You are on page 1of 47

britt engineering

be

The FRP Specialist

P I P E S U P P O R T S
2010

Engineered Supports for Fiberglass & Non-Metallic Pipe Catalog Fiberglass Pipe Design Manual

Britt Pipe Supports P.O.Box 101267 Birmingham, Al 35210

(205) 951-5691
(205) 951-5605 FAX www.brittengineering.com

http://www.brittengineering.com/impact_movie.html

EXPERIENCE FIRST
Cat. 9710

C copyright 2010. All rights reserved.

SUPPORT NO. BE-20S BE-20 BE-30 BE-30K BE-50 BE-50RH BE-50G BE-50RH BE-60 BE-60G BE-60A BE-60H BE-60RH BE-60S BE-60V BE-70 BE-70G BE-70H BE-70RH BE-80 BE-80S BE-90 BE-90K BE-100 BE-110 BE-110K BE-120 BE-120C BE-120RH BE-GUIDE CLIPS BE-130

REV. 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0

DESCRIPTION CRADLE SUPPORT SHOE SUPPORT SHOE SUPPORT INSULATED SHOE SUPPORT ROD HANGER CLAMP SUPPORT ROD HANGER HARDWARE ROD HANGER CLAMP SUPPORT WITH BRACE ROD HANGER HARDWARE COMPONENT SUPPORT COMPONENT SUPPORT WITH GUIDES COMPONENT ANCHOR COMPONENT HANGER SUPPORT ROD HANGER HARDWARE COMPONENT STANCHION SUPPORT COMPONENT RISER SUPPORT RISER CLAMP SUPPORT RISER CLAMP SUPPORT WITH GUIDES ROD HANGER RISER CLAMP SUPPORT ROD HANGER HARDWARE GUIDE SUPPORT GUIDE SUPPORT GUIDE SUPPORT INSULATED GUIDE SUPPORT LIGHT DUTY ANCHOR HEAVY DUTY ANCHOR INSULATED PIPE ANCHOR HANGER HANGER HANGER HARDWARE GUIDE CLIP HARDWARE SHEAR COLLARS

SIZE RANGE 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" 2" TO TO TO TO TO TO TO TO TO TO TO TO TO TO TO TO TO TO TO TO TO TO TO TO TO TO TO TO TO TO TO 10" 10" 36" 36" 36" 30" 30" 30" 30" 30" 30" 30" 30" 30" 30" 30" 30" 30" 30" 4" 4" 36" 36" 12" 36" 36" 20" 36" 36" 36" 36"

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS PIPE SUPPORT INDEX

SUPPORT NO. BE-5

PIPE SUPPORT DATA PIPE LOAD RATINGS DIMENSIONS (INCHES) SIZE VERT. AXIAL A B C L 8 400 1.25 2" 8 400 1.25 3" 8 800 1.25 4" 12 800 2 6" 12 900 2 8" 12 900 2 10" 12" 14" 16" 18" 20" 24" 30" 36"

Features Provides full 180o support. Extended length provides margin for extended spans. Full elastomer contact to eliminate chafing. Provides full bearing support. Application Used where horizontal pipe movements may occur and where support structure is below pipe.

BE-20S
C PIPE O.D.

BE-20S w Strap

ELASTOMERIC LINER OR ALTERNATE MATERIAL

L
PIPE O.D.

SS STRAP (Extra)

ELASTOMERIC LINER OR ALTERNATE MATERIAL

NOTES
C copyright 2009. All rights reserved.

1) Fig.30 recommended for 6" and above.


FRP PIPE SUPPORT STANDARDS CRADLE SUPPORT SUPPORT NO. BE-20S

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

PIPE SUPPORT DATA PIPE LOAD RATINGS DIMENSIONS (INCHES) SIZE VERT. AXIAL A B C L 8 400 1.25 2" 8 400 1.25 3" 8 800 1.25 4" 12 800 2 6" 12 900 2 8" 12 900 2 10" 12" 14" 16" 18" 20" 24" 30" 36"

Features Provides full 180o support. Extended length provides margin for extended spans. Full elastomer contact to eliminate chafing. Provides full bearing support. Application Used where horizontal pipe movements may occur and where support structure is below pipe.

PIPE O.D.

ELASTOMERIC LINER OR ALTERNATE MATERIAL

BOP

1-5/8" or as specified

TOS

NOTES 1) Fig.30 recommended for 6" and above. 2) Top of Steel to Bottom of Pipe dimension may be modified.
C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS SHOE SUPPORT

SUPPORT NO. BE-20

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A B C L VERT. AXIAL 8 1-1/4 400 8 1-1/4 600 8 1-1/4 800 12 2 1200 12 2 1600 12 2 2000 12 2 2400 14 2 3075 14 2 3385 14 2 4000 14 2 4710 16 2 6750 20 2 8525 20 2 11550

Features

Provides full 180o support. Extended length provides margin for extended spans. Full elastomer contact to eliminate chafing. Provides full bearing support. Application Used where horizontal pipe movements may occur and where support structure is below pipe.

PIPE O.D.
ELASTOMERIC LINER OR ALTERNATE MATERIAL

B.O.P

T
1-5/8" or as specified

NOTES 1) Top of Steel to Bottom of Pipe dimension may be modified.

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS SHOE SUPPORT

SUPPORT NO. BE-30

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A G L Rod VERT. AXIAL 8 .375 610 .625 8 .375 610 .625 8 .375 610 .625 8 .625 610 .625 8 .625 1130 .75 8 .625 1810 .75 12 .75 2710 1 12 .75 2710 1 .875 3770 1.13 12 .875 3770 1.13 12 1 4960 1.25 14 1.25 6833 1.38 16 1.25 8000 1.38 16 1.5 11630 1.38 16

Features Provides full 360 degrees support. Extended length provides margin for extended spans. Full elastomer contact prevents chafing. Application Used to support FRP pipe where support structure cannot be installed below pipe. Due to flexibility of FRP pipe this type of support should not be used exclusively in long runs of pipe. Anchors and guides should be used intermittently to control expansion and to reduce vibration. Can be used on sloping lines.

See BE-50RH for Rod Assy. Options

INSULATION BAND SLOTS (50K ONLY-see Note 1))

ELASTOMERIC LINER OR ALTERNATE MATERIAL

T=OD/2 + 2-7/8"

NOTES 1) Fig.50 and 50K are the same except the 50K has 3/4" slots for insulation banding. 2) SS Banding sold separate in 100' rolls 3) See drawing 50RH for hanger hardware.
C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS ROD HANGER CLAMP SUPPORT

SUPPORT NO. BE-50


Rev1

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A B C L VERT. AXIAL 8 2 400 4 8 2 600 4 8 2 800 4 12 2 1200 6 12 2 1450 6 12 2 1650 6 12 2 2065 6 14 2 3120 8 14 2 3440 8 14 2 4055 8 14 2 4775 8 16 2 6835 8 20 2 8625 10 20 2 11750 10

Features Provides full 180o support. Extended length provides margin for extended spans. Full elastomer contact to eliminate chafing. Provides full bearing support. Provides easy insulation installment. Application Used where horizontal pipe movements may occur and where support structure is below pipe.

PIPE O.D.

ELASTOMERIC LINER OR ALTERNATE MATERIAL

BOP

4". or as specified

TOS
B

INSULATION BAND SLOTS (30K ONLY) L

NOTES 1) Top of Steel to Bottom of Pipe dimension may be modified. 2) Gussets not required in sizes below 6" 3) Use Fig.110K for Anchor 4) Top of Steel to Bottom of Pipe dimension may be modified.
C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS INSULATED SHOE SUPPORT

SUPPORT NO. BE-30K

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36" ITEM 1 2 3 4

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A C E Rod VERT. AXIAL .375 730 .375 730 .375 730 .625 730 .625 1350 .625 2160 .75 3230 .75 3230 .875 4480 .875 4480 1 5900 1.25 9500 1.25 9500 1.5 13800 ROD HANGER LIST - TYPE 1 QTY FIG.NO. DESCRIPTION Beam Attachment 1 66 HD Hex Nut 3 HEX All Thread Rod 1 146 Clevis W Pin 1 299

NOTES 1) Two rod assemblies are options. Britt can supply separately. 2) Figure numbers refer to the Anvil Catalog. O 3) Rod load based on Anvil Catalog at 650 F

ITEM 1 2 3 4 5 6 7

ROD HANGER LIST - TYPE 2 QTY FIG.NO. DESCRIPTION 66 Beam Attachment 1 290 Weldless Eye-nut 1 146 All Thread Rod 1 HEX HD Hex nut 4 230 Turnbuckle w 6" Opening 1 253 LH/RH Machine Rod 10" Long 1 299 Clevis W Pin 1

Auxiliary Steel
1 Beam Attachment (Fig.66)

HD Hex Nut (typ.)


