ GNTON COL
WAT TO START LGHT N/A
BRAKE RED/BLACK (+) N DRVERS KCK PANEL
FACTORY ALARM DSARM
DSARMS WTH UNLOCK,
Single Pulse Disarms

ANT-THEFT
TRANSPONDER ANT-THEFT
SYSTEM, REQURES BYPASS
MODULE AND EXTRA
GNTON KEY
TRANSPONDER @ GNTON
SWTCH TUMBLER

EXTRA NFORMATON
NOTE *1 this vehicle has (2) PARKNG LGHT wires that will require (2) EXTRA RELAYS,
FUNCTON #775, to connect, . NOTE *2 the DRVERS DOOR MODULE is located NSDE the
DRVERS DOOR. NOTE *3 the COMFORT MODULE is the MAN MODULE and is located under the
DRVERS SDE of the DASH.




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 31 of 53

GTI with Power Windows 2003 -2004



KEY
T-
HARNES
S
MMOBLZER
N/A N/A
VOLKSWAGEN'S TRANSPONDER ANT-THEFT System, Requires Module and Extra
gnition Key

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER
RED/BLACK (+) or RED/GRAY
(+)
GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLACK/RED (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + )
GRAY/BROWN (+) and
GRAY/PURPLE (+) Use both,
See NOTE *1
@ HEADLGHT SWTCH,
POWER LOCK YELLOW/ BLUE (TYPE B)
@ DRVERS DOOR MODULE,
See NOTE *2
POWER UNLOCK
GREEN/RED or
YELLOW/GREEN (TYPE B)
(Requires Double Pulse)
@ DRVERS DOOR MODULE,
See NOTE *2
DOOR TRGGER BROWN/YELLOW (-)
@ COMFORT Module, 23-Pin
Plug, Pin 1, See NOTE *3

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 32 of 53

DOMELGHT SUPERVSON BLUE/GRAY (-)


@ COMFORT Module, 23-Pin
Plug, Pin 21, See NOTE *3
TRUNK RELEASE
BROWN/GREEN to
GREEN/BROWN (-)
@ COMFORT Module, 23-Pin
Plug, Pin 2, See NOTE *3
SLDNG POWER DOOR N/A
HORN BLACK/YELLOW (+)
@ HORN RELAY UNDER
DRVERS DASH
TACH
Any wire NOT RED/PURPLE or
BROWN
@ ANY FUEL-NJECTOR
WAT TO START LGHT N/A
BRAKE RED/BLACK (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM
DSARMS WTH UNLOCK,
Single Pulse Disarms

ANT-THEFT
TRANSPONDER ANT-THEFT
SYSTEM, REQURES BYPASS
MODULE AND EXTRA
GNTON KEY
TRANSPONDER @ GNTON
SWTCH TUMBLER

EXTRA NFORMATON
NOTE *1 this vehicle has (2) PARKNG LGHT WRES that will require (2) EXTRA RELAYS,
FUNCTON #775 to connect, . NOTE *2 the DRVERS DOOR MODULE is located NSDE the
DRVERS DOOR. NOTE *3 the COMFORT MODULE is the MAN MODULE and is located under the
DRVERS SDE of the DASH.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 33 of 53

VoIkswagen Jetta 1981-1989


FUNCTON COLOR LOCATON
Start: RED/BLACK GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3:
Accessory:
Brake Light: RED/YELLOW (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: RED/BLACK AT COL *
Parking Lights: GRAY/GREEN (+) AT LGHT SWTCH OR FUSE BOX
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * 1986-89 Models Only.

VoIkswagen Jetta 1981-1989

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BROWN/WHTE OR
BLACK
(-) AT PN SWTCH
OEM Horn:
Power Lock: RED/YELLOW DRVER KCK #202
Power Unlock: RED/WHTE PANEL
Trunk Release:
Alarm nput Wire: BROWN/WHTE OR
BLACK
(-) AT PN SWTCH

NOTES: See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 34 of 53

Make: Model: Year:
VoIkswagen Jetta 1990-1992


FUNCTON COLOR LOCATON
Start: RED/BLACK OR GRAY GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3:
Accessory:
Brake Light: RED/YELLOW (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: RED/BLACK AT COL
Parking Lights: DRVER - GRAY/BLACK PASSENGER - GRAY/RED (+) LGHT
SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

