You are on page 1of 4

Reset the service light on the

850 with VDO Cluster All Years 850 with Yazaki Cluster 1991 to- 1997 S-70 1998 to- 2000 V-70 1998 to- 2000 S-80 1999/2000 240 1986 to- 1993 740 /780 1986 to- 1997 760 1986 to 1990 940/960 1991 to 1997

Volvo S40/V40 Service Light Reset


RESETTING SERVICE LAMP ON 1999 S40/V40 1, Hold down the odometer button 2, Turn the ignition so all the lights come on 3, Keep holding the odometer down for 30 secs or until the service light starts flashing 4, Release the odometer button

VOLVO
Model 850, S70, V70, S80 240 Year 1996-97, 1998-00, 1999-00 1986-93 Procedure Service reminder lamp must be reset with either a Scan Tool Connected to the Data Link Connector (DLC), or connect a Volvo Rest Tool to the DLC and press the button on the tool to reset. When the "SERVICE" is illuminated, reach behind

the instrument panel and push the level located between the tachometer and speedometer. 740,780 1986-88, 1988-90 When the "SERVICE" light is illuminated, reach behind the instrument panel and press the button located to the right of the speedometer. When the "SERVICE" light is illuminated, remove the cap on the face of the instrument panel between the clock and the speedometer. Insert a thin-bladed tool into the cavity and press the reset button.
*Odometer above the speedometer needle.

740, 760, 850


w/ Yazaki Cluster*,

1989-92, 1986-90, 1991-97

940, 960 All Models 1999

Press and hold trip odometer reset button. Next, turn the ignition key to the run position KPII (not the start position). Wait 30 seconds or until service light begins blinking. Turn the ignition to off position. Release the Trip Odometer button. To reset the Service Reminder Indicator, turn the ignition on while the engine is not running. Access the diagnostic unit located on the left fender well under the hood. Connect the single wire plug to terminal #7. Press the reset button four times shortly. When the LED glows, press the button once. When the LED glows steadily again, press the button five times. When the LED glows steadily again, press the button once. After the LED gives a couple of rapid flashes, the system is reset. Unplug the connector and turn the ignition off.
*Odometer located below the speedometer needle.

850
w/ VDO Cluster*

All Years

Volvo S/V70
Ignition off. Press and hold trip button on the instrument cluster. Switch ignition on. Continue to hold trip button 10 sec. SRL lamp should start to flash. Within 5 sec release the trip button no later than 4 sec after the lamp started to flash.

Volvo 850-70 Service Light Reset

-------------------------------------------------------------------------------RESETTING SERVICE LAMP NOTE: This function is for the service reminder lamp, be sure you have performed the proper service such as changing the oil before resetting. If the check engine lamp is illuminated when the car is running, you'll need to have the car looked at by the Volvo dealer for proper diagnosis. 1. Turn on the ignition to the KPII position so the warning lamps on the dash are illuminated. Do not start the car. 2. Open the bonnet of the car and locate Diagnostic test port (A) behind the driver side headlamp. 3. Remove the cover and pull the jumper wire out of the holder in the cover. 4. Insert the jumper into terminal #7, then press button 4 times, wait approximately 5 seconds and the red lamp should glow continuously. You are now in the data reset mode. 5. Press the button 1 time and wait approximately 5 seconds for the lamp to glow again then press the button 5 times. After about 5 seconds the lamp will illuminate again, press the button 1 time and you will see the lamp flash repeatedly for a couple of seconds indicating that the service lamp has been properly reset. 6. If a mistake is made, simply switch the ignition off and back on to reset and start over. -------------------------------------------------------------------------------1996 Model (Some of them) On these models the diagnostic socket is in front of the gear stick. Switch the ignition on. As you look at the speedometer on the dash, beneath it opposite the trip reset button is a rubber plug. Remove the plug and with a thin pointer such as a ball point pen, depress the pin. This will reset the service light. -------------------------------------------------------------------------------1999 Model Service Lamp Reset Procedure 1. Press and hold trip odometer reset button 2. Turn ignition key to run position KPII (not the start position) 3. Wait 30 seconds or until service light begins blinking

4. Release Trip Odometer button 5. Turn ignition to off position

Volvo S80
Ignition switch in position I (radio posision). Press and hold trip button on the instrument cluster. Put ignition switch in position II. Continue to hold trip button for 10 sec. SRL lamp should start to flash. Within 5 sec release trip button. Sound/beep will confirm a successful SRL reset.

You might also like