3 All Thread Rod (Fig.146)

HD Hex Nut (3) 2

Weldless Eye-nut 2 (Fig.290) All Thread Rod 3 (Fig.146) HD Hex Nut (typ) 4 Turnbuckle 5 (Fig.230) LH/RH Machine Rod 6 (Fig.253)

4 Clevis w Pin (Fig.299)

Clevis w Pin 7 (Fig.299)

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS ROD HANGER HARDWARE

SUPPORT NO. BE-50RH


Rev1

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A G L Rod VERT. AXIAL 3/4 8 .375 610 3/4 8 .375 610 3/4 8 .375 610 3/4 8 .625 610 3/4 8 .625 1130 3/4 8 .625 1810 1 12 .75 2710 1 12 .75 2710 1-1/8 12 .875 3770 1-1/8 12 .875 3770 1-1/4 14 1 4960 1-3/8 16 1.25 6833 1-3/8 16 1.25 8000 1-3/8 16 1.5 11630

Features Provides full 360 degrees support. Extended length provides margin for extended spans. Full elastomer contact prevents chafing. Application Used to support FRP pipe where support structure cannot be installed below pipe. Due to flexibility of FRP pipe this type of support should not be used exclusively in long runs of pipe. Anchors and guides should be used intermittently to control expansion and to reduce vibration. Can be used on sloping lines.

See BE-50GRH for Rod Assy. Options


ELASTOMERIC LINER OR ALTERNATE MATERIAL

INSULATION BAND SLOTS (50GK ONLY-see Note 1))

BRACE TO STRUCTURE

T=OD/2 + 2-7/8" L

NOTES 1) Fig.50G and 50GK are the same except the 50GK has 3/4" slots for insulation banding. 2) SS Banding sold separate in 100' rolls 3) See drawing 50GRH for hanger hardware.
C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS ROD HANGER CLAMP SUPPORT W/ BRACE

SUPPORT NO. BE-50G


Rev1

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36" ITEM 1 2 3 4 8 9 10

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A C E Rod VERT. AXIAL .375 730 .375 730 .375 730 .625 730 .625 1350 .625 2160 .75 3230 .75 3230 .875 4480 .875 4480 1 5900 1.25 9500 1.25 9500 1.5 13800 ROD HANGER LIST - TYPE 1 QTY FIG.NO. DESCRIPTION Beam Attachment 1 66 HD Hex Nut 3 HEX All Thread Rod 1 146 Clevis W Pin 1 299 1 1 2 55 140 Bolt Welding Lug Britt Strut Brace Bolt w Nut

NOTES 1) Two rod assemblies are options. Britt can supply separately. 2) Figure numbers refer to the Anvil Catalog. O 3) Rod load based on Anvil Catalog at 650 F

ITEM 1 2 3 4 5 6 7 8 9 10

ROD HANGER LIST - TYPE 2 QTY FIG.NO. DESCRIPTION 66 Beam Attachment 1 290 Weldless Eye-nut 1 146 All Thread Rod 1 HEX HD Hex nut 4 230 Turnbuckle w 6" Opening 1 253 LH/RH Machine Rod 10" Long 1 299 Clevis W Pin 1 55 Welding Lug 1 140 Britt Strut Brace 1 Bolt w Nut 2

Auxiliary Steel

1
Beam Attachment (Fig.66) HD Hex Nut (3) All Thread Rod (Fig.146)

2
Weldless Eye-nut (Fig.290) All Thread Rod (Fig.146)

Beam Attachment (Fig.55)

3 4
2-1/2" Dia. Schedule 40 Pipe or Equal 12" Min.

HD Hex Nut (typ) Turnbuckle (Fig.230)

5 9

LH/RH Machine Rod (Fig.253) 6 Clevis w Pin (Fig.299)

Clevis w Pin (Fig.299)

7
2" Dia. Schedule 80 Pipe or Equal

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS ROD HANGER HARDWARE

SUPPORT NO. BE-50RH


Rev1

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A H L W VERT. AXIAL 7 7 9 400 3000 7 7 10.5 600 3000 7 7 12 800 3000 12 14 14 1200 11000 12 14 16.5 1600 11000 12 14 19 2000 11000 12 14 22 2550 11000 15 20 25 3150 10000 15 27.25 20 4020 10000 15 20 29 5090 9000 15 20 31 6360 9000 15 20 36 8820 8000 19 42.75 23 11000 15000 27.38 19 50 14000 15000

Features Matches standard 150# Flanges. Designed to prevent local overstress of FRP pipe due to component loads and moments. Application Used to support valves, regulators, flow meters, or other components used in piping systems.

L W 12" AND LARGER ARE SCALLOPED TO PROVIDE CLEARANCE FOR THE RING HUB REINFORCEMENT SPECIFIED IN PS-15-69

Mfg. Recommended Gasket Flange Flat Washer Valve Lock Washer

Hex Nut Lock Washer Flange Spot Face Area Component Support 60A, 60H, 60S, 60V HD Hex Nuts

NOTES 1) "H" dimension may be change but load rating would change. 2) 12" and largers are scalloped to provide clearance for the ing hub reinforcement specified in PS-15-69

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS COMPONENT SUPPORT

SUPPORT NO. BE-60

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A H L W VERT. AXIAL 7 7 9 400 3000 7 7 10.5 600 3000 7 7 12 800 3000 12 14 14 1200 11000 12 14 16.5 1600 11000 12 14 19 2000 11000 12 14 22 2550 11000 15 20 25 3150 10000 15 27.25 20 4020 10000 15 20 29 5090 9000 15 20 31 6360 9000 15 20 36 8820 8000 19 42.75 23 11000 15000 27.38 19 50 14000 15000

Features Matches standard 150# Flanges. Designed to prevent local overstress of FRP pipe due to component loads and moments. Application Used to support valves, regulators, flow meters, or other components used in piping systems.

1"x1"x1/4"x4" Angle See Fig. GA1

Guide Clip See Fig. GC1

3 Sides Typ.

Mfg. Recommended Gasket Flange Flat Washer Valve Lock Washer

3/16
1/8"CLR. (TYP.)
W

L 12" AND LARGER ARE SCALLOPED TO PROVIDE CLEARANCE FOR THE RING HUB REINFORCEMENT SPECIFIED IN PS-15-69

Hex Nut Lock Washer Flange Spot Face Area Component Support 60A, 60H, 60S, 60V HD Hex Nuts

NOTES 1) Gude Clips or Guide Angles are used to restrict lateral and vertical movement. 2) "H" dimension may be change but load rating would change. 3) 12" and largers are scalloped to provide clearance for the ing hub reinforcement specified in PS-15-69
SUPPORT NO. BE-60G

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS COMPONTENT SUPPORT W/ GUIDES

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A H L W VERT. AXIAL 7 7 9 400 3000 7 7 10.5 600 3000 7 7 12 800 3000 12 14 14 1200 11000 12 14 16.5 1600 11000 12 14 19 2000 11000 12 14 22 2550 11000 15 20 25 3150 10000 15 27.25 20 4020 10000 15 20 29 5090 9000 15 20 31 6360 9000 15 20 36 8820 8000 19 42.75 23 11000 15000 27.38 19 50 14000 15000

Features Matches standard 150# Flanges. Designed to prevent local overstress of FRP pipe due to component loads and moments. Application Used to support valves, regulators, flow meters, or other components used in piping systems.

2 Sides Typ.

Mfg. Recommended Gasket Flange Flat Washer Valve Lock Washer

3/16
W

L 12" AND LARGER ARE SCALLOPED TO PROVIDE CLEARANCE FOR THE RING HUB REINFORCEMENT SPECIFIED IN PS-15-69

NOTES
Hex Nut Lock Washer Flange Spot Face Area Component Support 60A, 60H, 60S, 60V HD Hex Nuts

1) "H" dimension may be change but load rating would change 2) 60A can be anchor by welding or bolting. 3) 12" and largers are scalloped to provide clearance for the ing hub reinforcement specified in PS-15-69
SUPPORT NO. BE-60A

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS COMPONENT SUPPORT ANCHOR

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A T G Rod VERT. AXIAL .563 .375 4 610 5.5 .563 .375 610 6.25 .563 .375 610 7.5 .563 .375 610 8.87 688 .5 1130 10.13 .813 .625 1810 11.75 .75 .75 2710 12.86 1 .75 2710 14.63 1.13 .875 3770 15.38 1.13 .875 3770 16.75 1.25 1 4960 19 1.25 1.25 6230 22.5 1.5 1.25 8300 25.86 1.75 1.5 11630

Features Matches standard 150# Flanges. Designed to prevent local overstress of FRP pipe due to component loads and moments. Cannot be used as an anchor Application Used to support valves, regulators, flow meters, or other components used in piping systems.