VoIkswagen Jetta 1990-1992

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BROWN/WHTE OR BROWN/BLACK (-) AT PN SWTCH
OEM Horn:
Power Lock: RED/YELLOW DRVER'S KCK PANEL *
Power Unlock: RED/WHTE DRVER'S KCK PANEL *
Trunk Release:
Alarm nput Wire: BROWN/WHTE OR BROWN/BLACK (-) AT PN SWTCH

NOTES: * See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 35 of 53

Make: Model: Year:
VoIkswagen Jetta 1993-1994


FUNCTON COLOR LOCATON
Start: RED/BLACK GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: N/A
Brake Light: BLACK/RED AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: RED/BLACK AT COL
Parking Lights: GRAY/BLACK (DRVER) GRAY/RED (PASS) HEADLGHT SWTCH
(+)
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * OEM Alarm Standard. Must lock/Unlock doors to Arm/Disarm OEM Alarm.

VoIkswagen Jetta 1993-1994

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: See Note Below *
Dome
Lights/Superv:
BROWN/WHTE (-) DRVER KCK PANEL
OEM Horn:
Power Lock: GRAY N DRVER DOOR AT PUMP * #202
Power Unlock: GREEN N DRVER DOOR AT PUMP * #202
Trunk Release:
Alarm nput Wire: BROWN/WHTE (-) DRVER KCK PANEL

NOTES: See Note #202 - Positive Pulse Door Lock Diagram. Door Locks At OEM Alarm Module-
YELLOW/RED (Lock) & RED/BLACK (Unlock)


Make: Model: Year:
VoIkswagen Jetta 1994

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 36 of 53


FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: BLACK/YELLOW GNTON SWTCH HARNESS (HEAT/AC)
Brake Light: RED/BLACK (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN/BLACK AT ENGNE CONTROL MODULE *
Parking Lights: GRAY/BLACK (DR) & GRAY/RED (PS) (+) AT HEADLGHT
SWTCH
Headlights: WHTE/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Engine Control Module Located On Center Of Firewall n Engine Compartment. **
Transmission Control Module Located Under Rear Seat On Driver Side. *** Park/Neutral Position
Relay Located n Fuse/Relay Center Behind Driver Dash.

VoIkswagen Jetta 1994

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BROWN/WHTE (-) AT ANY PN SWTCH
OEM Horn: BROWN/BLUE (-) STEERNG COLUMN HARNESS
Power Lock: GREEN DRVER KCK #202
Power Unlock: GRAY OR
BLACK/WHTE
PANEL
Trunk Release: GRAY (+) AT TRUNK RELEASE SWTCH
Alarm nput Wire: BROWN/WHTE (-) AT ANY PN SWTCH

NOTES: See Note #202 - Positive Pulse Door Lock Diagram.


Make: Model: Year:
VoIkswagen Jetta 1995-1996


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 37 of 53

FUNCTON COLOR LOCATON
Start: RED/BLACK (+) GNTON SWTCH HARNESS
gnition #1: BLACK (+) GNTON SWTCH HARNESS
gnition #2: BROWN/RED GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BLACK/YELLOW GNTON SWTCH HARNESS
Brake Light: RED/BLACK (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLACK/RED AT COL
Parking Lights: GRAY/BLACK (DR) & GRAY/RED (PS) (+) AT HEADLGHT SW. *
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

VoIkswagen Jetta 1995-1996

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (+) GNTON SWTCH HARNESS
OEM Alarm Disarm: WLL DSARM WHEN DOORS ARE
UNLOCKED
Dome
Lights/Superv:
BROWN/WHTE (-) DRVER KCK PANEL
OEM Horn:
Power Lock: YELLOW/RED (+) DRVER'S KCK PANEL **
Power Unlock: RED/BLACK (+) DRVER'S KCK PANEL **
Trunk Release: GRAY (+) UNDER REAR SEAT-DRVER SDE
Alarm nput Wire: BROWN/WHTE (-) DRVER KCK PANEL

NOTES: * Split Parking Light System - must use relays to isolate the circuits from each other. **
Requires Two Positive Pulses To Unlock Doors. See Note #202- See Positive Pulse Door Lock
Diagram & Note #231 - Double Pulse Door Lock Diagram.


