You are on page 1of 2

Training Plan Qualification: Mechatronics Servicing NCII Trainees Training Requirements 1.

Install Mechatroni cs devices Training Activity/Task Mode of Training Staff Facilities/Tools and Equipments Venue Assessment Arrangement Date and Time

1.1 Read and interpret work instruction according to the installation job requirements 1.2 Identify tools, equipments, testing device and materials needed for installation 1.3 Identify the PPE and OHS policies and procedures required for the installation job 1.4 Install Mechatronics devices 1.5 Conduct test on the installed Mechatronics devices

Modular/ Self-paced WorkBased Training

Marvin Villanueva

1. Various reading/inform ation materials 2. Pliers 3. Cutters 4. Screwdrivers 5. Soldering iron 6. Wrenches 7. Buzzers 8. Lamps 9. Switches 10. Different sensors 11. Multimeters 12. Air compressor 13. Power supplies 14. Cylinder actuators 15. PPE

Training Center (Practical Work Area)

Read and interpret work instruction according to the installation job requirements Identify tools, equipments, testing device and materials needed for installation Identify the PPE and OHS policies and procedures required for the installation job Install Mechatronics devices Conduct test on the installed Mechatronics devices

June 4, 2012 June 10, 2012 (8:00am 12:00pm) (1:00pm5:00pm)

Prepared by: Marvin W. Villanueva Jr.

2. Configure and adjust Mechatron ics devices

2.1 Read and interpret work instruction according to the configuration and adjustment job requirements 2.2 Identify tools, equipments, testing device and materials needed for configuration and adjustment 2.3 Identify the PPE and OHS policies and procedures required for the configuration and adjustment job 2.4 Configure and adjust Mechatronics devices according to standard operating procedures 2.5 Conduct test on the configured and adjusted Mechatronics devices

Modular/ Self-paced WorkBased Training

Marvin Villanueva

1. Various reading/inform ation materials 2. Pliers 3. Cutters 4. Screwdrivers 5. Soldering iron 6. Wrenches 7. Buzzers 8. Lamps 9. Switches 10. Sensors 11. Multimeters 12. Air compressor 13. Power supplies 14. Cylinders 15. PPE

Training Center (Practical Work Area)

Read and interpret work instruction according to the configuration and adjustment job requirements Identify tools, equipments, testing device and materials needed for configuration and adjustment Identify the PPE and OHS policies and procedures required for the configuration and adjustment job Configure and adjust Mechatronics devices according to standard operating procedures Conduct test on the configured and adjusted Mechatronics devices

June 11, 2012 June 15, 2012 (8:00am 12:00pm) (1:00pm5:00pm)

Prepared by: Marvin W. Villanueva Jr.

You might also like