See BE-60RH for Rod Assy. Options

12" AND LARGER ARE SCALLOPED TO PROVIDE CLEARANCE FOR THE RING HUB REINFORCEMENT SPECIFIED IN PS-15-69

Mfg. Recommended Gasket Flange Flat Washer Valve Lock Washer

NOTES
Hex Nut Lock Washer Flange Spot Face Area Component Support 60A, 60H, 60S, 60V HD Hex Nuts

1) See drawing 60RH for hanger hardware. 2) 12" and larger are scalloped to provide clearance for the ring hub reinforcement specified in PS-16-69 3) Two hangers may be required with long components.
SUPPORT NO. BE-60H

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS COMPONENT HANGER SUPPORT

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36" ITEM 1 2 3 4

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A C E Rod VERT. AXIAL .375 730 .375 730 .375 730 .375 730 .5 1350 .625 2160 .75 3230 .75 3230 .875 4480 .875 4480 1 5900 1.25 9500 1.25 9500 1.5 13800 ROD HANGER LIST - TYPE 1 QTY FIG.NO. DESCRIPTION Beam Attachment 1 66 HD Hex Nut 3 HEX All Thread Rod 1 146 Clevis W Pin 1 299

NOTES 1) Two rod assemblies are options. Britt can supply separately. 2) Figure numbers refer to the Anvil Catalog. O 3) Rod load based on Anvil Catalog at 650 F
Mfg. Recommended Gasket Flange Flat Washer Valve Lock Washer All Thread Hex Nut Lock Washer Flange Spot Face Area Component Support 60A, 60H, 60S, 60V HD Hex Nuts

ITEM 1 2 3 4 5 6 7

ROD HANGER LIST - TYPE 2 QTY FIG.NO. DESCRIPTION 66 Beam Attachment 1 290 Weldless Eye-nut 1 146 All Thread Rod 1 HEX HD Hex nut 4 230 Turnbuckle w 6" Opening 1 253 LH/RH Machine Rod 10" Long 1 299 Clevis W Pin 1

Auxiliary Steel
1 Beam Attachment (Fig.66) 2 HD Hex Nut (typ.) 3

Weldless Eye-nut 2 (Fig.290) All Thread Rod (Fig.153)


3 4

All Thread Rod (Fig.153)

HD Hex Nut (typ) Turnbuckle (Fig.230)


5

LH/RH Machine Rod 6 (Fig.253)


4

Clevis w Pin (Fig.299)

Clevis w Pin 7 (Fig.299)

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS ROD HANGER HARDWARE

SUPPORT NO. BE-60RH


Rev1

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A B H W VERT. AXIAL 8 400 7.5 8 400 7.5 8 400 7.5 10 600 14.5 10 1400 14.5 10 1600 14.5 12 2000 14.5 3000 20.63 12 3300 20.63 15 3900 20.63 15 4600 20.63 15 6600 20.63 15 15 8300 23 11630 27.38 15

Features Matches standard 150# Flanges. Designed to prevent local overstress of FRP pipe due to component loads and moments. Cannot be used as an anchor Application Used to support valves, regulators, flow meters, or other components used in piping systems.

W
12" AND LARGER ARE SCALLOPED TO PROVIDE CLEARANCE FOR THE RING HUB REINFORCEMENT SPECIFIED IN PS-15-69

Mfg. Recommended Gasket Flange Flat Washer Valve Lock Washer

Hex Nut Lock Washer Flange Spot Face Area Component Support 60A, 60H, 60S, 60V HD Hex Nuts

NOTES 1) See drawing FC for flange connection. 2) 12" and larger are scalloped to provide clearance for the ring hub reinforcement specified in PS-16-69

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS COMPONENT STANCHION SUPPORT

SUPPORT NO. BE-60S

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A B C W VERT. AXIAL 115 7.5 4 200 9 4 325 10.5 4 580 12.5 4 1150 15 6 1640 17.5 6 2550 20.5 6 3150 22.5 6 4020 25 6 4300 26.5 6 4300 29 6 4300 33.5 6 4300 40.5 6 4300 47.5 6

Features Matches standard 150# Flanges Provides full 360o support. May be either T-pole supported, beam or rod supported. Provides full bearing support for components in vertical runs of pipe. Application Used to support valves, regulators, flow meters, or other components used in piping systems.

Mfg. Recommended Gasket Flange Flat Washer Valve Lock Washer All Thread Hex Nut Lock Washer Flange Spot Face Area Component Support 60A, 60H, 60S, 60V HD Hex Nuts

NOTES 1) May serve as anchor by bolting or welding to structural members. 2) 12" and larger are scalloped to provide clearance for the ring hub reinforcement specified in PS-16-69

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS COMPONENT RISER SUPPORT

SUPPORT NO. BE-60V

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A C H Type VERT. AXIAL 2 1 4 400 2 1 4 400 3 1 4 400 3 1 4 600 3 1 4 1400 3 1 4 2800 3 1 4 3100 4 2 4 3200 5 2 4 3800 6 2 4 4300 6 2 4 4300 6 2 4 6500 6 2 4 8700 8 2 4 14900

Features Provides full 360 o support. Full elastomer contact to eliminate chafing. Supports long vertical runs of pipe. Provides full bearing support. Application Used to support vertical runs of pipe to prevent buckling and overstress of horizontal sections of the pipe run.

FRP SHEAR COLLAR (see fig.130)

TYPE 1

2x2x1/4 CLIP ANGLES

PIPE O.D.

ELASTOMERIC LINER OR ALTERNATE MATERIAL

FRP SHEAR COLLAR (see fig.130)

TYPE 2

PIPE O.D.

NOTES 1) Shear Collar must be used, See Fig.130 (sold separately) 2) Clip Angles can be used if needed. Supplied separately
C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS RISER CLAMP SUPPORT

SUPPORT NO. BE-70

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A C H Type VERT. AXIAL 3 1 6 400 3 1 6 400 3 1 6 400 3 1 6 600 3 1 6 600 3 1 6 600 3 1 6 600 3 1 6 1200 3 1 6 1200 4 1 6 1600 4 1 6 1500 4 1 6 1500 6 2 6 2100 6 2 6 1900

NOTES

Features Provides full 360 o support and guiding of pipe Full elastomer contact to eliminate chafing. Stabilizes long vertical runs of pipe. Provides full bearing support. Application Used to support vertical runs of pipe to prevent buckling and overstress of horizontal sections of the pipe run.

TYPE 1
C PIPE O.D. SLEEVE 1/8 CLR. (TYP) H FRP SHEAR COLLAR (see fig. 130)

ANGLE 1x1x1/4 FIELD WELD TO SLEEVE OR AUX STEEL

ELASTOMERIC LINER OR ALTERNATE MATERIAL

TYPE 2
C PIPE O.D.

FRP SHEAR COLLAR (see fig. 130) SLEEVE

1/8 CLR. (TYP) H

ANGLE 1x1x1/4 FIELD WELD TO SLEEVE OR AUX STEEL

NOTES 1) Shear Collar must be used, See Fig.130 (sold separately) 2) Clip Angles not supplied unless requested.
C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS RISER CLAMP SUPPORT W/ GUIDES

SUPPORT NO. BE-70G

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) C G H Rod VERT. AXIAL .437 3 .375 400 6 .437 3 .375 400 6 .437 3 .375 400 6 .437 3 .625 600 6 .563 3 .625 1400 6 .563 4 .875 1800 6 .687 5 .875 2300 6 .687 6 .875 2600 6 .875 6 1.25 4500 6 .875 6 1.25 4500 6 .875 6 1.25 4500 6 1.25 8600 6 1.125 6 1.25 8000 6 1.125 6 1.25 6 1.25 10000 6

NOTES

Features Provides full 360 o support and guiding of pipe Full elastomer contact to eliminate chafing. Stabilizes long vertical runs of pipe. Provides full bearing support. Application Used to support vertical runs of pipe to prevent buckling and overstress of horizontal sections of the pipe run.