Make: Model: Year:
VoIkswagen Jetta 1997-1998


FUNCTON COLOR LOCATON

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 38 of 53
Start: RED/BLACK GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2:
gnition #3:
Accessory:
Brake Light: BLACK/RED AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
Parking Lights: GRAY/BLACK (DR) & GRAY/RED (PS) (+) BEHND DRVER DASH
Headlights: WHTE (+) STEERNG COLUMN HARNESS
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

VoIkswagen Jetta 1997-1998

FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BROWN/WHTE (-) N DRVER'S KCK PANEL
OEM Horn: BROWN/BLUE (-) STEERNG COLUMN HARNESS
Power Lock: GREEN (+) N DRVER'S KCK PANEL *
Power Unlock: GRAY (+) N DRVER'S KCK PANEL *
Trunk Release: GRAY (+) BEHND DRVER DASH
Alarm nput Wire: BROWN/WHTE (-) N DRVER'S KCK PANEL

NOTES: * See nstallation Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 39 of 53

Make: Model: Year:
VoIkswagen Jetta 1999-2002


FUNCTON COLOR LOCATON
Start: RED/BLUE GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BROWN/RED GNTON SWTCH HANRESS
gnition #3: N/A
Accessory: BLACK/RED GNTON SWTCH HARNESS
Brake Light: RED/BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN/YELLOW
OR GREEN/RED N HARNESS, ENGNE
FRONT
Parking Lights: GRAY/TAN OR GRAY/ORANGE & GRAY/VOLET *
Headlights: WHTE/BLACK AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

VoIkswagen Jetta 1999-2002

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: SEE NOTE BELOW **
Dome
Lights/Superv:
BROWN/WHTE (-) OR BLUE/GRAY (-) AT ALARM MODULE
OEM Horn: BLACK/YELLOW AT 3-PN PLUG BEHND FUSE PANEL
Power Lock: YELLOW/BLUE (-) N DRVER'S DOOR OR RED/BLUE N DR.
KCK
Power Unlock: DK. GREEN/RED (-) N DRVER'S DOOR OR RED/LT. GREEN ***
Trunk Release: GRAY AT SWTCH N GLOVE BOX
Alarm nput Wire: BROWN/WHTE (-) OR BLUE/GRAY (-) AT ALARM MODULE

NOTES: * Split Parking Light System - must use relays to isolate the circuits from each other. **
Alarm Disarms With Single Pulse To The Unlock Wire. *** Two Consecutive Pulses, Unlocks The
Door.


Make: Model: Year:

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 40 of 53
VoIkswagen Jetta 2003

FUNCTON COLOR LOCATON
Start: RED/BLACK* GNTON SWTCH HARNESS*
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BROWN/RED GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BLACK/RED GNTON SWTCH HARNESS
Brake Light: RED/BLACK (+) Above Brake Pedal Switch
Tach Signal: GREEN/YELLOW At gnition Coil
Parking Lights: GRAY/BROWN (+) At Light Switch
Headlights: WHTE/BLACK (+) At Light Switch
Diesel Glow
Plug:

Clutch Bypass
Wire:

Notes: * This vehicle is equipped with a transponder immobilizer system. Must use a universal alarm
bypass module.

VoIkswagen Jetta 2003

FUNCTON COLOR LOCATON
Constant +12
Volts:
WHTE/RED ( + ) gnition Switch Harness
OEM Alarm
Disarm:

Dome
Lights/Superv:
RED/BLACK (-) Drivers. Kick Panel Near Pillar
OEM Horn:
Power Lock: RED/BLUE (-) HARNESS N DRVERS
KCKPANEL**

Power Unlock: RED/LT.GREEN (-) HARNESS N DRVERS
KCKPANEL

Trunk Release: GRAY (+) AT TRUNK RELEASE SWTCH
Alarm nput Wire: RED/BLACK (-) Drivers. Kick Panel Near Pillar
Notes: ** See Note #201 Negative Trigger Door Locks


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 41 of 53

VoIkswagen Passat 1991-1993
FUNCTON COLOR LOCATON
Start: RED/BLACK GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN/RED GNTON SWTCH HARNESS
Brake Light: BLACK/RED (+) SWTCH ON BRACKET ABOVE BRAKE
PEDAL
Tach Signal:
GREEN/BLUE OR
GREEN
AT ENGNE CONTROL MODULE *
Parking Lights: GRAY/BLACK (DR) & GRAY/RED (PS) (+) AT HEADLGHT SW. *
Headlights: WHTE/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Engine Control Module Located On Plenum n Rear Of Engine Compartment.

