Professional Documents
Culture Documents
Nama Alat : Metal detector Deskripsi Fungsi : Untuk melacak adanya logam atau benda yang mengandung unsur logam, menggunakan IC tunggal CS209A yang di produksi oleh Cherry Semiconductor. Dalam IC sudah terdapat generator oscillator yang berfungsi melalui rangkaian eksternal LC. Jika terdapat perubahan sinyal induktansi akibat pancaran sinyal dari L yang mengenai logam, maka akan menyalakan lampu LED dan membunyikan buzzer. VR digunakan untuk menyetel sensitifitas detector. Part list : R1 : 1k R2 : 10k R3 : 220 C1 : 10uF C2 : 222 C3 : 222 VR : 10 k Trimpot IC : CS209A L : 100uH B :9V S : Switch Bz : Buzzer Source :
Skema Rangkaian Pendeteksi Metal Note: The switch S1 can be a slide type ON/OFF switch. The POT R1 can be used to adjust the sensitivity of the circuit.
IC CS209A Description The CS209A is a bipolar monolithic integrated circuit for use in metal detection (Pendeteksi Metal)/ proximity sensing applications. The IC (see block diagram) contains two on-chip current regulators, oscillator and low-level feedback circuitry, peak detection/demodulation circuit, a comparator and two complementary output stages. The oscillator, along with an external LC network, provides controlled oscillations where amplitude is highly dependent on the Q of the LC tank. During low Q conditions, a variable low-level feedback circuit provides drive to maintain oscillation. The peak demodulator senses the negative portion of the oscillator envelop and provides a demodulated waveform as input to the comparator. The comparator sets the states of the complementary outputs by comparing the input from the demodulator to an internal reference. External loads are required for the output pins. A transient suppression circuit is included to absorb negative transients
Absolute Maximum Ratings Supply Voltage ................................................................................................24V Power Dissipation (TA = 125C).............................................................200mW Storage Temperature Range ....................................................55C to +165C Junction Temperature...............................................................40C to +150C Electrostatic Discharge (except TANK pin) ................................................2kV Lead Temperature Soldering Wave Solder(through hole styles only) ...........10 sec. max, 260C peak Reflow (SMD styles only) ...........60 sec. max above 183C, 230C peak