TYPE 1
ELASTOMERIC LINER OR ALTERNATE MATERIAL
FRP SHEAR COLLAR (see fig. 130) See BE-70RH for Rod Assy. Options

1-1/2 TYP. PIPE O.D. C

FRP SHEAR COLLAR (see fig. 130)

TYPE 2
G

1-1/2 TYP. PIPE O.D. C

NOTES 1) Shear Collar must be used, See Fig.130 (sold separately) 2) See drawing BE-70RH for Hardware.
C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS ROD HANGER RISER CLAMP SUPPORT

SUPPORT NO. BE-70H

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36" ITEM 1 2 3 4

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A C E Rod VERT. AXIAL .375 400 .375 400 .375 400 .625 600 .625 1400 .875 1800 .875 2300 .875 2600 1.25 4500 1.25 4500 1.25 4500 1.25 8600 1.25 8000 1.25 10000 ROD HANGER LIST - TYPE 1 QTY FIG.NO. DESCRIPTION Beam Attachment 1 66 HD Hex Nut 3 HEX All Thread Rod 1 146 Clevis W Pin 1 299

NOTES 1) Two rod assemblies are options. Britt can supply separately. 2) Figure numbers refer to the Anvil Catalog. 3) Shear Collar must be used, See Fig.130 (sold separately)

ITEM 1 2 3 4 5 6 7

ROD HANGER LIST - TYPE 2 QTY FIG.NO. DESCRIPTION 66 Beam Attachment 1 290 Weldless Eye-nut 1 146 All Thread Rod 1 HEX HD Hex nut 4 230 Turnbuckle w 6" Opening 1 253 LH/RH Machine Rod 10" Long 1 299 Clevis W Pin 1

Auxiliary Steel
1

Beam Attachment (Fig.66)


2

HD Hex Nut (typ)


3 All Thread Rod

Weldless Eye-nut 2 (Fig.290) All Thread Rod 3 (Fig.146) HD Hex Nut (typ.) 4 Turnbuckle 5 (Fig.230) LH/RH Machine Rod 6 (Fig.253)

(Fig.146)

Clevis w Pin (Fig.299)

Clevis w Pin (Fig.299) 7

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS ROD HANGER HARDWARE

SUPPORT NO. BE-70RH


Rev1

PIPE SUPPORT DATA PIPE LOAD RATINGS DIMENSIONS (INCHES) SIZE VERT. AXIAL A B C L 1.25 8 400 2" 1.25 8 600 3" 1.25 8 800 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

NOTES

Features Provides full 360 o support. Full elastomer contact to eliminate chafing. Allows axial movement while providing lateral restraint. Application Used to support and stabilize pipe between full pipe anchors to prevent buckling and overstress, or to restrain lateral movement due to expansion.

PIPE O.D.

ELASTOMERIC LINER OR ALTERNATE MATERIAL

1"x1"x1/4"x4" Angle See Fig. GA1

3 Sides Typ.

B.O.P.

3/16

1-5/8" std. or as specified

1/8"CLR. (TYP.)

NOTES 1) Clip Angles not supplied unless requested. See GA1. 2) Use BE-90 for 6" and above. 3) Top of Steel to Bottom of Pipe dimension may be modified.
C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS GUIDE SUPPORT

SUPPORT NO. BE-80

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A B C L VERT. AXIAL 1.25 400 8 1.25 600 8 1.25 800 8 2 1200 12 2 1600 12 2 2000 12 2 2400 12 2 3075 14 2 3385 14 2 4000 14 2 4710 14 2 6750 16 2 8525 20 2 11550 20

NOTES Features Provides full 360 o support. Full elastomer contact to eliminate chafing. Stabilizes long runs of pipe. Provides full bearing support. Allows axial movement while providing lateral restraint. Application Used to support and stabilize pipe between full pipe anchors to prevent buckling and overstress, or to restrain lateral movement due to expansion.

C
1"x1"x1/4"x4" Angle See Fig. GA1 OR Guide Clip See Fig. GC1

PIPE O.D.

ELASTOMERIC LINER OR ALTERNATE MATERIAL

3 Sides Typ.

B.O.P.

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

3/16

1-5/8"std. or as specified

1/8"CLR. (TYP.)

NOTES 1) Clip Angles not supplied unless requested. See GA1 2) Guide Clips (GC1) can be used in place of the Clip Angles (GC1sold separately). 3) Use 80G for 4" and under. 4) Top of Steel to Bottom of Pipe dimension may be modified.
FRP PIPE SUPPORT STANDARDS GUIDE SUPPORT SUPPORT NO. BE-90A

PIPE SUPPORT DATA PIPE LOAD RATINGS DIMENSIONS (INCHES) SIZE VERT. AXIAL A B C L 8 400 2" 8 600 3" 8 800 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

NOTES Features Provides full 360 o support. Full elastomer contact to eliminate chafing. Allows axial movement while providing lateral restraint. Application Used to support and stabilize pipe between full pipe anchors to prevent buckling and overstress, or to restrain lateral movement due to expansion.

PIPE O.D. 1/8"Clear (typ.) 1" Clear

3/4 x 0.20 Stainless Steel Strapping (see note 3)

ELASTOMERIC LINER OR ALTERNATE MATERIAL B.O.P

3/8"

Heavy Hex Nuts (4 Req'd)

NOTES 1) Old type support - Recommend use of 80G. 2) Use BE-90 for 6" and above. 3) 2) SS Banding sold separate in 100' rolls
C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS GUIDE SUPPORT

SUPPORT NO. BE-80S

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A B C L VERT. AXIAL 1.25 400 8 1.25 600 8 1.25 800 8 2 1200 12 2 1450 12 2 1650 12 2 2065 12 2 3120 14 2 3440 14 2 4055 14 2 4775 14 2 6835 16 2 8525 20 2 11750 20

NOTES Features Provides full 360 o support. Full elastomer contact to eliminate chafing. Stabilizes long runs of pipe. Provides full bearing support. Allows axial movement while providing lateral restraint. Application Used to support and stabilize pipe between full pipe anchors to prevent buckling and overstress, or to restrain lateral movement due to expansion.

PIPE O.D.
ELASTOMERIC LINER OR ALTERNATE MATERIAL

3 Sides Typ.

B.O.P

1"x1"x1/4"x4" Angle See Fig. GA1 OR Guide Clip See Fig. GC1

3/16
B
1/8"CLR. (TYP.)

4"

INSULATION BAND SLOTS

NOTES 1) Clip Angles not supplied unless requested. See GA1 2) Guide Clips (GC1) can be used in place of the Clip Angles (GC1 sold separately).
C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS INSULATED GUIDE SUPPORT

SUPPORT NO. BE-90K

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A B C L VERT. AXIAL 2 400 1500 6 2 600 2200 6 2 800 3000 6 2 1200 3000 6 2 1600 4000 12 2 2000 4000 12 2 2400 4000 12

NOTES

Features Provides full 360 o support. Full elastomer contact to eliminate chafing. Low profile to prevent bending. Designed to absorb full anchor loads and fully restrain pipe without local overstress. Application Used for anchoring long horizontal runs of FRP pipe where restraint of thermal expansion is required.

FRP SHEAR COLLAR (see fig. 130)

PIPE O.D.

ELASTOMERIC LINER OR ALTERNATE MATERIAL


B.O.P.

Typ.

3/16

1-5/8" std. or as specified

NOTES 1) Shear Collar must be used for Axial Load, See Fig.130 (sold separately). 2) Use Fig.110 for pipe sizes above 12"

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS LIGHT DUTY ANCHOR

SUPPORT NO. BE-100

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A B C L VERT. AXIAL 2 400 6 1500 2 600 6 2200 2 800 6 3000 2 1200 4000 12 2 1600 7000 12 2 2000 10200 12 2 2400 14650 12 2 3125 20000 14 2 3440 26100 14 2 4060 28000 14 2 4780 30370 14 2 6345 42560 16 2 8660 50000 20 2 11600 60000 20

NOTES

Features Provides full 360 o support. Full elastomer contact to eliminate chafing. Low profile to prevent bending. Designed to absorb full anchor loads and fully restrain pipe without local overstress. Extended length provides margin for extended spans. Application Used for anchoring long horizontal runs of FRP pipe where restraint of thermal expansion is required.

FRP SHEAR COLLAR (see fig. 130) C PIPE O.D.

ELASTOMERIC LINER OR ALTERNATE MATERIAL

B.O.P.

Typ.

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

3/16

1-5/8" std. or as specified

NOTES 1) Shear Collar must be used for Axial Load, See Fig.130 (sold separately).

FRP PIPE SUPPORT STANDARDS HEAVY DUTY ANCHOR

SUPPORT NO. BE-110

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A B C L VERT. AXIAL 2 400 4 12 550 2 400 4 12 1130 2 400 4 12 1810 2 600 6 12 4000 2 1450 6700 6 12 2 1650 10200 6 12 2 2065 14650 6 12 2 3120 20000 8 14 2 3440 26100 8 14 2 4055 28000 8 14 2 4775 30370 8 16 2 6850 42560 10 20 2 8660 50000 10 20 2 11600 60000 10 20

NOTES

Features Provides full 360 o support. Full elastomer contact to eliminate chafing. Low profile to prevent bending. Designed to absorb full anchor loads and fully restrain pipe without local overstress. Extended length provides margin for extended spans. Application Used for anchoring long horizontal runs of FRP pipe where restraint of thermal expansion is required.

FRP SHEAR COLLAR (see fig. 130)

PIPE O.D.
ELASTOMERIC LINER OR ALTERNATE MATERIAL

B.O.P
3/16
B

Typ.