VoIkswagen Passat 1991-1993

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: BLACK/WHTE OR
RED/BLK
(+) AT ANT-THEFT MODULE ****
Dome
Lights/Superv:
BROWN/WHTE (-) ANY PN SWTCH OR BELOW DR STEP
PLATE
OEM Horn: BROWN/BLUE (-) HORN SWTCH OR RELAY
Power Lock: RED/YELLOW (+) AT OEM ALARM UNT N DRVER'S KCK ***
Power Unlock: BLACK/WHTE (+) AT OEM ALARM UNT N DRVER'S KCK ***
Trunk Release: N/A
Alarm nput Wire: BROWN/WHTE (-) ANY PN SWTCH OR BELOW DR STEP
PLATE

NOTES: * Split Parking Light System - must use relays to isolate the circuits from each other. **
Other Circuits At OEM Alarm Module- BROWN/WHTE (-) Door Trigger, BROWN/GREEN (-)
Trunk Trigger, BROWN/RED (-) Hood Trigger. *** See Note #202- See Positive Pulse Door Lock
Diagram. **** This Wire s Located n The 10 Pin Connector At The Module. t Requires Two
Pulses To Disarm Alarm.


Make: Model: Year:

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 42 of 53
VoIkswagen Passat 1994
FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: BLACK/YELLOW GNTON SWTCH HARNESS (HEAT/AC)
Brake Light: BLACK/RED (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN/BLACK AT ENGNE CONTROL MODULE *
Parking Lights: GRAY/BLACK (DR) & GRAY/RED (PS) (+) AT HEADLGHT SW. **
Headlights: WHTE/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Engine Control Module Located On Center Of Firewall n Engine Compartment. **Split
Parking Light System, Use Two 6 Amp Diodes Or Two S.P.D.T. Relays To solate.

VoIkswagen Passat 1994

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BROWN/WHTE (-) AT ANY PN SWTCH
OEM Horn: BROWN/BLUE (-) STEERNG COLUMN HARNESS
Power Lock: RED/YELLOW DRVER KCK #202
Power Unlock: BLACK/WHTE PANEL
Trunk Release: N/A
Alarm nput Wire: BROWN/WHTE (-) AT ANY PN SWTCH

NOTES: See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 43 of 53

Make: Model: Year:
VoIkswagen Passat 1995-1997


FUNCTON COLOR LOCATON
Start: RED/BLACK (+) GNTON SWTCH HARNESS
gnition #1: BLACK (+) GNTON SWTCH HARNESS
gnition #2: BROWN/YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN/RED GNTON SWTCH HARNESS
Brake Light: RED/BLACK (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN AT COL *
Parking Lights: GRAY/BLACK (DR) & GRAY/RED (PS) (+) AT HEADLGHT SW. **
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * BLACK/PURPLE For 97 At Harness Between Engine And Driver Shock Tower.

VoIkswagen Passat 1995-1997

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (+) GNTON SWTCH HARNESS
OEM Alarm Disarm: WLL DSARM WHEN DOORS ARE
UNLOCKED
Dome
Lights/Superv:
BROWN/WHTE (-) DRVER KCK PANEL
OEM Horn:
Power Lock: GRAY DRVER'S KCK PANEL ***
Power Unlock: GREEN DRVER'S KCK PANEL ***
Trunk Release: GRAY (+) UNDER REAR SEAT-DRVER SDE
Alarm nput Wire: BROWN/WHTE (-) DRVER KCK PANEL

NOTES: * Split Parking Light System - must use relays to isolate the circuits from each other. **
Requires Two Positive Pulses To Unlock.


Make: Model: Year:
VoIkswagen Passat 1998

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 44 of 53


FUNCTON COLOR LOCATON
Start: RED/BLACK & BLUE (2) WRES GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: YELLOW/BLACK GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: N/A
Brake Light: RED/BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN/BLUE PN #6 OF ECM *
Parking Lights: GRAY/RED (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug: BROWN/GREEN PN #41 OF ECM *
Clutch Bypass Wire: RED/GRAY (-) AT SWTCH ABOVE CLUTCH PEDAL

NOTES: * ECM s Located n Left Rear Corner Of Engine Compartment.

