You are on page 1of 2

Safety in Nuclear Power Plants

Safety in Nuclear Power Plants The safety of any large scale industry is of great concern and the nuclear power plant is no exception. Safety in nuclear power plants is the foremost aspect to be taken into consideration for any worker. Here is a noteworthy perspective on the significance of vigilant safety culture of a nuclear power plant. The main reason for the concern of safety in nuclear power plants is the release of uncontrolled emissions into the surroundings, which may pose severe risks to humans at the reactor site as well as off-site. Nuclear Power Reactor: Safety Mechanisms Every design of a nuclear power reactor must and should incorporate provisions for human errors as well as equipment failures. They should have several backup elements and design to rule out errors made by the operator. When the first atomic reactor was in a critical condition in 1942, Enrico Fermi has already incorporated the necessary safety measures to combat the situation. Some of the main safety measures to be followed in a nuclear power plant are dealt with individually in the following sections. Control of Radioactivity The control of radioactivity requires the ability to control neutron flux. A decrease in the neutron flux will also decrease the radioactivity. The best way out to decrease neutron flux is to integrate neutron-absorbing control rods by partially inserting them into the reactor core. In most of the modern power plants, all the control rods are inserted into the reactor core within a few seconds, thus stopping the nuclear reaction as quickly as possible. Additionally, most of the nuclear power reactors are designed in such a way that the efficiency of the reaction comes down as the temperature increases above the normal level. Thus, lesser neutrons can only cause fission, thereby slowing down the reactor automatically. Maintenance of barriers It is very important to maintain the series of physical barriers between the environment and radiator core to prevent the discharge of radiations. Maintenance of Core Cooling Every nuclear reactor requires some type of cooling. Normally, water is used as a coolant. However, few reactors cannot use water, in which case sodium salts are used. Safety of Workers Radiation dosage for the workers can be reduced by following the procedures given below so as to reduce the health risks for them:

1/2

Safety in Nuclear Power Plants

Remote is used to handle the equipment in the reactor core

Physical shielding

Setting time limitations for a worker to work in an area with considerable radiation levels

Supervising the wok environment and keeping an eye on the individual doses

All the above mentioned safety steps have to be considered seriously to ensure safety of nuclear power plants. However, according to regulations, situations of unexpected melt-downs must be strictly confined within the plant only without the requirement to vacate close-by residential areas.

2/2

You might also like