4"

INSULATION BAND SLOTS

NOTES 1) Shear Collar must be used for Axial Load, See Fig.130 (sold separately)

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS INSULATED ANCHOR

SUPPORT NO. BE-110K

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A L T ROD VERT. AXIAL 610 3 .375 6 610 4.75 .375 6 610 5.75 .375 6 610 7.75 .375 6 1130 9.75 .5 8 1810 8 11.75 .625 2710 14 .750 12 2710 12 16.25 .750 3770 12 18.38 .875 3770 12 20.63 .875 4960 1 14 22.75

NOTES Features Provides full 180 o support. Extended length provides margin for extended spans. Full elastomer contact prevents chafing. Application Used to support FRP pipe where support structure cannot be installed below pipe. Due to flexibility of FRP pipe this support should not be used exclusively in long runs of pipe. To provide stability, pipe guides or anchors should be used intermittently to control expansion and to reduce vibration. Used in new installations where support can be slipped on pipe without opening strap.

See BE-120RH for Rod Assy. Options

ELASTOMERIC LINER OR ALTERNATE MATERIAL

NOTES 1) See drawing 120RH for hanger hardware. 2) Use Fig.120C for 24" and above.

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS HANGER

SUPPORT NO. BE-120

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A L T ROD VERT. AXIAL 610 5.63 .375 6 610 6.13 .375 6 610 7.38 .375 6 610 8.88 .375 6 1130 9.88 .5 8 1810 8 11.75 .625 2710 13 .750 12 2710 12 14.5 .750 3770 12 17.13 .875 3770 12 18.25 .875 4960 1 14 19.88 6833 16 22.38 1.25 8000 16 26.13 1.25 11630 16 30.13 1.5

NOTES Features Provides full 180 o support. Extended length provides margin for extended spans. Full elastomer contact prevents chafing. Application Used to support FRP pipe where support structure cannot be installed below pipe. Due to flexibility of FRP pipe this support should not be used exclusively in long runs of pipe. To provide stability, pipe guides or anchors should be used intermittently to control expansion and to reduce vibration.Used where support cannot be slipped over pipe or where disassembly of support is required.

See BE-120RH for Rod Assy. Options

ELASTOMERIC LINER OR ALTERNATE MATERIAL

NOTES 1) See drawing 120RH for hanger hardware. 2) Easy installation if pipe is already installed.

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS HANGER

SUPPORT NO. BE-120C

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36" ITEM 1 2 3 4

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A B C Rod VERT. AXIAL .375 400 .375 400 .375 400 .375 600 .5 1400 .5 1800 .625 2300 .625 2600 .75 4500 .75 4500 .75 4500 .875 8600 .875 8000 1.25 10000 ROD HANGER LIST - TYPE 1 QTY FIG.NO. DESCRIPTION Beam Attachment 1 66 HD Hex Nut 4 HEX All Thread Rod 1 146 Clevis W Pin 1 299

NOTES 1) Two rod assemblies are options that Britt can supply separately. 2) Figure numbers refer to the Anvil Catalog.

ITEM 1 2 3 4 5 6

ROD HANGER LIST - TYPE 2 QTY FIG.NO. DESCRIPTION 66 Beam Attachment 1 290 Weldless Eye-nut 1 146 All Thread Rod 1 HEX HD Hex nut 5 230 Turnbuckle w 6" Opening 1 253 LH/RH Machine Rod 10" Long 1

Auxiliary Steel
1

Beam Attachment (Fig.66)


2 HD Hex Nut (3) 3 All Thread Rod

Weldless Eye-nut 2 (Fig.290) All Thread Rod 3 (Fig.146) HD Hex Nut (8) 4 Turnbuckle 5 (Fig.230) LH/RH Machine Rod 6 (Fig.253)

(Fig.153)

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS ROD HANGER HARDWARE

SUPPORT NO. BE-120RH


Rev1

PIPE SUPPORT DATA PIPE LOAD RATINGS DIMENSIONS (INCHES) SIZE VERT. AXIAL A B C D 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

NOTES 1) Guide Clips ordered separately from guides 2) Dimensions may be modified to allow for baseplate thickness.

3/16

3 sides

GC-1

5.250

1/8"CLR. (TYP.)

5.250

GC-2

2.75

1/8"CLR. (TYP.) 1"

3/16

CA-1

4"

3 sides

1/8"CLR. (TYP.)

Application Guide Clips limit lateral and vertical. Guide Angles limit lateral movement where welding on the edge is acceptable.
C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS GUIDE CLIP HARDWARE

SUPPORT NO. BE-GUIDE CLIPS

PIPE SIZE 2" 3" 4" 6" 8" 10" 12" 14" 16" 18" 20" 24" 30" 36"

PIPE SUPPORT DATA LOAD RATINGS DIMENSIONS (INCHES) A B T W VERT. AXIAL .375 3 .375 3 .375 3 .375 3 .375 3 .375 3 .375 3 .625 3 .625 3 .625 4 .625 4 .625 4 .750 6 .750 6

NOTES 1) Installation kit includes FRP roller, resin cup for mixing, resin, hardener and mat cut to length. 2) Orders less than 4 kits does not include tools.

W FRP Shear Collar flush (even) with support W

T T

FRP Shear Collar Flush with outside diameter of pipe support.

BASIC INSTALLATION PROCEDURE 1. Grind down 1/16" or less of the outside of pipe from the support to the width of the shear collar. Clean area and tape off support edge where shear collar will contact the support. 2. Mix only enough resin and catalyst to install the shear collar. Collars over 3/8" thick will have to be done in phases, allowing each phase to cure. After curing, rough up with sandpaper or grinder. 3. Wet out the shear collar mats one at a time. Do about 3 to 4 layers at a time. 4. Apply the resin coated mats to the prepared pipe area and flush to the support. 5. Gently using the fiberglass roller, roll out the fiberglass mat to remove air bubbles. 6. Wet out remaining mats and repeat steps 4 and 5. 7. More detail information is available upon request. Also Britt has trained personal that can field train your personal to install shear collars and pipe field joints. QC inspectors are also available for inspections.

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS FRP SHEAR COLLAR

SUPPORT NO. BE-130

BC-01 BC-02

HD-3

HD-2

BRITT can also supply you with Anvil type parts such as turnbuckles all tread rods, cleviss, clamps, U-bolts, supports for HDPE & steel pipe, spring hangers , auxiliary steel and what ever hardware you might need for your application.

C copyright 2009. All rights reserved.

Britt Pipe Supports. P.O.Box 101267 Birmingham, Al 35210 (205) 951-5691


email: sales@brittengineering.com

FRP PIPE SUPPORT STANDARDS PIPE HARDWARE

SUPPORT NO.

britt engineering
FRP PIPING DESIGN MANUAL 2009

be

P.O.Box 320325 Birmingham, AL 35232 (205) 951-5691 (205) 951-5601 FAX email: wfbritt@aol.com web site: brittengineering.com

Experience First
C copyright 2009. All rights reserved.

Supports for FRP Piping


This catalog presents a complete line of supports that was developed specifically for Fiberglass Reinforced Plastic (FRP) Pipe. Many of the design features have been the result of suggestions from design engineers and construction people who have determined how improvements would make the design and installation easier and faster. This family of designs is 18 years old and yet continues to grow and improve because we listen to the people who use them. In the late 60's and early 70's, FRP materials were being developed that would propel the market of FRP pipe to new heights. FRP was being specified in new applications where only specialty alloys had been used and, as the applications expanded, FRP was becoming the c o m p l e t e p r o b l e m s o l v e r. Resin manufacturers were developing new Polyester and Vinyl Esters. Fabricators were developing manufacturing methods that improved quality and reduced costs. In 1974 reports indicated that corrosion applications of FRP was to be the growth industry of the future but about that same time some users were finding that frequent piping failures were causing concern. One of the major manufacturers of resins determined that most of the piping failures could be eliminated through the use of proper supports, guides and anchors. The technical information presented in this catalog is the result of the cooperative effort of this manufacturer and an engineering firm that resulted in the installation of a completely successful system that used FRP almost exclusively. These principles of pipe design along with the supports in this catalog have been used in thousands of piping systems with complete success. When deviations to catalog standards are required, britt engineering is prepared to provide design assistance and is equipped to furnish any specials that might be required. britt engineering is continually cooperating with engineers, designers, and construction personnel in the specification of hangers and supports, and will assist in the
Britt Engineering, Inc. P.O.Box 320325 Birmingham, Al 35232-0325 (205) 951-5691
Support Design Tips

interpretation of applicable piping codes. All supports are manufactured in the US using domestic materials only. britt engineering supports are almost always made to order since the outside diameter of FRP pipe varies depending on the manufacturer, wall thickness, and corrosion liner thickness. Being custom made it is important to order the supports as early in the schedule as possible. The company will work closely with your engineering and purchasing department to insure the best possible fit up of support to pipe and that schedules are met. The supports shown in this catalog are intended for installation and service as designed and specified herein. Exceeding support spans, hanging one pipe beneath another, lack of component support and attempting to modify supports are some examples of misapplication. If there is a question about application, call britt engineering. Our supports are manufactured to comply with strict standards and care must be exercised to prevent misuse.

SUPPORT NO. SDT-1


C copyright 2009. All rights reserved.