VoIkswagen Passat 1998

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: BROWN/GRAY (-) AT PN #21 OF CENTRAL CONTROL SYS. **
Dome
Lights/Superv:
BROWN/WHTE (-) N DRVER'S KCK PANEL
OEM Horn: BROWN/YELLOW OR
BLACK
(-) STEERNG COLUMN HARNESS
Power Lock: BROWN/GREEN (-) N DRVER'S KCK PANEL ***
Power Unlock: BROWN/BLUE (-) N DRVER'S KCK PANEL ***
Trunk Release: BROWN/GRAY (-) AT RELEASE SWTCH
Alarm nput Wire: BROWN/WHTE (-) N DRVER'S KCK PANEL

NOTES: ** Central Control System s Located Under Carpet of Driver's Seat. *** See Note #201 -
Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 45 of 53

Make: Model: Year:
VoIkswagen Passat 1998-2000
FUNCTON COLOR LOCATON
Start: RED/BLACK GNTON SWTCH HARNESS *
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: WHTE/YELLOW GNTON SWTCH HARNESS
Brake Light: RED/BLUE AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN/BLUE
AT NSTRUMENT PANEL CLUSTER UNDER
DASH
Parking Lights: GREEN/RED (+) STEERNG COLUMN HARNESS FROM
SWTCH
Headlights:
Diesel Glow Plug: N/A
Clutch Bypass Wire:

NOTES: * 1999 Models may Have A Transponder Passive Theft System. See nstallation Note
#144 - Bypassing Transponder Theft Systems.

VoIkswagen Passat 1998-2000

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: GRAY/WHTE (-) DRVER'S KCK PANEL OR FACT. ALARM
***
Dome
Lights/Superv:
BROWN/WHTE (-) ANY SWTCH
OEM Horn:
Power Lock: BROWN/BLUE (-) DRVER'S KCK PANEL OR FACT. ALARM **
Power Unlock: GRAY/WHTE (-) DRVER'S KCK PANEL OR FACT. ALARM **
Trunk Release:
Alarm nput Wire: BROWN/WHTE (-) ANY SWTCH

NOTES: ** Factory Alarm Module s Located Under The Rear Sear On Driver's Side of Vehicle.
Requires Two Consecutive Negative Pulses to Unlock The Doors. *** This s The Same Wire As
Unlock. The First Negative Pulse Disarms The Factory Alarm. See Note #201 Negative Trigger
Door Locks. See also Note #231 for double-pulse information if your module does not have a
double pulse option.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 46 of 53
Make: Model: Year:
VoIkswagen Passat 2001-2004
FUNCTON COLOR LOCATON
Start: RED/BLACK GNTON SWTCH HARNESS *
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: YELLOW/BLUE GNTON SWTCH HARNESS
Brake Light: RED/BLACK AT SWTCH ABOVE PEDAL
Tach Signal: GREEN/BLUE BEHND NSTRUMENT CLUSTER
Parking Lights: GRAY/BLACK &
GRAY/RED (+)
AT HEADLGHT SWTCH **
Headlights: WHTE/BLACK AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * This Vehicle s Equipped With A Transponder Passive Theft System. See nstallation
Note #144 - Bypassing Transponder Theft Systems.

VoIkswagen Passat 2001-2004

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: UNLOCK WRE ***
Dome
Lights/Superv:

OEM Horn: BROWN/YELLOW (+) STEERNG COLUMN HARNESS
Power Lock: RED/GREEN (-) DRVER'S KCK PANEL
Power Unlock: RED/BLUE (-) DRVER'S KCK PANEL ***
Trunk Release:
Alarm nput Wire:

NOTES: ** Use Both Wires And Diode solate With The Band Facing Away From The
Alarm/Remote Start Module. *** Use Double Pulse To Unlock The Doors. A Single Pulse
Disarms The Alarm, A Second Pulse Unlocks The Doors.


Make: Model: Year:
VoIkswagen Quantum 1982
FUNCTON COLOR LOCATON
Start: RED/BLACK GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 47 of 53
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3:
Accessory:
Brake Light: RED/YELLOW (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: RED/BLACK OR GREEN AT COL
Parking Lights: DRVER - GRAY/BLACK PASSENGER - GRAY/RED (+) LGHT
SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

VoIkswagen Quantum 1982

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BROWN/WHTE (-) AT PN SWTCH
OEM Horn:
Power Lock: RED/YELLOW AT SWTCH #202
Power Unlock: RED AT SWTCH #202
Trunk Release:
Alarm nput Wire: BROWN/WHTE (-) AT PN SWTCH

NOTES: See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 48 of 53

VoIkswagen Rabbit 1981-1984


FUNCTON COLOR LOCATON
Start: RED/BLACK GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2:
gnition #3:
Accessory:
Brake Light: RED/BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN AT COL
Parking Lights: GRAY (+) AT LGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

VoIkswagen Rabbit 1981-1984

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BROWN/WHTE (-) AT PN SWTCH
OEM Horn:
Power Lock: ADD ACTUATOR POWER DOOR LOCKS MUST BE ADDED
#204
Power Unlock: ADD ACTUATOR POWER DOOR LOCKS MUST BE ADDED
#204
Trunk Release:
Alarm nput Wire: BROWN/WHTE (-) AT PN SWTCH

