Professional Documents
Culture Documents
Temperature Refrigerator Temperature Low Side Pressure (cut-in) Low Side Pressure (cut-out) High Side Pressure Wattage Amps (running) Base Voltage 65F (18C) Ambient 32 to 40% -6 to 6 F -21 to -14 C 33 to 46 F 0.5 to 8 C 5 to 12 psig 34 to 83 kPa -2 to 2 psig -14 to 14 kPa 85 to 95 psig 586 to 655 kPa 40 to 55 .5 to 1.1 115 vac (127 vac max) DEFROST SPECiFiCATiONS Cabinet Size 26 & 28 SD, 23 CD Thermostat Cut-in 25 F (-4 C) Cut-out 47 F (8 C) Watts 500 Heater Ohms 26 90F (32C) Ambient 100% -6 to 6 F -21 to -14 C 33 to 46 F 0.5 to 8 C N/A -2 to 2 psig -14 to 14 kPa 120 to 135 psig 827 to 931 kPa 60 to 70 .7 to .9
TU
CAUTiON
All electrical parts and wiring must be shielded from torch flame. DO NOT allow torch to touch insulation; it will char at 200F and flash ignite (burn) at 500F. Excessive heat will distort the plastic liner.
Timing Gear
Electronic Timer - (ADC) Defrost 24 minutes every 6-96 hours of compressor run time. CONDENSER FAN MOTOR Watts 3.1 (Energy Star, some models) RPM 1100 CW Opposite Shaft Amps 0.03 Running
NOTE
This product comes equipped with an Adaptive Defrost Control (ADC). To activate manual defrost, simultaneously press and hold the Fresh Food up (+) and Fresh Food down (-) keys for 5 seconds. A d in the freezer temperature window and F in the refrigerator temperature window will display when the heater is activated. To deactivate manual defrost, simultaneously press and hold the Fresh Food up (+) and Fresh Food down (-) keys for 5 seconds. A d and F will be displayed until the defrost cycle is complete.
LINE
BLK
BLK BRN
POWER
ICE MAKER
NEUTRAL
YEL
iCE MAKER SPECiFiCATiONS Electrical Thermostat Heater Voltage 115 vac (127 vac max) Opens at 48 F (9 C), Closes at 15 F (-9 C) 85 vac iCE MAKER CONNECTOR PLUG CONNECTiONS Wire Number 1 2 3 4 Wire Color Green/Yellow Yellow Black Light Blue Connects to: Ground Water Valve Line Neutral
ICE MAKER
P-3
THERMAL CUT-OUT
BLK
RED
ICE MAKER
YEL
THERMOSTAT
BLU
C NO NC
YEL
P-4
RED
WATER VALVE
NO NC
BLK
GRN / YEL
GRN / YEL
P-1
LT. BLU
MOLD
MOUNTING PLATE
ICE MAKER
P-2
LT. BLU
iMPORTANT
MOLD HEATER
165 WATTS
SHUT-OFF SWITCH
Ice Maker Errors Displayed on UI System Error Codes Displayed on UI ERROR OP or 2 SH or 3 OP or 2 SH or 3 SY SY SY Freezer Sensor OPEN Freezer Sensor SHORTED FF Sensor OPEN FF Sensor SHORTED Evaporator Fan Circuit Communication error Communication error In Manual Defrost Test 1 2 3 9
Diagnostic Mode Activate: FZ (+) and FZ (-) for 5 sec. Standard compressor Defrost heater FF lighting FZ lighting
22 23 24 26
EF CE CF dF
To initiate manual defrost press and hold, for 5 sec. FF(+) and FF(-), (d) and (f) will be displayed.
41 12 38 15
Perfect Temp Drawer VCC Condensor fan VCC Compressor Evaporator fan De-activate: Hold FF (+) for 5 sec.
29 30 33 0-