FOWARD

Review piping specifications. Review piping drawings. Review structural drawings Review valve and fitting specifications. Locate possible hanger locations. Analyze thermal movement, stress and flexibility of the piping system. Calculate hanger loads. Select hanger types. Check hanger clearance around existing piping and equipment Notes: The following notes concerning the design and installation of FRP pipe and supports are provided as a help to the designer or engineer. These design notes are intended to serve as a guide to the proper use of the supports described in this catalog and while it is impossible to cover every piping condition, experience indicates that approximately 95% of the support requirements can be met through the use of these standard designs. If the designer is faced with special conditions where a special design might be required he should contact britt engineering for assistance. The principles of design and analysis for FRP pipe differ considerably from the principles of design for metallic pipe. The analysis of steel pipe normally begins with maximum flexibility and the final support-guide-anchor design ends when allowables are achieved. When dealing with FRP pipe, the analysis normally begins with a fully anchored system and the final support-guide-anchor configuration is established when the minimum stress condition is reached (based on the available structural steel). The fully anchored FRP piping system is often referred to as an anchor to anchor system. This simply means that an anchor is placed at
Britt Engineering, Inc. P.O.Box 320325 Birmingham, Al 35232-0325 (205) 951-5691

each end of a straight run of piping. The pipe is restrained by the anchors from growing thermally and is guided to prevent buckling. This arrangement is never considered with metallic pipe but the low compressive modulus of FRP allows anchoring. The anchor loads are normally less than 1/60th that of steel but must be considered in the structural design of the support system, especially in large diameter pipe. Many vendor catalogs include tables that the designer can use to determine support, guides and hanger spacings. The spacings are usually based on a specific gravity of 1.2, a liquid temperature of 160 or 180 degrees F, and a limited deflection of 1/2". This information is useful for estimating but in most instances the spacings are not based on total pipe stress. Very seldom is pressure stress considered in the derivation of these tables. In FRP piping systems it is very important that the total stress be considered when selecting support spans. By using the equations presented In the technical section of this catalog the designer can accurately define support and guide spacings and be assured that the pipe is designed to operate within the specified allowable stress. The use of the procedures outlined in the Technical Section of this catalog will
SUPPORT NO. SDT-2
C copyright 2009. All rights reserved.

Support Design Tips

CHOOSING SUPPORTS

greatly improve the reliability and service life of any FRP piping system. The same procedures will work equally well with duct systems. As these procedures were being developed it became evident that there were no commercially available standard supports for FRP piping. Many different designs were illustrated in many of the catalogs but a review of the designs indicated that additional work would be needed to make them work. britt engineering developed a family of special FRP pipe support designs that was based on the maximum loads that might be expected in FRP piping. This family of supports has been used in almost every environment and in almost every condition found in process industries. Over the past 18 years new designs have been added to expand the applications and the size range was extended to pipe diameters of 108" and 120". When specifying the supports shown in this catalog the designer will recognize the ease of application and will become familiar with the unique features that are important to the design of an FRP system. The long support with a full bonded liner eliminates failures due to local stresses. The low profile of all britt engineering supports keeps the pipe close to the structural steel thus reducing the size and amount of auxiliary steel. Selecting standards greatly reduces design time and the standardization of supports reduces manufacturing costs. Interchange ability and standardization reduces or eliminates all field rework thereby reducing construction costs. Each support is clearly marked for easy identification. As a word of caution, the designer is reminded to call britt engineering when the need for sizes and loads exceed the support tables in this catalog. While britt engineering has other standards that have been developed for special applications, the use of these supports must be checked against actual conditions. Duct systems can be supported using the same basic designs shown in this catalog; however, since duct systems very seldom have fluid loads, the supports can be much lighter. When specifying supports for ducting simply add a "D" to the Fig.No. (Fig.20"D"). All
Britt Engineering, Inc. P.O.Box 320325 Birmingham, Al 35232-0325 (205) 951-5691

installation dimensions remain the same. The designer should review the following design considerations to insure that all supports are correctly used. If there are any deviations from these standard practices and designs the designer should contact britt engineering. 1. FITUP of SUPPORT - The designer must specify the maximum OD of the FRP pipe to insure proper support fit. Pipe specifications normally require the pipe manufacturer to maintain a tolerance +1/8" -0.0" on the OD and the manufacturer is required to state the maximum OD in his quotation. The support will be manufactured to fit within 1/16" of the maximum OD. 2. LOCATION of SUPPORTS - When supporting pipe inside of a building, the building steel will provide the easiest support points. If the support spacing is based on the spacing of the structural steel, and is found to exceed the calculated support spacing, use a slightly (1/16") thicker pipe wall and re-run spacing calculations. Continue adding wall thickness until the required span is reached or until added wall thickness starts to decrease span capability. If the pipe will not span, then intermediate supports, requiring the addition of auxiliary steel, are required. Of course a comparison of the increased pipe cost vs. the cost of auxiliary steel will allow the designer to decide whether a heavier pipe will offer advantages. 3. LOCATION of GUIDES - Guides serve as supports and also provide lateral restraint to prevent buckling of the pipe when the pipe expands due to elevated temperatures. Smaller piping will require more frequent guiding and in some cases the use of guides may be required at every support point. Larger piping may require every other support point to be a guide. Calculations should be made to determine exact requirements.

Support Design Tips

SUPPORT NO. SDT-3


C copyright 2009. All rights reserved.

CHOOSING SUPPORTS

5. FIXING of ANCHORS - FRP anchors are designed to lightly grip the pipe and are never to be allowed to clamp the pipe with any excessive force. The anchor is fixed to the pipe by applying shear collars, or FRP bands to the pipe on either side of the anchor. Except for very unusual cases the collars are applied in the field after the anchor has been installed. The collars are built up of layer's of 1-1/2 oz. mat to a thickness that allows the anchor to bear against the collar. See Fig.130 6. RISER SUPPORTS - Vertical runs of pipe inside of a building normally are supported on floor sleeves or off of curbs surrounding a pipe chase through the floor. Riser supports or riser guides when required, are fixed to the pipe using the same shear collars as used with anchors, however the collar need only be applied to the top side of the support so that the weight of the riser can be carried by the riser support. The rule for riser guide spacing is the same as other guides unless the pipe is subjected to wind loads where more frequent guiding is required. It is important to note that loads for riser supports can be very high, especially in large diameter pipe. Loads in excess of support ratings will require special designs and should be brought to the attention of britt engineering 7. SUPPORTS for INSULATED PIPE Special supports are used to accommodate up to 4" of insulation. In all except very special cases the supports, anchors, and guides are attached to the pipe and are not designed to clamp or support the outside of the insulation. When heat tracing is required the tracing passes outside of the support. *** Important *** If heat tracing is required contact britt engineering for special details and designs. 8. COMPONENT SUPPORTS - It is very important that all valves and inline components be supported independently of the pipe. In some instances it is necessary to anchor the component
Britt Engineering, Inc. P.O.Box 320325 Birmingham, Al 35232-0325 (205) 951-5691

where heavy actuator's are cantilevered off of the valve or component or where external loads or dynamics might damage the pipe. Components in vertical and horizontal pipe runs require support although components in vertical runs may not require independent support of each component, 9. EXPANSION - The thermal expansion of FRP is two to three times that of steel and requires special attention especially where a fully anchored system is not used. Expansion joints and expansion loops are sometimes specified but these add a weakness to the system. Expansion loops in addition to adding extra piping, will add as many as four fittings and at least eight more joints. Each joint is an additional point of weakness. If lack of structural restraint presents a problem where anchor loads might preclude the use of the anchored system, there are several other design methods that can be employed, but in most cases the anchored system can be incorporated. The description of the other design methods are beyond the scope of this manual because these are special cases. If there is a problem in using the anchored technique call britt engineering and we will be glad to discuss specific applications. 10. COATINGS - The standard coatings for britt engineering supports is either a high quality prime coat that is applied by spray coating, or hot dip galvanize. Paint systems are in compliance with EPA regulations regarding VOC and hazardous materials. It is very important that the designer select a corrosion resistant coating that will withstand the environmental conditions in the area where the pipe supports are to be installed. If special high performance coatings are required these should be specified in the purchase documents. britt engineering is able to provide any coating system that might be required and can also provide assistance in the selection of special coatings

Support Design Tips

SUPPORT NO. SDT-4


C copyright 2009. All rights reserved.

CHOOSING SUPPORTS

Britt Engineering, Inc. P.O.Box 320325 Birmingham, Al 35232-0325 (205) 951-5691

Support Design Tips

SUPPORT NO. SDT-6


C copyright 2009. All rights reserved.