NOTES: See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 49 of 53

VoIkswagen Rabbit ConvertibIe 1981-1984


FUNCTON COLOR LOCATON
Start: RED/BLACK GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory:
Brake Light: RED/BLACK (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLACK/RED AT COL *
Parking Lights: GRAY/GREEN (+) AT LGHT SWTCH OR FUSE BOX
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Diesel

VoIkswagen Rabbit ConvertibIe 1981-1984

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BROWN/WHTE (-) AT PN SWTCH
OEM Horn:
Power Lock: ADD ACTUATOR POWER DOOR LOCKS MUST BE ADDED
#204
Power Unlock: ADD ACTUATOR POWER DOOR LOCKS MUST BE ADDED
#204
Trunk Release:
Alarm nput Wire: BROWN/WHTE (-) AT PN SWTCH

NOTES: See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 50 of 53

VoIkswagen Rabbit P/U 1981-1983


FUNCTON COLOR LOCATON
Start: RED/BLACK GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2:
gnition #3:
Accessory:
Brake Light: BLACK/RED (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: RED/BLACK AT COL *
Parking Lights: GRAY (+) AT LGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Or Diesel Engine.

VoIkswagen Rabbit P/U 1981-1983

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BROWN/WHTE (-) AT PN SWTCH
OEM Horn:
Power Lock: ADD ACTUATOR POWER DOOR LOCKS MUST BE ADDED
#204
Power Unlock: ADD ACTUATOR POWER DOOR LOCKS MUST BE ADDED
#204
Trunk Release:
Alarm nput Wire: BROWN/WHTE (-) AT PN SWTCH

NOTES: See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 51 of 53

VoIkswagen Scirocco 1979-1988


FUNCTON COLOR LOCATON
Start: RED/BLACK GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3:
Accessory:
Brake Light: RED/BLACK(+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: RED/BLACK AT COL OR DASH TACHOMETER *
Parking Lights: GRAY/GREEN (+) AT LGHT SWTCH OR FUSE BOX
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Some Models Carburated.

VoIkswagen Scirocco 1979-1988

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BROWN/WHTE (-) AT PN SWTCH
OEM Horn:
Power Lock: RED/YELLOW AT SWTCH #202
Power Unlock: RED AT SWTCH #202
Trunk Release:
Alarm nput Wire: BROWN/WHTE (-) AT PN SWTCH

NOTES: See Note #202 - Positive Trigger Door Locks


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 52 of 53

VoIkswagen Vanagon 1980-1989


FUNCTON COLOR LOCATON
Start: RED/BLACK GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3:
Accessory:
Brake Light: RED/BLACK (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE OR GREEN AT COL
Parking Lights: GRAY (+) AT LGHT SWTCH OR FUSE BOX
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

VoIkswagen Vanagon 1980-1989

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BROWN/WHTE OR WHTE/GREEN (-) AT PN SWTCH
OEM Horn:
Power Lock: ADD ACTUATOR ACTUATOR NEEDED N DRVER DOOR
#204
Power Unlock: ADD ACTUATOR ACTUATOR NEEDED N DRVER DOOR
#204
Trunk Release:
Alarm nput Wire: BROWN/WHTE OR WHTE/GREEN (-) AT PN SWTCH

NOTES: See Note #204 - Adding Actuator Door Lock Diagram.


Make: Model: Year:
VoIkswagen Vanagon 1990-1991
FUNCTON COLOR LOCATON

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Volkswagen - Copyright 2004-2006 - 12 Volt Resource LLC Page 53 of 53
Start: RED/BLACK GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3:
Accessory:
Brake Light: RED BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN AT COL OR DASH TACHOMETER
Parking Lights: GRAY/GREEN (+) AT LGHT SWTCH FOR FUSE BOX
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

VoIkswagen Vanagon 1990-1991

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BROWN/WHTE (-) AT PN SWTCH
OEM Horn:
Power Lock: ADD ACTUATOR ACTUATOR NEEDED N DRVER DOOR
#204
Power Unlock: ADD ACTUATOR ACTUATOR NEEDED N DRVER DOOR
#204
Trunk Release:
Alarm nput Wire: BROWN/WHTE (-) AT PN SWTCH

NOTES: See Note #204 - Adding Actuator Door Lock Diagram.

You might also like