CHOOSING SUPPORTS

Design Considerations for FRP Piping Systems

Background The use of fiberglass reinforced plastic (FRP) in the construction of pipe for process piping systems is becoming more and more popular. The possibilities of its utilization in new and unique ways have outgrown the available body of knowledge necessary to assure its proper application. The shared interest among designers is to extend the range and quality of those and other new applications. There are many years of practical experience in every area of FRP application, yet there is little published data that would allow an engineer to establish basic ground rules for the design of an FRP process piping system. Recently, there has been tremendous growth in the use of FRP in piping systems and it appears that this growth will continue. The purpose of this report is to present the basic principles that have been used successfully to design FRP piping systems and also to describe problem areas that have caused difficulty. The main emphasis of this report is toward piping design rather than material selection. The task of material selection has been much simplified through the efforts of resin suppliers who provide complete corrosion data for the proper selection of a resin system. Most resin suppliers will also provide case histories detailing the behavior of their products in almost every environment and application.

Mechanical Properties After the selection of a resin system, a determination as to the type of pipe must be made. There are three major categories of FRP pipe construction. They are: (1) contact molded, (2) filament wound, and (3) centrifugally cast. The mechanical properties of the pipe are closely linked to the method of fabrication and those properties vary considerably among the three types. Despite conjecture as to the advantages and disadvantages of each type of pipe construction, it has been found that any of the three can be utilized if the pipe is of high quality and if the system has been properly designed and supported. The specific mechanical properties of the pipe selected are incorporated into the design of the system. This includes the location and type of support. The mechanical properties inherent to the method of pipe fabrication are discussed in a later section. The most important factor in the design of a piping system is the determination of the mechanical properties of the pipe over the operational temperature range of the system. The catalogs for many pipe manufacturers list the range of properties for various laminates, but very few provide performance data at elevated temperatures. The equation which is used to determine the design aspects of any structural system utilizes factors for the mechanical properties under the expected design conditions, including temperature. Without this information, the designer is severely handicapped.

Britt Engineering, Inc. P.O.Box 320325 Birmingham, Al 35232-0325 (205) 951-5691

Design Considerations for FRP Piping Systems

SUPPORT NO. TS-1


C copyright 2009. All rights reserved.

TECHNICAL SECTION

Support Design
FA FA
LS
y

ANCHOR LOAD
FA
=

SUPPORT SPAN REQUIREMENTS:


A. DEFLECTION LIMITED, T
+

y = 1/2 INCH 1 12 tu 5 p

At ET

P Af LS =
PRESSURE LOAD

THERMAL LOAD

4 460.8 E I W n= .67 W nS

B. STRESS LIMITED LS =

USE SMALLEST VALUE

WHERE:

= THERMAL COEFICIENT OF EXPANSION

At = CROSS-SECTIONAL AREA, TOTAL WALL, in. T = T OP - T INS,


F
2

WHERE: E = YOUNG'S TENSILE MODULUS AT OPERATING TEMP lb/in.2 ., 4 = MOMENT OF INERTIA, STRUCTURAL WALL, in. I

W
Di
2

= WEIGHT/FOOT.PIPE + FLUID, lb/ft.

P = MAXIMUM OPERATING PRESSURE, lb/in. Af = FLOW AREA, =


4

n = NET ALLOWABLE STRESS, lb/in.

2 2

tu = ULTIMATE TENSILE STRESS, lb/in. p = PRESSURE STRESS,


P As

NOTE: ANCHOR LOAD IS INDEPENDENT OF PIPE LENGTH

At
3

S = SECTION MODULUS, STRUCTURAL WALL, in. As = AREA, STRUCTURAL WALL


FIGURE 3 - Anchor loads FIGURE 4 - Support Spans.

Lr

LG Lo

OFF-SET LEG (Lo) REQUIREMENTS:


A. STRESS LIMITED (CANTILEVER BEAM WITH LOAD AT FREE END) LO = 3 L E DO n 1 12

GUIDE SPACING REQUIREMENTS:


2

LG =

At

I I T (2)

1 12

EULER EQUATION FOR PIN ENDED COLUMNS

B. BENDING MOMENT LIMITED LO = 6 LEI MMAX 1 12

USE LARGEST VALUE

WHERE:

WHERE: LG = GUIDE SPACING ft.

Lr
L

= LONGEST RUN INTO ELBOW. (ft. in.) = THERMAL EXPANSION = L r T , in. (12)

I At W

= MOMENT OF INERTIA, STRUCTURAL WALL, in. = CROSS-SECTIONAL AREA, TOTAL WALL, in.2 = COEFFICIENT OF EXPANSION, in./in.- F

= YOUNG'S TENSILE MODULUS AT OPERATING TEMP lb/in.2 .,

T = T OP - T INS, F (2) = FACTOR FOR ECCENTRICITY OF LOADING OR DEVIATION FROM PIN COLUMN

Do = PIPE OUTSIDE DIAMETER, in n = NET ALLOWABLE STRESS MMAX = MAXIMUM ALLOWABLE BENDING MOMENT, in.-lb (MANUFACTURER'S TEST DATA)
FIGURE 5 - Offsets

FIGURE 6 - Guide Spacing

Britt Engineering, Inc. P.O.Box 320325 Birmingham, Al 35232-0325 (205) 951-5691

Design Considerations for FRP Piping Systems

SUPPORT NO. TS-2


C copyright 2009. All rights reserved.

TECHNICAL SECTION

Et TENSILE MODULUS x 106 PSI

Figure 1 shows the change in modulus at elevated temperatures for two filament wound polyester pipes. This type of data is required in system analysis if the design is to be sound.

1.0

.75

.50

.25

Thin Wall Pipe Heavy Wall Pipe

50

100

150

200

OPERATING TEMPERATURE

FIGURE 1 - Tensile modulus, E t vs temperature, F

Comparisons The following compares and contrasts the design features and advantages of the three types of FRP pipe: Contact Molded. The high resin to glass fiber ratio of this pipe makes it ideal for highly corrosive fluids. In order to meet the strength requirements in the hoop direction, it usually has a thicker wall than the other types of pipe. For this reason, it is heavier. Also, since it is virtually hand made, it is more expensive. Strength in the axial direction is higher than filament wound pipe. Because the pipe is hand made, it is subject to wider manufacturing tolerances than the other types of pipe. This is especially important to the support designer who is responsible for the designed fit of supports. Contact molded pipe is highly recommended for use where it might be subject to a severe exterior environment. Fittings are normally joined to the pipe using the butt and strap method. Filament Wound. A high glass content and precise fiber orientation make this type of pipe ideal for pressure applications. Machines are used more in its fabrication so the tolerances are closer, the mechanical properties more consistent, and the production cost is lower than for contact molded pipe. Due to the low resin to glass fiber ratio, a corrosion liner of a minimum 100 mils should be provided. Since
Britt Engineering, Inc. P.O.Box 320325 Birmingham, Al 35232-0325 (205) 951-5691

the axial strength of filament wound pipe is less than that for contact molded pipe, at the same pressure rating, the filament wound pipe will require a much closer support spacing. This is due to the thinner wall common with filament wound pipe. The preferred method of joining fittings and pipe is the butt and strap method, although several manufacturers provide tapered bell and spigot ends for joining pipe and fittings. The bell and spigot joint is an adhesive joint that is dependent on the glue line between the bell and spigot. Centrifugally Cast. This type of pipe is almost fully machine made and it provides the most consistent mechanical properties and the closest tolerances. It has a lower glass fiber content than filament wound pipe and features higher corrosion resistance. The smooth outside diameter also facilitates a more consistent support design. Cast pipe, due to fiber orientation and higher glass content, has a higher axial strength than either the filament wound or contact molded pipe. Cast pipe has an unreinforced corrosion liner which is susceptible to damage by impact, but if the pipe is properly handled and supported, it should pose no problems. Fittings are normally of the socket weld type that can be over wrapped if added joint security is desired. However, with correct installation procedures and inspection, the over wrap is generally considered unnecessary.
SUPPORT NO. TS-3
C copyright 2009. All rights reserved.

Design Considerations for FRP Piping Systems

TECHNICAL SECTION

Design Considerations Contact molded FRP pipe, made according to PS 15-69, is normally rated by pressure in increments of 25 psi up to 150 psi. Standard machine made pipe does not follow this type of rating and the designers should refer to the ultimate pressure rating listed in the manufacturer's catalog. It is important to note that these ratings are based on the allowable pressure of a continuously supported pipe subject to pressure stress only. Since piping systems are almost never continuously supported, the stresses of bending must be considered when determining the allowable working pressure of an FRP pipe. The equations presented in the section on Support Design take these stresses into account. Wall thicknesses are based on a 10:1 safety factor in the hoop direction and it is customary to use a 5:1 or 6:1 safely factor in the axial direction. By maintaining these safety factors in the design, stress risers in elbows and other fittings will be within the allowable stress limit. The method of design layout preferred by britt engineering is an anchor to anchor design. This design method can be economical and offers many advantages. The anchor to anchor system is more rigid and less susceptible to damage due to dynamic loading. This system also provides a means for controlling expansion (thermal and pressure), thereby reducing the length of offsets and eliminating the need for expansion joints. Anchors are placed on either side of every change in pipe direction and as near to the fitting as possible. The amount of structural steel required to absorb the loads imposed on the anchors can be minimized by keeping the pipe elevation close to the steel and by utilizing tension members between anchors. It is important to recognize that the pipe must be guided between anchors to prevent buckling. In cases where there are long straight runs, anchors should be placed no more than 150 to 200 feet apart. When the anchor to anchor design cannot be used and the pipe must be hung with rod hangers, a great deal of care should be taken to ensure flexibility. However, a pumped
Britt Engineering, Inc. P.O.Box 320325 Birmingham, Al 35232-0325 (205) 951-5691

system that is too flexible will vibrate and destroy itself if vibrations are within the resonant range. Excessive stresses can also be induced by wind loads. To reduce vibration and wind load effects, the pipe should be laterally restrained at specified intervals along the pipe. These restraints should not be located near changes in direction where offset legs are required for flexibility. Design Techniques Many piping system failures that occur during hydrostatic testing, or even after years of service, have been attributed to poor workmanship. These failures are due to an overstress condition which was caused by either poor workmanship or unsatisfactory design. The task of the designer is to eliminate, as much as possible, the likelihood of failure. With sufficient effort spent on the design and in the instruction of installation personnel, failures can be effectively reduced. It is hoped that the design techniques presented here will help to standardize a conservative design approach. Beyond this, a great deal of work is necessary to standardize installation techniques, especially the methods for fabricating joints. In an effort to reduce the possibility of failure, the designer should seriously consider the following: Keep the pipe run away from high traffic areas where damage from equipment impact is likely. Keep flange joints to a minimum. Provide vents at each high point. Provide drains at each low point or pocket. (Drains with blind flanges will allow the line to be drained if repairs are necessary.) Ensure that all supports, anchors, and guides are installed prior to the hydrotest. (This cannot be over emphasized since

Design Considerations for FRP Piping Systems

SUPPORT NO. TS-4


C copyright 2009. All rights reserved.

TECHNICAL SECTION

the pipe system can be severely damaged without proper pipe support.) All valves and valve operators, or components in the system, must be independently supported. Riser supports for long vertical runs should be guided or restrained to reduce vibration and wind load effects. When setting up for hydrotesting, open all high point vents to remove all air and connect the pump to the lowest point in the system. (The pump should be a small, positive displacement pump [3 to 5 gpm] and should be equipped with a pressure regulator that will allow the system pressure to build slowly.) Economic Considerations With material prices and the cost of labor rising frequently, a cost comparison between an FRP system and any other is meaningless since cost data is out of date before it is printed. FRP is normally selected because of its corrosion resistance, however one important point that should be made concerning any comparison is that the total installed cost be considered. Many studies do not include data on the support system required for FRP pipe. This is because most analysis procedures tend to regard all piping systems as being supported in the same manner and at the same relative cost. In addition, the cost of auxiliary steel, and the labor necessary to install that steel, should be evaluated. The service life of each system is an important factor and should be included in the evaluation if sufficient historical data can be obtained. Many designers would probably elect to use materials other than FRP when the installed price of the two systems is relatively close, but the extended service life of FRP systems will usually be more favorable. Generally, experience at britt engineering has indicated that FRP systems are more economical than other systems in pipe sizes above 4 inches where special metallic materials are considered.

Applicable Codes and Standards There are very few codes or standards applicable to the design of FRP piping systems. The designer should be familiar with the American National Standard Code for Pressure Piping (ANSI) B31.3, although it deals mainly with metallic pipe it has been expanded to cover non-metallics including thermoplastic and thermoset materials. The only other standard that could prove useful for design purposes is the NBS Voluntary Product Standard PS 15-69, which covers custom contact molded FRP equipment. This document is no longer published by NPS but copies can be obtained through some of the resin and glass manufacturers. The tables for pipe included in this Standard should be used with care. The American Society for Testing and Materials (ASTM) has published standards for Plastic Pipe and Building Products, Section 8, Volume 08.04, 1993. This document is a compilation of test procedures and methods for establishing material and mechanical properties for plastics used in piping. A number of codes and standards are being developed to promote standardization of the product but they are not available at this time. One excellent guide that is available is a book entitled "Corrosion -- Resistant Plastic Composites in Chemical Plant Design" by J. H. Mallinson, published by Marcel Dekker, New York , 1988. Another book that provides good overall coverage of the use of FRP is "Fiberglass Reinforced Plastics Deskbook" by N.P. and P.N. Cheremisinoff, Ann Arbor Science, Michigan, 1978. The Composites Institute of the Society of Plastics Industry published a "Fiberglass Pipe Handbook" in 1989 that is a document that was written by the Fiberglass Pipe Institute, New York. The handbook is a compilation of technical sections covering above and below ground piping systems and while it is an excellent reference for piping design, the methods of analysis and design of supports presented in this book are not the same as recommended in this catalog.
SUPPORT NO. TS-5
C copyright 2009. All rights reserved.

Britt Engineering, Inc. P.O.Box 320325 Birmingham, Al 35232-0325 (205) 951-5691

Design Considerations for FRP Piping Systems

TECHNICAL SECTION

tThe use of expansion joints and expansion loops are very rarely used in practice and the supports recommended in the handbook should not be used except in very light duty service. Layout of Piping Systems The preliminary piping layout for FRP piping is the same as for any other system (Figure 2). Once a general piping arrangement has been selected, an isometric of the system should be made and the following steps taken: Locate available support steel and establish the location of additional support steel as required. Existing bridges, pipe racks and building structural steel will establish the available support spacing. Locate anchors at each change in pipe direction and as close as possible to elbows. Locate riser supports and component supports. Riser supports can be tentatively located on 10 foot centers until calculations are made.
Nominal Wall Thickness Pipe Size (Inches)
Table 1 (Sample Only)

Establish support design criteria and pipe wall thickness required using the equations in the section on Support Designs factoring the operating temperature and pressure of the system. An iterative process is employed to obtain wall thickness and to define acceptable support spans. Tabulate support design criteria shown in Table 1 and rearrange support spacing and anchor locations on the isometric to meet design criteria. Add guides at locations determined in the table. Check offset leg requirements between anchors at directional changes. Relocate anchors as required to meet offset requirements. Rearrange riser support locations. The distance between centers should not exceed the guide spacing. In areas where offset leg requirements cannot be met, consideration should be given to rerouting the pipe to provide more flexibility.

Support Span (Inches) 8.3 9.6 12.3 13.1

Offset Leg (Inches) .47 .64 .82 .90 L L L L

Guide Spacing Anchor Load (Inches) (Inches) 11.5 16.7 28.0 33.7 3500 5200 9842 12250

4" 6" 10" 12"

.202 .202 .250 .265

LR FA

LO

FA FA LA LG

15

t) 0f

FA LA

ANCHOR GUIDE
Ls

15

t) 0f

SUPPORT RISER SUPPORT


FA

ANCHOR FORCE ANCHOR SPACING GUIDE SPACING SUPPORT SPACING

LG

LA LG Ls

Ly LO

Fig. 2 Typical pipe run

Britt Engineering, Inc. P.O.Box 320325 Birmingham, Al 35232-0325 (205) 951-5691

Design Considerations for FRP Piping Systems

SUPPORT NO. TS-6


C copyright 2009. All rights reserved.

TECHNICAL SECTION

Vibration Pump or equipment vibrations are usually absorbed by the piping system; however, it is a good practice to use an expansion joint with tie rods at the pump discharge if the discharge pipe can be anchored. Care must be exercised to insure that the pump is capable of handling the thrust loads and/or thermal loads that are developed by the fittings. Water Hammer There are several recommended methods for reducing water hammer effects. There are several air chamber designs available that will help reduce shock but the best method is to design the system so that slugging does not occur. Slowing the response time of the control valves to a minimum of eight to ten seconds will usually achieve this. Cavitation This is caused by a restriction in the line, such as a control valve, that causes a drop in local pressure due to high flow velocities through the restriction. Gate valves should be used where possible instead of butterfly valves.

Conclusions The experience at britt engineering has positively shown that the design approach used in this report will provide a satisfactory system if reasonable care and control is exercised when the pipe is installed. The supports, guides, and anchors shown in this catalog have been designed to match the analysis and support requirements for FRP pipe and have been proven through 18 years of service. The finish and/or coatings on the support should be selected to match the environmental conditions of the process system and should be specified by the designer. Standard finishes for britt engineering support are either epoxy primer or hot dip galvanize. Special coatings are available and britt engineering can assist the designer in the selection of the most cost efficient coating system.

Guide

Hanger

Component Support

Anchor

Support

Suggested Supports for FRP Pipe

Britt Engineering, Inc. P.O.Box 320325 Birmingham, Al 35232-0325 (205) 951-5691

Design Considerations for FRP Piping Systems

SUPPORT NO. TS-7


C copyright 2009. All rights reserved.

TECHNICAL SECTION

You might also like